I wrecked my car and after having it fixed and reset the seat belts are still locked up. this is an extremely common problem in cobalts it seems. i went chevrolet dealership and they are telling me that it isnt fixable, that the seatbelts will just suck back down inside again. my car is fixed but is now rendered not safe to driv…
Read full complaint
I wrecked my car and after having it fixed and reset the seat belts are still locked up. this is an extremely common problem in cobalts it seems. i went chevrolet dealership and they are telling me that it isnt fixable, that the seatbelts will just suck back down inside again. my car is fixed but is now rendered not safe to drive because the seat belts dont work, and theres no way to have them fixed according to chevrolet.
NHTSA ODI #11469896
Mileage unknown · Jan 21, 2020
Air BagsSeat BeltsCrash
2007 CHEVROLET COBALT. CONSUMER WRITES IN REGARDS TO DEFECTIVE AIRBAG. CONSUMER STATED THAT AIRBAG DID NOT DEPLOY DURING AUTOMOBILE ACCIDENT. *LD *JS
NHTSA ODI #11299850
Mileage unknown · Jun 12, 2016
Electrical SystemSeat BeltsUnknown Or Other
THE DEFECT: NO AUDIBLE WARNING CHIME WHEN THE DRIVERS DOOR IS OPENED AFTER TURNING OFF THE IGNITION AND LEAVING THE KEY IN THE CYLINDER. THERE IS ALSO NO AUDIBLE CHIME WHEN THE SEATBELT IS NOT CONNECTED WHILE DRIVING AND THE TURN SIGNALS MAKE NO AUDIBLE SOUNDS WHEN ON. ALL AUDIBLE SOUNDS ARE PLAYED USING THE VEHICLES SOUND SYST…
Read full complaint
THE DEFECT: NO AUDIBLE WARNING CHIME WHEN THE DRIVERS DOOR IS OPENED AFTER TURNING OFF THE IGNITION AND LEAVING THE KEY IN THE CYLINDER. THERE IS ALSO NO AUDIBLE CHIME WHEN THE SEATBELT IS NOT CONNECTED WHILE DRIVING AND THE TURN SIGNALS MAKE NO AUDIBLE SOUNDS WHEN ON. ALL AUDIBLE SOUNDS ARE PLAYED USING THE VEHICLES SOUND SYSTEM. I SAW THERE HAS BEEN A RECALL ISSUED FOR OTHER GM MODELS WITH SIMILAR PROBLEMS. THIS PROBLEM IS COMMON WITH THIS MAKE AND MODEL AND OTHER SIMILAR GM VEHICLES. MY CHIMES HAVEN'T WORKED RIGHT FOR AWHILE NOW. A QUICK GOOGLE SEARCH SHOWS THIS IS A ON GOING PROBLEM WITH GM RADIOS FOR A LONG TIME. A RECALL HAS BEEN ISSUED FOR NEWER GM VEHICLES WITH SIMILAR PROBLEMS GENERAL MOTORS RECALLS CHEVROLET SONIC, TRAX AND SPARK OVER RADIO COMPLIANCE ISSUE READ MORE: HTTP://GMAUTHORITY.COM/BLOG/2016/05/CHEVROLET-SONIC-SPARK-TRAX-RADIO-COMPLIANCE-RECALL/#IXZZ4BOC2C3P3
NHTSA ODI #10873742
35,000 miles · Dec 24, 2015
Electrical SystemSeat Belts
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING THE VEHICLE, THE KEY WAS ACCIDENTALLY REMOVED FROM THE IGNITION SWITCH AND THE VEHICLE CONTINUED TO OPERATE. ON SEVERAL OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF AND THE FRONT DRIVER SEAT BELT WAS FAULTY. THE VEHICLE WAS TAKEN TO THE DEALER …
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING THE VEHICLE, THE KEY WAS ACCIDENTALLY REMOVED FROM THE IGNITION SWITCH AND THE VEHICLE CONTINUED TO OPERATE. ON SEVERAL OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF AND THE FRONT DRIVER SEAT BELT WAS FAULTY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LINKAGE WAS FAULTY. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 35,000. UPDATED 2/4/16 *CN *CN
NHTSA ODI #10812026
