IllustrationSTEERING FAILURE. THE VEHICLE'S ELECTRICAL POWER STEERING GOES OUT VERY OFTEN. *TR
2007 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
Steering complaints
689 reportsTL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT SPEEDS UNDER 40 MPH THE POWER STEERING FAILED AND IT BECAME DIFFICULT TO CONTROL THE VEHICLE. THE VEHICLE WAS TAKEN TO THE CLOSEST DEALER WHO REPAIRED THE POWER STEERING PUMP AND THE STEERING COLUMN. THE STEERING MOTOR WAS ALSO REPLACED. THERE WERE NO ADDITIONAL FAILU…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT SPEEDS UNDER 40 MPH THE POWER STEERING FAILED AND IT BECAME DIFFICULT TO CONTROL THE VEHICLE. THE VEHICLE WAS TAKEN TO THE CLOSEST DEALER WHO REPAIRED THE POWER STEERING PUMP AND THE STEERING COLUMN. THE STEERING MOTOR WAS ALSO REPLACED. THERE WERE NO ADDITIONAL FAILURES SINCE THE VEHICLE WAS REPAIRED. THERE WERE NO RECALLS. THE CURRENT AND FAILURE MILEAGES WERE UNDER 47,000.
I HAVE A 2007 CHEVY COBALT. ON 01/30/10 I WAS DRIVING DOWN THE ROAD WHEN I HEARD "DING DING DING" I LOOKED DOWN TO MY DASH BOARD AND SAW IT SAID "POWER STEERING" MY CAR THEN GOT REALLY HARD TO STEER. SO I PULLED OVER AND TURNED MY CAR OFF AND THEN BACK ON AND I WAS ABLE TO STEER FINE AGAIN. SINCE THEN I HAVEN'T WANTED TO DRIVE M…
Read full complaint
I HAVE A 2007 CHEVY COBALT. ON 01/30/10 I WAS DRIVING DOWN THE ROAD WHEN I HEARD "DING DING DING" I LOOKED DOWN TO MY DASH BOARD AND SAW IT SAID "POWER STEERING" MY CAR THEN GOT REALLY HARD TO STEER. SO I PULLED OVER AND TURNED MY CAR OFF AND THEN BACK ON AND I WAS ABLE TO STEER FINE AGAIN. SINCE THEN I HAVEN'T WANTED TO DRIVE MY CAR, IN FEAR THAT I WILL NOT BE ABLE TO STEER. I RESEARCHED THIS PROBLEM AND I SAW THAT ALOT OF PEOPLE ARE ALSO HAVING THE SAME PROBLEMS WITH THEIR COBALTS. THIS IS NOT OUR FAULT SO WE SHOULDN'T HAVE TO PAY TO GET IT FIXED. *TR
I AM VERY UPSET AT THE FACT THAT I JUST READ ALL THE COMPLAINTS ON THE ELECTRICAL POWER STEERING IN THE CHEVROLET COBALT. THE SAME PROBLEM I HAVE. I WORK AND PAY MONTHLY PAYMENTS ON A 2007 CHEVROLET COBALT LS THAT IS HAVING THESE PROBLEMS. GM SHOULD DO SOMETHING, OR IS IT GOING TO BE WHEN SOMEONE DIES AS A RESULT OF THIS. STEERI…
Read full complaint
I AM VERY UPSET AT THE FACT THAT I JUST READ ALL THE COMPLAINTS ON THE ELECTRICAL POWER STEERING IN THE CHEVROLET COBALT. THE SAME PROBLEM I HAVE. I WORK AND PAY MONTHLY PAYMENTS ON A 2007 CHEVROLET COBALT LS THAT IS HAVING THESE PROBLEMS. GM SHOULD DO SOMETHING, OR IS IT GOING TO BE WHEN SOMEONE DIES AS A RESULT OF THIS. STEERING IS A VERY IMPORTANT COMPONENT TO A VEHICLE. I REFUSE TO PAY THE LARGE AMOUNT OF MONEY THAT IT'S GOING TO COST TO GET IT FIXED AND THE DEALER CAN'T PROMISE IT WON'T HAPPEN AGAIN. PEOPLE INVEST MONEY INTO A NEWER CAR NOT TO HAVE TO PAY FOR PROBLEMS THIS EARLY ON!. MY CAR EVENS STALLS ONCE IN AWHILE WHEN I FIRST START IT AND WITHOUT EVEN MASHING THE GAS YOU'LL HEAR THE IGNITION RUN HARD FOR A FEW SECONDS LIKE IT'S STARTING ITSELF. *TR
