IllustrationINTERMITTENT FAILURE OF POWER STEERING WHILE DRIVING A 2007 CHEVY COBALT WITH ONLY 49000 MILES ON IT. TO FIX IT TEMPORARILY YOU RESTART THE ENGINE, BUT WILL TURN OFF AGAIN A FEW MILES LATER. TO FIX IT YOU HAVE TO REPLACE THE POWER STEERING MOTOR WHICH REQUIRES REPLACING THE ENTIRE STEERING COLUMN. *TR
2007 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
Steering complaints
689 reportsMY HUSBAND AND I HAVE A 2007 CHEVY COBALT LTZ , FOR ABOUT THREE WEEKS WE HAD BEEN NOTICING VIBRATIONS IN THE STEERING. ALSO WHEN BRAKING THE STEERING WOULD SHAKE. DURING THAT TIME WE GOT A LETTER FROM OUR DEALERSHIP ABOUT THE SIDE AIRBAGS. THEY SAID THAT THEY HAD SOLD IT AS IF IT HAD SIDE AIRBAGS,BUT IT DIDN'T HAVE ANY.ON OUR W…
Read full complaint
MY HUSBAND AND I HAVE A 2007 CHEVY COBALT LTZ , FOR ABOUT THREE WEEKS WE HAD BEEN NOTICING VIBRATIONS IN THE STEERING. ALSO WHEN BRAKING THE STEERING WOULD SHAKE. DURING THAT TIME WE GOT A LETTER FROM OUR DEALERSHIP ABOUT THE SIDE AIRBAGS. THEY SAID THAT THEY HAD SOLD IT AS IF IT HAD SIDE AIRBAGS,BUT IT DIDN'T HAVE ANY.ON OUR WAY UP THERE TO THE DEALERSHIP WE BEGAN TO EXPERIENCE TIGHTNESS IN THE STEERING JUST AS WE STARTED ON THE INTERSTATE . WE HAD NOT GONE VERY FAR WHEN OUR COBALT BEGAN TO FISH TAIL AND MY HUSBAND WAS UNABLE TO CONTROL THE CAR AND WE THEN WENT INTO TWO 360S AND BEGAN TO ROLL ACCORDING TO WITNESSES WE ROLLED 4 OR 5 TIMES BEFORE THE CAR RESTED ON THE RIGHT SIDE. ALSO FRONT AIRBAGS DID NOT COME OUT. IT FELT AS IF THE CAR HAD NO POWER STEERING AT ALL. *TR
WITHIN A MONTH OF PURCHASING A NEW 2007 CHEVY COBALT - I BEGAN HEARING RATTLING NOISES FROM MY VEHICLE. I HAVE HAD THE CAR IN FOR REPAIRS NUMEROUS TIMES. MULTIPLE COMPONENTS HAVE BEEN REPLACED AND OR REPAIRED. I CURRENTLY HAVE 15,000 MILES ON THE VEHICLE - TO THIS DAY I CAN STILL HEAR RATTLING NOISES AND CLUNKING NOISE COMING …
Read full complaint
WITHIN A MONTH OF PURCHASING A NEW 2007 CHEVY COBALT - I BEGAN HEARING RATTLING NOISES FROM MY VEHICLE. I HAVE HAD THE CAR IN FOR REPAIRS NUMEROUS TIMES. MULTIPLE COMPONENTS HAVE BEEN REPLACED AND OR REPAIRED. I CURRENTLY HAVE 15,000 MILES ON THE VEHICLE - TO THIS DAY I CAN STILL HEAR RATTLING NOISES AND CLUNKING NOISE COMING FROM THE STEERING-SUSPENSION. THE MECHANICS HAVE NOW TOLD ME THEY DON'T KNOW WHAT'S WRONG AND SUGGESTED I TRY A DIFFERENT DEALERSHIP. I HAVE CONTACTED CHEVY AND RECEIVED NO HELP IN SETTLING THIS ISSUE. IF CHEVY WOULD OF HAD THEIR RETURN POLICY WHEN I PURCHASED - I WOULD OF GLADLY RETURNED THE VEHICLE - I MAKE CAR PAYMENTS ON A LEMON. I DON'T EVEN LIKE MY DAUGHTER TO RIDE IN THE VEHICLE FOR FEAR OF HER SAFETY. I FEAR I WILL BE DRIVING DOWN THE ROAD THE FRONT END WILL FALL APART. IT SCARES ME TO DEATH. *TR
