IllustrationSTEERING FAILURE LIGHT COMES ON. STEERING IS ERRATIC. *TR
2007 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
Steering complaints
689 reportsWHILE DRIVING AT SLOWER SPEEDS THE ELECTRIC POWER ASSIST STEERING STOPS WORKING. THIS HAS ONLY HAPPENED 4 TIMES BUT IT IS VERY SCARY ALMOST RESULTING IN 1 ACCIDENT. I REFUSE TO PAY THE MONEY THEY WANT TO CHANGE THE POWER ASSIST MOTOR WHEN IT SHOULD BE FIXED FOR FREE AS A SAFETY PROBLEM. ALSO I WOULD HATE FOR GM TO PUT THE SAME T…
Read full complaint
WHILE DRIVING AT SLOWER SPEEDS THE ELECTRIC POWER ASSIST STEERING STOPS WORKING. THIS HAS ONLY HAPPENED 4 TIMES BUT IT IS VERY SCARY ALMOST RESULTING IN 1 ACCIDENT. I REFUSE TO PAY THE MONEY THEY WANT TO CHANGE THE POWER ASSIST MOTOR WHEN IT SHOULD BE FIXED FOR FREE AS A SAFETY PROBLEM. ALSO I WOULD HATE FOR GM TO PUT THE SAME TYPE OF PART IN INSTEAD OF A SAFER UPDATED ONE. I DO NOT WANT TO HAVE A FALSE SENSE OF SECURITY. SAYING THERE HAS NOT BEEN ANY DEATHS IS NOT A VALID DEFENSE. JUST THINK ABOUT TURNING RIGHT FROM A SIDE STREET ONTO A BUSY ROAD AND YOUR STEERING ASSIST GOES OUT. YOU RUN ALMOST HEAD ON INTO A MINIVAN WITH A MOTHER DRIVING 4 CHILDREN TO SCHOOL. THE MINIVAN BOUNCES OFF OF YOUR CAR AND THEN OFF OF A GUARD RAIL ON THE OTHER SIDE ON THE ROAD. THE MINIVAN FLIPS ON ITS SIDE KILLING TWO OF THE CHILDREN AND SERIOUSLY INJURING THE MOTHER. IS THIS AN ACCEPTABLE LOSS AS LONG AS GM DOES NOT HAVE TO PAY OUT ANY MONEY FOR A RECALL? AS FAR AS I AM CONCERNED THE PEOPLE AT GM WHO ARE SAYING THE POWER STEERING ASSIST IS NOT A PROBLEM WOULD BE GUILTY OF MURDER IF THEY MADE EVERY ATTEMPT TO NOT FIX AN UNSAFE CONDITION. JUST A SHORT STORY AND JUST MY OPINION. *TR
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. SHE STATED WHILE DRIVING AT SPEEDS OF LESS THAN 60 MPH ON THE HIGHWAY IN LIGHT RAIN CONDITIONS, SHE HEARD A LOUD BOOM AND SCREECHING SOUND. IMMEDIATLEY AFTERWARD, THE VEHICLE BEGAN TO PULL TO THE LEFT. SHE ATTEMPTED TO STEER THE VEHICLE OFF THE HIGHWAY HOWEVER, THE VEHICLE WOULD NOT …
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. SHE STATED WHILE DRIVING AT SPEEDS OF LESS THAN 60 MPH ON THE HIGHWAY IN LIGHT RAIN CONDITIONS, SHE HEARD A LOUD BOOM AND SCREECHING SOUND. IMMEDIATLEY AFTERWARD, THE VEHICLE BEGAN TO PULL TO THE LEFT. SHE ATTEMPTED TO STEER THE VEHICLE OFF THE HIGHWAY HOWEVER, THE VEHICLE WOULD NOT RESPOND TO HER STEERING. SHE THEN TAPPED ON THE BRAKES AND THE VEHICLE SPUN OUT OF CONTROL UNTIL THE VEHICLE WAS NOW PROCEEDING BACKWARD. THE VEHICLE THEN PROCEEDED UP A NEARBY GRASSY HILL, TURNING OUT OF CONTROL UNTIL SHE WAS ABLE TO TURN THE VEHICLE FRONT WARD. THE BRAKES AND STEERING STILL WOULD NOT RESPOND TO DRIVER INITIATION. THE VEHICLE THEN PROCEEDED BACK DOWN THE GRASSY HILL AND BACK TOWARD TRAFFIC. THE VEHICLE STOPPED ONCE BACK ONTO THE CEMENT PAVEMENT. THE FRONT DRIVER'S SIDE WHEEL WAS TOTALLY COLLAPSED OUTWARD AND THE TIRE WAS SHREDDED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY FOUND THE RACK AND PINION FAILED, HOWEVER THEY WOULD NOT TAKE ANY LIABILITY FOR THE FAILURES. THEY STATED SHE MUST HAVE HIT SOMETHING IN THE HIGHWAY TO HAVE EXPERIENCED CATASTROPHIC FAILURES. THE CONTACT WAS SURE SHE DID NOT HIT ANYTHING IN THE ROAD AND THE FAILURE WAS UNEXPECTED AND UNEXPLAINED. NO REPAIRS WERE MADE TO THE VEHICLE, TO DATE. THE FAILURE AND CURRENT MILEAGES WERE 51,000.
