NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
43 reportsClear category filter137,000 miles · Dec 19, 2012
Electrical SystemPower Train
FIRST OFF 10,000 MILES AFTER MY WARRANTY ENDED THE CLUTCH WENT ON THIS CAR. SINCE THEN I HAVE HAD TO REPLACE THE CLUTCH 3 MORE TIMES, REPLACE THE TRANSMISSION AND THEN REBUILD THE TRANSMISSION. WHOEVER AT CHEVY DECIDED TO USE ATF IN A MANUAL TRANSMISSION CARE DUE TO THEIR OWN DESIGN FLAW OF A SMALLER WHOLE THEREBY CREATING SYNCH…
Read full complaint
FIRST OFF 10,000 MILES AFTER MY WARRANTY ENDED THE CLUTCH WENT ON THIS CAR. SINCE THEN I HAVE HAD TO REPLACE THE CLUTCH 3 MORE TIMES, REPLACE THE TRANSMISSION AND THEN REBUILD THE TRANSMISSION. WHOEVER AT CHEVY DECIDED TO USE ATF IN A MANUAL TRANSMISSION CARE DUE TO THEIR OWN DESIGN FLAW OF A SMALLER WHOLE THEREBY CREATING SYNCHOS WHICH WERE NOT PROPERLY LUBRICATED SHOULD BE SHOT. SO HERE WE ARE AGAIN FOR ANNUAL TRANSMISSION MAINTENANCE..IE: THE CLUTCH WENT OUT AGAIN. THIS TIME WE CHANGED IT AND SINCE ALL THE FRAME BOLTS WERE STRIPPED OUT FROM THE "LICENSED MECHANIC" WHO DID IT THE LAST 3 TIMES, WE HAD TO TAKE IT OUT THE TOP. NEXT CAME THE NEW STARTER THAT HAD TO BE PUT IN AND NOW IT IS ALL BACK TOGETHER, ALL FUSES CHECKED OUT OK, THE BATTERY IS OK, THE STARTER CHECKS OUT OF, BUT....THE CAR WILL NOT START. DASH LIGHTS INDICATE THAT THERE IS A POWER STEERING ISSUE AND I AM OUT OF GAS, BOTH OF WHICH ARE INCORRECT SO SOMETHING IS WRONG AND I AM OUT OF IDEAS AS TO WHAT ON THIS STUPID CAR THAT I NEVER SHOULD HAVE PURCHASED AND WILL NEVER PURCHASE AGAIN BECAUSE IT IS JUNK!! *TR
NHTSA ODI #10489222
90,000 miles · Dec 7, 2012
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH AND SHE WAS UNABLE TO SHIFT GEARS SINCE THE SHIFTER FAILED TO MOVE. THE CONTACT MENTIONED THAT THE FAILURE PREVENTED HER FROM TURNING OFF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH AND SHE WAS UNABLE TO SHIFT GEARS SINCE THE SHIFTER FAILED TO MOVE. THE CONTACT MENTIONED THAT THE FAILURE PREVENTED HER FROM TURNING OFF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 90,000.
