IllustrationTHE POWER STEERING WAS MAKING SOME SORT OF NOISY SOUND THEN IT WAS NOT EASY TO CONTROL. I HAD TO PARK THE CAR AND TURN IT OFF.
2007 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
Steering complaints
689 reportsTL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS COASTED OVER TO THE SIDE OF THE ROAD AND TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING). THE MANU…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS COASTED OVER TO THE SIDE OF THE ROAD AND TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
I HAVE 07 COBALT WITH 45000 MILES ON IT HAS A RATTLE IN STEERING COLUMN, ELECTRIC MOTOR WAS REPLACED BY RECALL, NOW PLASTIC GEAR IS WORN CAUSING NOISE. REQIRES COLUM BEING REPLACE AT A COST OG $800.00 FOR PART PLUS LABOR.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE THE VEHICLE WAS STATIONARY, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE STEERING WHEEL SEIZED ON MORE THAN ONE OCCASION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 169,000.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHEN THE VEHICLE WAS PARKED, THE CONTACT SMELLED FUEL. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING LOST POWER AND THE POWER STEERING AND CHECK ENGINE LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO STATED THAT A RECALL REPAIR WAS PREVIOUSLY PERFORMED AND WOULD NOT…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHEN THE VEHICLE WAS PARKED, THE CONTACT SMELLED FUEL. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING LOST POWER AND THE POWER STEERING AND CHECK ENGINE LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO STATED THAT A RECALL REPAIR WAS PREVIOUSLY PERFORMED AND WOULD NOT BE REPEATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT NOTHING COULD BE DONE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE POWER STEERING FAILED AND THE BATTERY WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING MOTOR , KEYS AND THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE POWER STEERING FAILED AND THE BATTERY WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING MOTOR , KEYS AND THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. THE VIN WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. AFTER HAVING THE VEHICLE REPAIRED FOR THE IGNITION KEY TO BE REMOVED FROM THE STARTER, THE ENGINE LIGHT ILLUMINATED AND THE STEERING WAS IN DIC MODE. ALSO, THE POWER STEERING FAILED. WHEN DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE ACCORDINGLY. THE CONTACT TOOK…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. AFTER HAVING THE VEHICLE REPAIRED FOR THE IGNITION KEY TO BE REMOVED FROM THE STARTER, THE ENGINE LIGHT ILLUMINATED AND THE STEERING WAS IN DIC MODE. ALSO, THE POWER STEERING FAILED. WHEN DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE ACCORDINGLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE VEHICLE WAS REPAIRED WITH AN AFTERMARKET PART THAT NEEDED TO BE REPLACED. THE PART WAS REPLACED, BUT THE FAILURE RECURRED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED NO RESOLUTION. THE APPROXIMATE FAILURE MILEAGE WAS 43,703.
FIRST I EXPERIENCED FULE EXCEL RATION. CALLED MANUFACTURE TOLD ME I WAS EXPERIENCING A KNOWN PROBLEM BUT MY VIN WAS NOT ON THE RECALL LIST. TOOK IT IN FOR IGNITION RECALL SHORTLY AFTER MY HEAD LIGHTS DIM OR ONE GOES OUT THEN IT COMES BACK ON THEN THE OTHER ONE WILL GO OUT OR DIM TOOK IT TO MACHANIC THEY FIXED IT BUT IT IS NOW DO…
Read full complaint
FIRST I EXPERIENCED FULE EXCEL RATION. CALLED MANUFACTURE TOLD ME I WAS EXPERIENCING A KNOWN PROBLEM BUT MY VIN WAS NOT ON THE RECALL LIST. TOOK IT IN FOR IGNITION RECALL SHORTLY AFTER MY HEAD LIGHTS DIM OR ONE GOES OUT THEN IT COMES BACK ON THEN THE OTHER ONE WILL GO OUT OR DIM TOOK IT TO MACHANIC THEY FIXED IT BUT IT IS NOW DOING THE SAME THING THEN THE POWER STEERING SUNDENLY WENT OUT ALMOST HAD A COLLISON LIGHT NEVER CAME ON. RESTARTED THE CAR EVERYTHING WORKED THEN POWER STEERING LIGHT CAME ON TOOK IT TO MACHCANIC TURNED THE CAR OFF TO HAVE HIM CHECK IT HE PULLED IT IN TO THE SHOP AND LIGHT WAS NOT ON. SO HE TOLD ME I HAD TO BRING IT BACK WHEN LIGHT CAME ON IN ORDER TO RUN A TEST. LIGHT NEVER CAME BACK ON THEN 5 DAYS AGO LOST POWER STEERING AGAIN ALMOST HAD AN ACCIDENT. IF I AM AT A COMPLETE STOP IN TRAFFIC OR AT A RED LIGHT THE CAR WILL EXCILERATE WITH OUT ME TOUCHING THE GAS WHEN I BREAK TO KEEP FROM HITTING THE VEHICLE IN FRONT OF ME THE REAR END WILL FISH TAIL. I AM 60 YEARS OLD THIS CAR HAS ALMOST CAUSED ME TO HAVE SEVERAL ACCIDENTS. IT IS UNSAFE THE MANUFACTURER ADMITTED WHEN I TOOK IT IN FOR THE IGNITION SWITCH THAT THERE WERE ISSUES WITH THE PROMLEMS I HAVE BEEN EXPERIENCING BUT MY VIN WAS ONLY ON THE IGNITION RECALL. THEY TOLD ME THE DEALER WOULD FIX THEM AT MY EXPENCE. I GET 950. DOLLARS A. MONTH AND HAVE CANCER. I HAVE NO MEANS TO PAY FOR THE DEFECTS IN 2012 MY DAUGHTER BOUGHT ME THE CAR AND PAID 10,000.00 FOR IT. I HAVE NO OTHER MEANS OF TRANSPORTATION TO MY DOCTORS ECT. PLEASE HELP ME. WHILE DRIVING AT NIGHT MY HEAD LIGHT WILL DIM OR ONE WILL COMPLETELY GO OUT. CAUSING ME TO ALMOST MISS THE EXIT AND RUN OFF AN EMBANKMENT.
MY POWER STEERING IS GOING OUT. I CALLED ABOUT THE RECALL, BUT SINCE THEY CLAIM IT IS FIXED, THEY WILL NOT REDO THE RECALL WORK. IT IS OBVIOUS THAT THE REPAIR WORK THEY DID, DID NOT FIX THE ISSUE COMPLETELY. I WAS DRIVING AND WHEN I TURN THE WHEEL IT WILL NOT RETURN TO THE NORMAL POSITION. SO, I HAVE TO MANUALLY DO IT, WHICH…
Read full complaint
MY POWER STEERING IS GOING OUT. I CALLED ABOUT THE RECALL, BUT SINCE THEY CLAIM IT IS FIXED, THEY WILL NOT REDO THE RECALL WORK. IT IS OBVIOUS THAT THE REPAIR WORK THEY DID, DID NOT FIX THE ISSUE COMPLETELY. I WAS DRIVING AND WHEN I TURN THE WHEEL IT WILL NOT RETURN TO THE NORMAL POSITION. SO, I HAVE TO MANUALLY DO IT, WHICH MAKES THE VEHICLE SWERVE. IT IS DANGEROUS, AND A KNOWN PROBLEM.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 40 MPH AND MAKING A TURN, THE POWER STEERING SEIZED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS R…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 40 MPH AND MAKING A TURN, THE POWER STEERING SEIZED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.