I WAS DRIVING HOME AND WENT TO TAKE A RIGHT TURN WHEN THE STEERING WHEEL LOCKED. IT WAS VERY DIFFICULT TO TURN AND I WENT INTO THE OPPOSITE LANE. LUCKILY, THERE WERE NO CARS IN THE OTHER LANE. I MANAGED TO PULL OVER AND RESTART THE CAR. THE STEERING WORKED LONG ENOUGH TO GET ME BACK HOME. THIS IS A VERY DANGEROUS DEFECT AND NEED…
Read full complaint
I WAS DRIVING HOME AND WENT TO TAKE A RIGHT TURN WHEN THE STEERING WHEEL LOCKED. IT WAS VERY DIFFICULT TO TURN AND I WENT INTO THE OPPOSITE LANE. LUCKILY, THERE WERE NO CARS IN THE OTHER LANE. I MANAGED TO PULL OVER AND RESTART THE CAR. THE STEERING WORKED LONG ENOUGH TO GET ME BACK HOME. THIS IS A VERY DANGEROUS DEFECT AND NEEDS TO BE RECALLED. *TR
BOUGHT 2007 CHEVY COBALT USED FROM A LOCAL CAR DEALER LAST MARCH, WENT ON A FAMILY TRIP TO THE SMOKY MOUNTAINS AND WHILE GOING THROUGH THE MOUNTAINS POWER STEERING GOES COMPLETELY OUT. STOPPED AT THE VISITOR CENTER AND MY FATHER TRIES TO SEE WHAT IS WRONG. HE CANT FIND THE POWER STEERING PUMP/FLUID BECAUSE WE DIDN'T KNOW IT WAS …
Read full complaint
BOUGHT 2007 CHEVY COBALT USED FROM A LOCAL CAR DEALER LAST MARCH, WENT ON A FAMILY TRIP TO THE SMOKY MOUNTAINS AND WHILE GOING THROUGH THE MOUNTAINS POWER STEERING GOES COMPLETELY OUT. STOPPED AT THE VISITOR CENTER AND MY FATHER TRIES TO SEE WHAT IS WRONG. HE CANT FIND THE POWER STEERING PUMP/FLUID BECAUSE WE DIDN'T KNOW IT WAS ELECTRONIC. THE PROBLEM PERSISTED THROUGH OUT THE TRIP BUT AS WE GOT BACK THE PROBLEM SEEMED TO STOP, THEN A FEW WEEKS LATER THE POWER STEERING CONSTANTLY GOES OUT. THIS PROBLEM OCCURS EVERY TIME I DRIVE MY CAR, IT HAS MADE DRIVING AN ANNOYING TASK AND I HAVE COME CLOSE TO MULTIPLE COLLISIONS DURING THE FAILURE. THIS HAS ALSO CAUSED ME PHYSICAL PAIN IN BOTH MY WRIST AND ELBOW WHILE TRYING TO TURN MY CAR. NOTHING HAS BEEN DONE TO CORRECT THIS DUE TO LACK OF FINANCE AND MY RESEARCH ON THE TOPIC SAID IT COSTS AROUND $4000 TO CORRECT. *TR
WE BOUGHT A NEW 2007 COBALT AND NOW AT 43,000 MILES ONLY 7,000 MILES PAST WARRANTY THE POWER STEERING GOES OUT YOU CAN SHUT CAR OFF AND RESTART AND IT FIXES THE PROBLEM FOR A SHORT PERIOD OF TIME BUT THIS IS A ONGOING ISSUE WITH OTHER COBALTS WE HAVE CONTACTED GM AND THEY ARE UNWILLING TO FIX IT SO THAT'S WHY WE ARE HERE. *TR