AROUND 46,000 MILES ON MY 2007 CHEVY COBALT I WAS DRIVING ON THE HIGHWAY DRIVING TO A DIFFERENT TOWN, WHEN GOING TO TURN MY POWER STEERING WENT OUT. I FILED A COMPLAINT TO CHEVROLET BUT SOMEONE TOLD ME TO DO IT HERE TOO. *TR
I HAVE A 2007 CHEVY COBALT. I WAS DRIVING DOWN THE INTERSTATE WHEN MY POWER STEERING LIGHT CAME ON AND I LOST MY POWER STEERING. WHEN I STOPPED THE CAR AND RESTARTED IT I HAD POWER STEERING FOR A FEW MILES BEFORE IT WENT OUT AGAIN. THE NEXT DAY I DROVE APPROX 135 MILES BEFORE IT WENT OUT AGAIN. I TOOK THE CAR TO THE GARAGE O…
Read full complaint
I HAVE A 2007 CHEVY COBALT. I WAS DRIVING DOWN THE INTERSTATE WHEN MY POWER STEERING LIGHT CAME ON AND I LOST MY POWER STEERING. WHEN I STOPPED THE CAR AND RESTARTED IT I HAD POWER STEERING FOR A FEW MILES BEFORE IT WENT OUT AGAIN. THE NEXT DAY I DROVE APPROX 135 MILES BEFORE IT WENT OUT AGAIN. I TOOK THE CAR TO THE GARAGE ON 2-1-2010 AND THEY REPLACED MY POWER STEERING MOTOR AT A COST OF $390.00. *TR
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH ON NORMAL ROAD CONDITIONS. A CHIME SENSOR SOUNDED INSIDE OF THE VEHICLE AND THE "POWER STEERING" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER PULLED OVER TO TH…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH ON NORMAL ROAD CONDITIONS. A CHIME SENSOR SOUNDED INSIDE OF THE VEHICLE AND THE "POWER STEERING" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF. THE VEHICLE RESTARTED AND RESUMED OPERATION. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 53,500.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHENEVER THE CONTACT WOULD DRIVE THE VEHICLE AT ANY SPEED SHE NOTICED THAT THE POWER STEERING WOULD SUDDENLY STOP WORKING MAKING THE VEHICLE EXTREMELY DIFFICULT TO TURN. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MIL…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHENEVER THE CONTACT WOULD DRIVE THE VEHICLE AT ANY SPEED SHE NOTICED THAT THE POWER STEERING WOULD SUDDENLY STOP WORKING MAKING THE VEHICLE EXTREMELY DIFFICULT TO TURN. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 46000.
I OWN A 2007 CHEVY COBALT LS. ON MORE THEN 10 OCCASIONS, I'VE HAD MY CAR IN REVERSE TO PULL INTO A PARKING SPOT OR OPERATING MY CAR AT LOW SPEED WHILE TRYING TO MAKE A TURN EITHER LEFT OR RIGHT. I WILL GET A MESSAGE IN THE MESSAGE CENTER THAT SAYS CHECK POWERING STEERING, AND THE POWER STEERING WILL GO OUT ON THE VEHICLE MAKING …
Read full complaint
I OWN A 2007 CHEVY COBALT LS. ON MORE THEN 10 OCCASIONS, I'VE HAD MY CAR IN REVERSE TO PULL INTO A PARKING SPOT OR OPERATING MY CAR AT LOW SPEED WHILE TRYING TO MAKE A TURN EITHER LEFT OR RIGHT. I WILL GET A MESSAGE IN THE MESSAGE CENTER THAT SAYS CHECK POWERING STEERING, AND THE POWER STEERING WILL GO OUT ON THE VEHICLE MAKING IT VIRTUALLY IMPOSSIBLE TO NAVIGATE. TO TEMPORARILY CORRECT THIS PROBLEM, I MUST TURN THE CAR OFF AND RESTART IT, IT THEN OPERATES AS NORMAL. *TR
CAR POWER STEERING LOCKS UP. ENGINE ROUGH IDLE LOSS OF POWER. *TR
I KNEW EVER SINCE I PURCHASED THE VEHICLE WITH 29,000 MILES THAT THERE WAS A PROBLEM WITH THE POWER STEERING MOTOR ON MY 2007 CHEVY COBALT. DURING A DRIVING TEST, MY DAUGHTER COULDN'T TURN THE WHEEL. THE MOTOR OVERHEATED. WE TOOK IT TO A AUTO SHOP AND THEY SAID THE MOTOR WILL CONTINUE TO DO IT BECAUSE OF THE WAY IT WAS MADE AN…
Read full complaint
I KNEW EVER SINCE I PURCHASED THE VEHICLE WITH 29,000 MILES THAT THERE WAS A PROBLEM WITH THE POWER STEERING MOTOR ON MY 2007 CHEVY COBALT. DURING A DRIVING TEST, MY DAUGHTER COULDN'T TURN THE WHEEL. THE MOTOR OVERHEATED. WE TOOK IT TO A AUTO SHOP AND THEY SAID THE MOTOR WILL CONTINUE TO DO IT BECAUSE OF THE WAY IT WAS MADE AND THERE WAS NOTHING HE COULD DO BUT THAT I SHOULD COMPLAIN TO CHEVY. ONE DAY IN NOVEMBER 2009, IT OVERHEATED AND I COULDN'T TURN THE WHEEL WHICH CAUSED ME TO RUN UP A CURB. MY TIRE WAS DAMAGED AND I HAD TO BE TOWED TO A REPAIR SHOP. IT COST ME 50.00 FOR THE TOW AND AROUND 200.00 FOR A NEW TIRE, WHEEL ALIGNMENT AND LABOR. THE MECHANIC SAID IT IS A BAD DESIGN, THAT THEY SHOULD'VE REMOVED THE MOTOR AND REPLACED IT WITH A TRADITIONAL PUMP. HE SAID THAT WILL BE THE ONLY WAY TO CORRECT THE PROBLEM. IT OVERHEATS DAILY AND IT IS IMPOSSIBLE TO STEER-ESPECIALLY FOR A SMALL FEMALE. CHEVY SHOULD HAVE TO REPLACE THESE MOTORS BEFORE SOMEONE GETS KILLED. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.