154,000 miles · Apr 2, 2015
Seat Belts
SEATBELT WILL NOT BUCKLE. HUSBAND HAD TO SLIDE OUT UNDER THE SEATBELT AND WE CANNOT GET IT UNSTUCK. *TR
NHTSA ODI #10703428
100,279 miles · Mar 31, 2015
Air BagsSeat Belts
THE AIRBAG MAINTENANCE LIGHT CAME ON IN THE CAR, TOOK CAR TO GM DEALER AND STATED THAT THERE WAS BROKEN WIRE IN THE PASSENGER SIDE SEATBELT RETRACTOR. DEALER HAD TO REPLACE RETRACTOR AND CLEAR CODE. HAVING HARD TIME UNDERSTANDING HOW THIS IS NOT SAFETY RELATED AND WHY I AM HAVING TO PAY OUT OF POCKET TO FIX THIS. THIS PART DO…
Read full complaint
THE AIRBAG MAINTENANCE LIGHT CAME ON IN THE CAR, TOOK CAR TO GM DEALER AND STATED THAT THERE WAS BROKEN WIRE IN THE PASSENGER SIDE SEATBELT RETRACTOR. DEALER HAD TO REPLACE RETRACTOR AND CLEAR CODE. HAVING HARD TIME UNDERSTANDING HOW THIS IS NOT SAFETY RELATED AND WHY I AM HAVING TO PAY OUT OF POCKET TO FIX THIS. THIS PART DOES NOT HARDLY MOVE AND SHOULD BE DESIGNED TO MOVE SO MANY REVOLUTIONS. MY OPINION THIS IS A FLAW IN THE DESIGN AND SHOULD BE COVERED BY GM. *TR
NHTSA ODI #10702773
75,550 miles · Dec 27, 2014
Electrical SystemSeat Belts
ON THE 2007 CHEVY COBALT, THE KEY GETS STUCK IN THE ACCESSORY POSITION AND CANNOT BE REMOVED. YOU MUST EITHER JUMP THE CAR OR PUSH THE SWITCH UNDER THE STEERING COLUMN TO REMOVE THE KEY. WITH THE KEY IN THE ACCESSORY POSITION, THE BATTERY DRAINS AND RENDERS THE RADIO INACTIVE. THIS ADDS TO AN ADDITIONAL SAFETY CONCERN BECAUSE …
Read full complaint
ON THE 2007 CHEVY COBALT, THE KEY GETS STUCK IN THE ACCESSORY POSITION AND CANNOT BE REMOVED. YOU MUST EITHER JUMP THE CAR OR PUSH THE SWITCH UNDER THE STEERING COLUMN TO REMOVE THE KEY. WITH THE KEY IN THE ACCESSORY POSITION, THE BATTERY DRAINS AND RENDERS THE RADIO INACTIVE. THIS ADDS TO AN ADDITIONAL SAFETY CONCERN BECAUSE THE SEATBELT CHIME AND BLINKER SOUND GO THROUGH THE RADIO AND CANNOT BE HEARD WHEN THE RADIO IS INACTIVE. CHEVY STATED THAT YOU MUST BRING IN THE CAR TO HAVE THE RADIO REPROGRAMMED FOR $130 EACH TIME THE BATTERY GOES DEAD. *TR
NHTSA ODI #10668486
110,000 miles · Sep 4, 2014
Seat Belts
PUT MY CAR IN PARK, TURNED THE IGNITION OFF, PRESSED THE RELEASE BUTTON ON THE SEAT BELT AND IT FAILED. I WAS STUCK IN MY CAR FOR OVER FIVE MINUTES BEFORE I DECIDED I HAD TO SLIDE UNDER THE WAIST/LAP RESTRAINT IN ORDER TO AVOID CUTTING THE SEAT BELT. *TR
NHTSA ODI #10630695
70,000 miles · Jul 15, 2014
Air BagsElectrical SystemSeat Belts
ELECTRICAL SHORT IN THE RIGHT FRONT SEAT BELT RETRACTOR IN WHICH DISABLES THE AIR BAG SYSTEM BECAUSE OF THE FAULT. THIS DIAGNOSIS WAS VERIFIED BY BERGSTROM CHEVROLET IN APPLETON, WISCONSIN. AFTER NUMEROUS CONTACTS WITH GM AND BERGSTROM CHEVROLET, THEY DECIDED NOT TO COVER THE COST BECAUSE OF EXPIRED WARRANTY. *TR
NHTSA ODI #10610751
45,000 miles · Jan 10, 2013
Air BagsElectrical SystemSeat Belts
DRIVING DOWN THE ROAD AND THE AIRBAG ON THE PASSENGERS SIDE SHUTS OFF WITH A PASSENGER IN THE SEAT. SERVICE AIRBAG LIGHT GOES ON. SHUT THE CAR OFF AND RESTART THEN IT WILL BE FINE FOR A WHILE. I THINK IT IS SENSOR ON THE SEATBELT RETRACTOR. *TR
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
2007 Chevrolet Cobalt Problems, Complaints & Recalls | Skip That Year
Illustration