POWER STEERING ON 2007 CHEVROLET COBALT GOES OUT CONSTANTLY. ITS ON WHEN YOU FIRST START THE CAR, BUT THEN GOES OFF AFTER A MILE OR SO OF DRIVING. POWER STEERING MOTOR WAS CHANGED TWICE, AND IT WORKED FOR ABOUT 2 WEEKS, THEN WENT RIGHT BACK TO THE OLD WAY. *TR
WHEN MAKING A U-TURN THE STEERING TURNS BY ITSELF TO THE STEERING LOCK ABOUT 1/2 TURN BEFORE HITTING THE STOP. IT HAPPENS BOTH DIRECTIONS BUT NOT WHEN DOING THIS IN REVERSE GEAR. IT BECOMES HARD TO CORRECT UNTIL THE STEERING WHEEL IS TURNED ABOUT 1 TURN BACK TOWARDS CENTER. IT ALMOST FEELS LIKE THE WHEELS ARE GOING PAST CENTER A…
Read full complaint
WHEN MAKING A U-TURN THE STEERING TURNS BY ITSELF TO THE STEERING LOCK ABOUT 1/2 TURN BEFORE HITTING THE STOP. IT HAPPENS BOTH DIRECTIONS BUT NOT WHEN DOING THIS IN REVERSE GEAR. IT BECOMES HARD TO CORRECT UNTIL THE STEERING WHEEL IS TURNED ABOUT 1 TURN BACK TOWARDS CENTER. IT ALMOST FEELS LIKE THE WHEELS ARE GOING PAST CENTER AND THAT IS WHY IT IS HARD TO CORRECT. IT IS IN THE DEALER FOR THIS PROBLEM. *TR
IT WAS RUNNING SMOOTH UNTIL ABOUT ROUGHLY A YEAR THEN JUST A FEW WEEKS AGO THE POWER STEERING WENT OUT AND THE WARNING LIGHTS CAME ON. IT WAS TAKEN BACK TO THE DEALER THEY DIDN'T FIND ANYTHING WRONG WITH IT AND SAID NOTHING CAN BE DONE UNTIL ITS RECALLED. YOU CAN'T STEER IT, YOU NEED TO RESTART YOUR CAR AND HOPE IT GOES AWAY. I…
Read full complaint
IT WAS RUNNING SMOOTH UNTIL ABOUT ROUGHLY A YEAR THEN JUST A FEW WEEKS AGO THE POWER STEERING WENT OUT AND THE WARNING LIGHTS CAME ON. IT WAS TAKEN BACK TO THE DEALER THEY DIDN'T FIND ANYTHING WRONG WITH IT AND SAID NOTHING CAN BE DONE UNTIL ITS RECALLED. YOU CAN'T STEER IT, YOU NEED TO RESTART YOUR CAR AND HOPE IT GOES AWAY. IT SEEMS LIKE WHEN THE ENGINE OR THE CAR IS WARM IT GOES OUT. I AM A COLLEGE STUDENT WHO HAS TO COMMUTE FROM HOME BY GOING ON HIGHWAYS AND BUSY STREETS THIS ISN'T SAFE! PARENTS BUY THESE CARS FOR THEIR TEENAGERS. EVERYONE WHO OWN THIS CAR HAS THIS ISSUE AND WAITING FOR AN ANSWER. MANY LIVES ARE BEING PUT AT RISK BECAUSE OF THIS PROBLEM. PLEASE DON'T WAIT UNTIL AN ACCIDENT HAPPENS AND LIVE(S) ARE TAKEN AWAY BECAUSE YOU HAVE TO WAIT FOR ENOUGH PEOPLE TO COMPLAIN. PLEASE RECALL IT AND GET IT SOLVED. BEFORE SOMETHING SERIOUS HAPPENS TO SOMEONE(S). PLEASE HELP EVERYONE! *TR
I HAVE A CHEVY COBALT LS AND IN HAVING A PROBLEM WITH THE POWER STEERING BUT IT DOESN'T HAVE A PLACE TO PUT IT ON IT AND I WAS DIVING AND IT MAKE ME HAVE A ACCIDENT. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.