I DRIVE A 2007 CHEVROLET COBALT LS. THE ELECTRIC POWER STEERING BEGAN TO CLICK OFF AND ON THEN THIS PAST MONTH HAS GONE COMPLETELY OFF. IT IS EXTREMELY DIFFICULT TO STEER MY CAR WHICH CAN LEAD TO AN ACCIDENT AND/OR HARM TO MYSELF. I NEED TO GET TO AND FROM WORK AND CAN NOT AFFORD TO NOT DRIVE MY CAR. I CALLED A CHEVY DEALERSHIP …
Read full complaint
I DRIVE A 2007 CHEVROLET COBALT LS. THE ELECTRIC POWER STEERING BEGAN TO CLICK OFF AND ON THEN THIS PAST MONTH HAS GONE COMPLETELY OFF. IT IS EXTREMELY DIFFICULT TO STEER MY CAR WHICH CAN LEAD TO AN ACCIDENT AND/OR HARM TO MYSELF. I NEED TO GET TO AND FROM WORK AND CAN NOT AFFORD TO NOT DRIVE MY CAR. I CALLED A CHEVY DEALERSHIP AND THE AMOUNT OF MONEY THAT HAS TO GO INTO THIS IS QUITE A BIT. I'M AM VERY UPSET DUE TO THE SIMPLE FACT THAT MY CAR IS A 2007 AND THIS IS SOMETHING I SHOULD NOT HAVE TO WORRY ABOUT RIGHT NOW. AND ON TOP OF THAT EVER SINCE MY POWER STEERING IS OUT MY ENGINE LIGHT IS ON. *TR
POWER STEERING COLUMN, GEARS WHEEL RATTLE, AND ARE LOOSE. FIX IS 2K. OUT OF MY POCKET TO REPLACE IT. THIS IS CRITICAL. *TR
POWER STEERING WENT OUT ON MY CHEVY COBALT WITHOUT WARNING. *TR
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE STEERING COLUMN FAILED. WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A TURN THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT TURNED THE VEHICLE ON AND OFF SO THAT THE STEERING WHEEL WOULD RESET ITSELF. THE GM MANUFACTURER WAS CONTACTED AND STATED T…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE STEERING COLUMN FAILED. WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A TURN THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT TURNED THE VEHICLE ON AND OFF SO THAT THE STEERING WHEEL WOULD RESET ITSELF. THE GM MANUFACTURER WAS CONTACTED AND STATED THAT THE PARTS HAVE BEEN ORDERED. THE FAILURE MILEAGE WAS 47,000.
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 20 TO 25 MPH ON NORMAL ROAD CONDITIONS THE "POWER STEERING" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER EXERTED HIGHER EFFORT TO TURN THE STEERING WHEEL AND DROVE INTO A SERVICE …
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 20 TO 25 MPH ON NORMAL ROAD CONDITIONS THE "POWER STEERING" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER EXERTED HIGHER EFFORT TO TURN THE STEERING WHEEL AND DROVE INTO A SERVICE STATION. THE ENGINE WAS TURNED OFF. THE VEHICLE RESUMED OPERATION WITHOUT POWER STEERING. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE I S IN THE PROCESS OF BEING TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE MILEAGE WAS 43,900.
MY 2007 CHEVY COBALT IS HAVING INTERMITTENT FAILURE WITH THE POWER STEERING. IT RANDOMLY OCCURS, WITH NO WARNING. THE "POWER STEERING" WARNING LIGHT APPEARS ON THE DISPLAY AND I LOSE ALL POWER STEERING ABILITY. THIS CAUSES MY VEHICLE TO BECOME UNMANAGEABLE AND FEEL RATHER UNSAFE TO DRIVE. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.