NHTSA ODI #10487711
Mileage unknown · Oct 17, 2012
Electrical SystemPower Train
CAR WILL NOT TURN OFF, KEY GOES TO ACC THEN WONT TURN ANY FARTHER. I HAVE TO PUSH THE SHIFTER BUTTON BEFORE IT WILL RELEASE THE KEY. *TR
NHTSA ODI #10480797
151,000 miles · Sep 30, 2012
Electrical SystemPower TrainSteering
BATTERY DIED IN CAR, HAD TO JUMP THE CAR. CAR STARTED FINE, STEERING SEEMED TO BE A LITTLE TIGHT. AFTER A FEW MINUTES OF DRIVING THE TIGHTNESS IN THE STEERING WENT AWAY. HOWEVER UPON ARRIVING AT HOME THE KEY WOULD NOT COME OUT OF THE IGNITION, AND THE SHIFTER WOULD SHIFT INTO ANY GEAR EASILY WITHOUT HAVING TO PRESS IN THE SHI…
Read full complaint
BATTERY DIED IN CAR, HAD TO JUMP THE CAR. CAR STARTED FINE, STEERING SEEMED TO BE A LITTLE TIGHT. AFTER A FEW MINUTES OF DRIVING THE TIGHTNESS IN THE STEERING WENT AWAY. HOWEVER UPON ARRIVING AT HOME THE KEY WOULD NOT COME OUT OF THE IGNITION, AND THE SHIFTER WOULD SHIFT INTO ANY GEAR EASILY WITHOUT HAVING TO PRESS IN THE SHIFTER BUTTON. ALSO IN ATTEMPTS TO REMOVE THE KEY THE STEERING WHEEL IS NOW LOCKED ALL THE WAY TO THE RIGHT WITH THE WHEELS LOCKED IN THE RIGHT POSITION. WAS ABLE TO REMOVE KEY FROM IGNITION BY LOCATING THE EMERGENCY KEY RELEASE SWITCH UNDER THE STEERING COLUMN BUT CAR WILL NOT START NOW AS KEY WONT TURN ALL THE WAY, AND SHIFTER STILL SHIFTS INTO ANY GEAR WITHOUT HAVING TO PRESS THE SHIFTER BUTTON. CAR WAS PARKED FRONT FIRST AGAINST BUILDING SO I HAVE NO IDEA HOW I WILL GET IT TOWED OUT OF THERE TO A SHOP TO FIX IT! I SUSPECT THE SHIFTER CABLE ASSEMBLY AT THE END OF THE SHIFTER WHICH IS MADE OUT OF PLASTIC IS BROKEN. WILL VERIFY WHEN ITS TAKEN APART. I HAVE SEEN AT LEAST 50 OTHER CASES ON THE INTERNET WHERE THIS PIECE BREAKS AND CAUSES THE CAR NOT TO REGISTER IT BEING IN PARK AND WILL NOT RELEASE KEY FROM IGNITION. GM RECALLED CERTAIN YEARS FOR SHIFTER PROBLEMS BUT NOT THE 2007 UNFORTUNATELY! *TR
NHTSA ODI #10478016
52,200 miles · Oct 13, 2011
Electrical SystemPower TrainSteering
PURCHASED VEHICLE BRAND NEW IN 2007 AND NO PROBLEMS TILL NOW. 22 YEAR OLD DAUGHTER DRIVING VEHICLE, SHE IS A COLLEGE STUDENT. SHE DRIVES IN MAJOR CITY DAILY AND DRIVING HOME FROM SCHOOL GAUGE CLUSTER WENT CRAZY AND POWER STEERING WENT OUT. SCARING HER, SHE PARKED THE CAR IN A CHURCH LOT AND I SENT THE CAR TO A DEALER THE NEXT…
Read full complaint
PURCHASED VEHICLE BRAND NEW IN 2007 AND NO PROBLEMS TILL NOW. 22 YEAR OLD DAUGHTER DRIVING VEHICLE, SHE IS A COLLEGE STUDENT. SHE DRIVES IN MAJOR CITY DAILY AND DRIVING HOME FROM SCHOOL GAUGE CLUSTER WENT CRAZY AND POWER STEERING WENT OUT. SCARING HER, SHE PARKED THE CAR IN A CHURCH LOT AND I SENT THE CAR TO A DEALER THE NEXT DAY. I HAD FOUND ON THE INTERNET THAT THERE WAS A RECALL ON THE POWER STEERING ASSIST MOTOR AND INFORMED THE DEALERSHIP OF SUCH WHEN THE WORK WAS TO BE DONE. THEY REPLACED THE MOTOR UNDER THE RECALL BUT ALSO CHARGED ME $780.00 TO REPLACE THE STEERING COLUMN WHICH THEY SAID WAS BAD. I HAVE FOUND 1000 + COMPLAINTS ON THE INTERNET OF PEOPLE SAYING THEIR STEERING COLUMNS WERE SUPPOSEDLY BAD AS WELL WITH 1 PERSON HAVING THEIRS REPLACED 3 TIMES NOW. SHE PICKED THE CAR UP AND 2 WEEKS LATER THE SAME THING OCCURS AGAIN. THE DEALERSHIP LOOKS AT IT FOR 4 DAYS AND CLAIM THEY CAN'T FIND ANYTHING WRONG SO DO NOTHING BUT INVESTIGATE. THEY CLAIM THE CODES WERE ERASED ON THE COMPUTER BECAUSE WE DROVE IT AFTER THE FAULT BUT THE CAR WAS PARKED AND IMMEDIATELY HAULED TO THE DEALER ON A FLATBED TRUCK. AS I SAID BEFORE THERE ARE WELL OVER 1,000 COMPLAINTS ON THE INTERNET THAT I HAVE FOUND MYSELF SO I AM SURE THERE ARE A LOT MORE. AS SOON AS I CAN AFFORD IT THIS CAR WILL BE PUT IN TOWN SQUARE WITH A BIG LEMON SIGN ON IT AND SHE WILL BE DRIVING SOMETHING OTHER THAN GM. *TR
NHTSA ODI #10430136
100,000 miles · Oct 12, 2011
Engine And Engine CoolingPower TrainVehicle Speed Control
WHEN COMING TO A STOP, THE CAR WILL ACCELERATE ON ITS OWN. IT DOES THIS AT RANDOM TIMES, TODAY AT STOP SIGN THE CAR SPEEDOMETER ACCELERATED TO 80 MPH AND CAR SHUT DOWN WHILE AT A COMPLETE STOP. NO CODES TO READ NOR DID CHECK ENGINE LIGHT COME ON. *KB
NHTSA ODI #10429929
42,000 miles · Jan 12, 2011
Electrical SystemPower Train
THE KEY CAN NOT BE REMOVED FROM THE IGNITION SWITCH. EVENTHOUGH THE SHIFTER IS IN THE PARK POSITION. THE KEY DOES NOT RETURN TO THE REMOVE POSITION. YOU CAN TURN THE ENGINE OFF, BUT THE KEY REMAINS IN THE ACCESSORY POSITION SO THE BATTERY RUNS DOWN. REPEATED EFFORTS OF CYCLING THE SHIFTER AND TURNING THE WHEEL DOES NOT RECTIFY …
Read full complaint
THE KEY CAN NOT BE REMOVED FROM THE IGNITION SWITCH. EVENTHOUGH THE SHIFTER IS IN THE PARK POSITION. THE KEY DOES NOT RETURN TO THE REMOVE POSITION. YOU CAN TURN THE ENGINE OFF, BUT THE KEY REMAINS IN THE ACCESSORY POSITION SO THE BATTERY RUNS DOWN. REPEATED EFFORTS OF CYCLING THE SHIFTER AND TURNING THE WHEEL DOES NOT RECTIFY THE PROBLEM. WHEN I TOOK IT TO THE DEALER THE SHIFTER WAS REPLACED AT A COST OF $287. FORTUNATELY, THIS HAPPENED WHEN I RETURNED HOME AND WAS ABLE TO PARK IN MY OWN GARAGE. IT WOULD HAVE BEEN UNFORTUNATE IF I HAD BEEN ON A TRIP OR AN IMPORTANT ERRAND AND WOULD HAVE TO LEFT THE KEY IN THE IGNITION IN A PUBLIC AREA. WHEN I "GOOGLED" THIS PROBLEM ON THE INTERNET IN AN EFFORT TO FIND A SIMPLE SOLUTION, I FOUND NUMEROUS SIMILAR COMPLAINTS IN REGARDS TO THE COBALT CAR. *TR
NHTSA ODI #10376354
89,000 miles · Nov 22, 2010
Electrical SystemPower Train
DRIVING DOWN THE ROAD THE POWER STEERING LIGHT COMES ON, POWER STEERING GOES OUT, RPM, SPEEDOMETER AND FUEL GAUGES GO TO ZERO THEN RAPIDLY MOVE BACK AND FORTH, TRANSMISSION SLIPS, CHECK ENGINE LIGHT AND AUTO THEFT LIGHTS COME ON. I HAVE HAD THE POWER STEERING RECALL FIXED. THIS HAS HAPPENED MULTIPLE TIMES NOW. AT FIRST IT WOUL…
Read full complaint
DRIVING DOWN THE ROAD THE POWER STEERING LIGHT COMES ON, POWER STEERING GOES OUT, RPM, SPEEDOMETER AND FUEL GAUGES GO TO ZERO THEN RAPIDLY MOVE BACK AND FORTH, TRANSMISSION SLIPS, CHECK ENGINE LIGHT AND AUTO THEFT LIGHTS COME ON. I HAVE HAD THE POWER STEERING RECALL FIXED. THIS HAS HAPPENED MULTIPLE TIMES NOW. AT FIRST IT WOULD GO AWAY IF THE VEHICLE WAS RESTARTED, HOWEVER, NOW I HAVE TO HAVE IT TOWED TO THE DEALERSHIP TO HAVE IT FIXED. THIS WILL BE THE SECOND TRIP TO THE DEALERSHIP IN 1.5 WEEKS. *TR
NHTSA ODI #10367044
47,000 miles · Oct 21, 2010
Power TrainCrash
AUTOMATIC 2007 CHEVROLET COBALT. GM SENT ME A LETTER ABOUT THE POWER STEERING RECALL. WENT TO DEALERSHIP TO GET THE PROBLEM FIXED SEPTEMBER 1, 2010. SEPTEMBER 24, 2010 I WAS INVOLVED IN A CAR ACCIDENT WHERE MY COBALT HYDROPLANED AND COMPLETELY LOST CONTROL AS DESCRIBED IN THE INVESTIGATIONS DONE BY GM, ON THIS ISSUE. *TR
NHTSA ODI #10361660
50,000 miles · Feb 25, 2010
Electrical SystemPower TrainStructure
2007 CHEVY COBALT- MANY PROBLEMS, ELECTRICAL COMES OFF AND ON, CAR RIDES LIKE A BUCKET OF BOLTS, AT 50,000 KMS FRONT PASSENGER WHEEL HAD 1 1/2 INCH MOVEMENT WHILE PARKED. VERY DANGEROUS. WHY NO RECALLS FOR THESE ISSUES? THE FIXER OF THE CAR REPLACED A SUSPENSION CONTROL ARM BUSHING. ALL KINDS OF NOISE, ALL POT HOLES I THOUGH…
Read full complaint
2007 CHEVY COBALT- MANY PROBLEMS, ELECTRICAL COMES OFF AND ON, CAR RIDES LIKE A BUCKET OF BOLTS, AT 50,000 KMS FRONT PASSENGER WHEEL HAD 1 1/2 INCH MOVEMENT WHILE PARKED. VERY DANGEROUS. WHY NO RECALLS FOR THESE ISSUES? THE FIXER OF THE CAR REPLACED A SUSPENSION CONTROL ARM BUSHING. ALL KINDS OF NOISE, ALL POT HOLES I THOUGHT THE CAR WAS GOING TO FALL APART. HUNK OF JUNK CAR. MANY SAFETY ISSUES SHOULD BE INVESTIGATED. BROUGHT BACK TO THE DEALER SEVERAL TIMES FOR SAGGING DOORS ON TWO DOOR MODEL, IRREGULAR IDOL, RATTLING SOUNDS IN THE FRONT END TO NO AVAIL. THANK GOD I ONLY LEASED IT, THEY CAN KEEP IT, IT IS A HUNK OF JUNK. I WOULD NEVER RECOMMEND THIS CAR TO ANYONE. *TR
NHTSA ODI #10314431
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration