NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
19 reportsClear category filterMileage unknown · Apr 23, 2025
Electrical SystemService Brakes, HydraulicSteering
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving approximately 35 MPH, the power steering warning light illuminated, and the contact had to manually steer the vehicle. The contact continued to drive the vehicle without power steering functionality. The contact stated that additional electrical fail…
Read full complaint
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving approximately 35 MPH, the power steering warning light illuminated, and the contact had to manually steer the vehicle. The contact continued to drive the vehicle without power steering functionality. The contact stated that additional electrical failures had occurred. The contact also stated that the ABS activated and deactivated independently, and the traction control became inoperable. The instrument panel also became inoperable, and the contact was unable to see the speedometer and fuel gauge functions on the instrument panel. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown. The VIN was not available.
NHTSA ODI #11656377
84,000 miles · Jul 8, 2013
Electrical SystemService Brakes, HydraulicSteeringCrash
VEHICLE WAS RECALLED AROUND 2010 FOR STEERING AND FIXED. SINCE THEN NUMEROUS ELECTRICAL FAILURES, POWER BRAKES, AND STEERING FAILURES HAVE HAPPENED. VEHICLE HAS BEEN IN DEALER AND NUMEROUS OTHER SHOPS OVER THE YEARS FOR SAME PROBLEMS. CHEVY DEALER (KERRY CHEVROLET IN ALEXANDRIA KENTUCKY), WHERE CAR WAS BOUGHT KEPT SAYING THEY DI…
Read full complaint
VEHICLE WAS RECALLED AROUND 2010 FOR STEERING AND FIXED. SINCE THEN NUMEROUS ELECTRICAL FAILURES, POWER BRAKES, AND STEERING FAILURES HAVE HAPPENED. VEHICLE HAS BEEN IN DEALER AND NUMEROUS OTHER SHOPS OVER THE YEARS FOR SAME PROBLEMS. CHEVY DEALER (KERRY CHEVROLET IN ALEXANDRIA KENTUCKY), WHERE CAR WAS BOUGHT KEPT SAYING THEY DID NOT KNOW WHAT WAS WRONG. EVEN AFTER HUNDREDS OF DOLLARS SPENT TO FIX, PROBLEMS EVENTUALLY CAME BACK ( ELECTRICAL FAILURE, GAUGES FLUTTERING, RADIO FLASHING, STEERING LOCK, POWER BRAKE FAILURE). THIS PAST WEEKEND, GAUGES STARTED FLUTTERING, STEERING LOCKED UP WHILE DRIVING AND CAR WENT INTO A SPIN RUNNING OFF THE ROAD. CHEVROLET DEALER HAS ALWAYS PASSED ALL THESE THINGS OFF AS NOT THEIR PROBLEM. I WOULD LIKE ANY INFO ON WHAT CAN BE DONE ABOUT THIS. WE ARE NOW AFRAID TO HAVE VEHICLE FIXED AGAIN AND DRIVE IT FEARING STEERING MAY LOCK WHILE DRIVING AT A FASTER SPEED. AT LEAST THIS POWER FAILURE HAPPENED AT A LOW SPEED AND NO ONE IN THE OTHER LANE DURING SPIN. NEXT TIME MIGHT NOT BE SO LUCKY. PLEASE GIVE US ANY INFO ON WHAT CAN BE DONE. THANK YOU. *TR
NHTSA ODI #10523692
70,000 miles · Jan 30, 2013
Service Brakes, Hydraulic
THE TRACTION AND ABS LIGHT FREQUENTLY COMES ON. I'M NOT SURE IF IT SOMETHING THAT I SHOULD BE WORRIED ABOUT, OR IF IT IS SOMETHING THAT JUST HAPPENS. *TR
NHTSA ODI #10495210
70,000 miles · Dec 26, 2012
Service Brakes, HydraulicSteeringCrashInjury
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, SHE DEPRESSED THE BRAKE PEDAL AND THE STEERING WHEEL INDEPENDENTLY TURNED TO THE LEFT, CAUSING THE VEHICLE TO CRASH INTO A BRICK WALL. THE AIR BAGS DEPLOYED HOWEVER, THE CONTACT WAS TRANSPORTED TO THE HOSPITAL FOR TREATMENT OF INJURIES TO…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, SHE DEPRESSED THE BRAKE PEDAL AND THE STEERING WHEEL INDEPENDENTLY TURNED TO THE LEFT, CAUSING THE VEHICLE TO CRASH INTO A BRICK WALL. THE AIR BAGS DEPLOYED HOWEVER, THE CONTACT WAS TRANSPORTED TO THE HOSPITAL FOR TREATMENT OF INJURIES TO HER LEFT FOOT, ANKLE WRIST AND PAINS TO HER CHEST. THE CONTACT HAD TO BE CUT OUT OF THE VEHICLE, WHICH WAS DESTROYED. A POLICE REPORT WAS FILED OF THE INCIDENT. THE CAUSE OF FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 70,000. *TR
NHTSA ODI #10490093
15,000 miles · Sep 29, 2011
Fuel System, GasolineService Brakes, HydraulicSteering
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THE FRONT SUSPENSION CAUSED THE TWO FRONT TIRES TO BE WORN. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED AN ALIGNMENT BUT THE VEHICLE CONTINUED TO PULL TO THE LEFT. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 15,000 AND TH…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THE FRONT SUSPENSION CAUSED THE TWO FRONT TIRES TO BE WORN. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED AN ALIGNMENT BUT THE VEHICLE CONTINUED TO PULL TO THE LEFT. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 26,000. UPDATED 03/23/12*LJ THE CONSUMER STATED THE POWER STEERING, BRAKES AND GAS TANK NEEDED TO REPLACED.UPDATED 04/09/12
NHTSA ODI #10427891
40,000 miles · Mar 31, 2011
Electrical SystemService Brakes, HydraulicSuspension
I HAVE A 2007 COLBALT LT AND HAD TO HAVE THE BRAKES AND STRUTS REPLACED AT 40,000 MILES. THE FRONT OF THE CAR WAS SHAKING WHEN PUTTING ON THE BRAKES AND HAD A LOUD NOISE. I TOOK THE CAR TO A REPAIR SHOP WHEN THEY REPLACED THE BRAKES AND STRUTS. THE STRUTS SHOULDN'T GO UP THIS QUICK. NOW THE KEY GETS STUCK IN THE IGNITION. *…
Read full complaint
I HAVE A 2007 COLBALT LT AND HAD TO HAVE THE BRAKES AND STRUTS REPLACED AT 40,000 MILES. THE FRONT OF THE CAR WAS SHAKING WHEN PUTTING ON THE BRAKES AND HAD A LOUD NOISE. I TOOK THE CAR TO A REPAIR SHOP WHEN THEY REPLACED THE BRAKES AND STRUTS. THE STRUTS SHOULDN'T GO UP THIS QUICK. NOW THE KEY GETS STUCK IN THE IGNITION. *TR
NHTSA ODI #10393811
96,867 miles · Oct 19, 2010
Service Brakes, Hydraulic
I DROVE MY CAR ABOUT 1/2 MILE TO THE LOCAL CVS. WHEN I LEFT I STARTED THE CAR AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I HAD LOST PRESSURE AND DID NOT HAVE BRAKES. I HAVE A MANUAL TRANSMISSIONS. I PULLED OVER IN ANOTHER PARKING LOT AND PUMPED THE BRAKES TO GET PRESSURE BACK. CAR RAN FINE FOR A 15 MILES. THE SAME NIGHT …
Read full complaint
I DROVE MY CAR ABOUT 1/2 MILE TO THE LOCAL CVS. WHEN I LEFT I STARTED THE CAR AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I HAD LOST PRESSURE AND DID NOT HAVE BRAKES. I HAVE A MANUAL TRANSMISSIONS. I PULLED OVER IN ANOTHER PARKING LOT AND PUMPED THE BRAKES TO GET PRESSURE BACK. CAR RAN FINE FOR A 15 MILES. THE SAME NIGHT I DROVE TO ANOTHER LOCATION AND LOST PRESSURE OF THE BRAKE PEDAL WHILE SITTING AT A STOP LIGHT. I PULLED OVER AND PUMPED THE BRAKES AGAIN. I HAVE DRIVEN THE CAR SINCE TO THE DEALER AND THEY CANNOT REPLICATE THE PROBLEM, NOR DIAGNOSE IT. THEY SAID IT WAS INTERMITTENT AND MOST LIKELY THE BRAKE MASTER CYLINDER. THERE WAS NO EVIDENCE OF BRAKE FLUID LEAKING FROM ANY OF THE BRAKE LINES OR AROUND THE TIRES. THE PROBLEM IS THEY CANNOT SAY FOR SURE IF THE MASTER CYLINDER IS LEAKING INTERNALLY OR IF A GASKET OR SEAL IS FAILING. I AM GOING TO HAVE THE MASTER CYLINDER REPLACED AND HOPE THAT IS THE PROBLEM, BUT I AM AFRAID TO DRIVE ON THE FREEWAY OR AT FAST SPEEDS BECAUSE I HAVE NO CAUSE FOR THE BRAKE FAILURE. I AM THANKFUL I WAS NOT GOING FAST, OTHERWISE THE ONLY WAY TO SLOW THE CAR WOULD BE TO DOWN SHIFT AND USE THE EMERGENCY BRAKE. THIS PART IS ALSO NOT WARRANTIED, BUT I AM SURPRISED IT IS ALREADY FAILING BEFORE I HAVE CHANGED THE BRAKE PADS, ROTORS, OR DRUMS. IT IS WEIRD. NOW I HAVE TO WAIT FOR THE PART TO COME FROM THE PLANT? THEY DO NOT EVEN HAVE IT IN STOCK. IS THIS A COMMON PROBLEM? I WILL BE ASKING FOR THE OLD PART, BUT AM UNSURE IF I WILL BE ABLE TO SEE IF THE MASTER CYLINDER IS BAD. *TR
NHTSA ODI #10361251
32,000 miles · Aug 9, 2010
Service Brakes, Hydraulic
REAR BRAKES MAKE A LOUD EERIE SOUND WHEN IN REVERSE, NOT ALWAYS BUT USUALLY ON A COLD START, COLD MORNING, AFTER A CAR WASH, AFTER RAIN, OR PARKED FOR A COUPLE DAYS. *TR
NHTSA ODI #10348282
30,378 miles · Jul 13, 2010
Service Brakes, Hydraulic
THE CAR SHAKES AND MAKES A SCREECHING SOUND WHEN THE BRAKE IA APPLIED. I HAVE CHANGED THE ENTIRE BRAKE SYSTEM TO MY COBALT 2007 AND MY CAR STILL SEEMS TO SHAKE AND SHRIEK WHEN I APPLY THE BRAKE AT A FAST SPEED. *TR
NHTSA ODI #10342915
62,000 miles · Mar 1, 2010
Parking BrakeService Brakes, HydraulicSteeringCrashInjury
DRIVER WAS CHANGING LANES ON HIGHWAY IN A 2007 CHEVY COBALT WHEN HER STEERING WHEEL FROZE UP ON HER. SHE COULD NOT CORRECT STEERING AND HER BRAKES SEEMED TO LOSE POWER AS WELL. SHE HIT A CONCRETE BARRIER, HER CAR WENT AIRBORNE AND STARTED ROLLING. SHE WAS EJECTED ABOUT FIFTY FEET. VEHICLE WAS A COMPLETE LOSS. THE AUTO INSURANCE…
Read full complaint
DRIVER WAS CHANGING LANES ON HIGHWAY IN A 2007 CHEVY COBALT WHEN HER STEERING WHEEL FROZE UP ON HER. SHE COULD NOT CORRECT STEERING AND HER BRAKES SEEMED TO LOSE POWER AS WELL. SHE HIT A CONCRETE BARRIER, HER CAR WENT AIRBORNE AND STARTED ROLLING. SHE WAS EJECTED ABOUT FIFTY FEET. VEHICLE WAS A COMPLETE LOSS. THE AUTO INSURANCE COMPANY WON'T INVESTIGATE DUE TO HER CAR BEING JUST 12,000 MILES OVER WARRANTY. (ECONOMIC LOSS RULE) THE CAR IS STILL BEING HELD FOR FURTHER INVESTIGATION PER REQUEST OF THE DRIVER. VEHICLE NEVER HAD TROUBLE BEFORE THIS. DRIVER WAS SEVERELY INJURED SPENDING 10 DAYS IN HOSPITAL, 2 OF THOSE IN ICU. DRIVER HAD COMPLICATIONS DUE TO INJURIES, NOW ON ROUND THE CLOCK IV'S AT HOME. *TR
NHTSA ODI #10315214
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration