MY WIFE'S 2007 CHEVROLET COBALT LS POWER STEERING WENT OUT AFTER RESTARTING THE CAR EVERYTHING IS FINE FOR NOW. AFTER SEARCHING ONLINE I SEE THAT MANY OTHERS ARE HAVING THE SAME PROBLEM. AND IN ALL CASES THEY ARE BEING CHARGED JUST FOR DIAGNOSTICS AND NOTHING IS BEING DONE TO FIX IT. THIS IS A PROBLEM THAT COULD GET MY WIFE HURT…
Read full complaint
MY WIFE'S 2007 CHEVROLET COBALT LS POWER STEERING WENT OUT AFTER RESTARTING THE CAR EVERYTHING IS FINE FOR NOW. AFTER SEARCHING ONLINE I SEE THAT MANY OTHERS ARE HAVING THE SAME PROBLEM. AND IN ALL CASES THEY ARE BEING CHARGED JUST FOR DIAGNOSTICS AND NOTHING IS BEING DONE TO FIX IT. THIS IS A PROBLEM THAT COULD GET MY WIFE HURT BEING AS SHE WOULD HAVE TROUBLE STEERING IT LUCKILY I WAS DRIVING IT AT THE TIME. IT IS THE CHEVY DEALER NOW HAVING THE FUEL PUMP REPLACED WHICH WAS RECALLED AND WE WILL SEE WHAT THEY TELL ME ABOUT IT. *TR
NHTSA ODI #10312630
50,000 miles · Feb 19, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHENEVER THE CONTACT WOULD DRIVE THE VEHICLE AT ANY SPEED HE COULD SMELLED GAS FUMES INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT HAD A LOCAL MECHANIC DIAGNOSE HIS VEHICLE AND HE WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAI…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHENEVER THE CONTACT WOULD DRIVE THE VEHICLE AT ANY SPEED HE COULD SMELLED GAS FUMES INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT HAD A LOCAL MECHANIC DIAGNOSE HIS VEHICLE AND HE WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 50,000.
NHTSA ODI #10312008
Mileage unknown · Feb 12, 2010
Fuel System, Gasoline
I RECEIVED A SAFETY RECALL NOTICE AND I CALLED MISSION CHEVROLET IN EL PASO TX TO SCHEDULE AND APPOINTMENT AS PER THE RECALL NOTICE, I SPOKE TO A REPRESENTATIVE IN THE SERVICE DEPARTMENT AND HE TOLD ME THAT I COULD NOT SCHEDULE AN APPOINTMENT SINCE HE DID NOT ANTICIPATE HAVING PARTS AVAILABLE BECAUSE HE WAS ONLY RECEIVING 15 PAR…
Read full complaint
I RECEIVED A SAFETY RECALL NOTICE AND I CALLED MISSION CHEVROLET IN EL PASO TX TO SCHEDULE AND APPOINTMENT AS PER THE RECALL NOTICE, I SPOKE TO A REPRESENTATIVE IN THE SERVICE DEPARTMENT AND HE TOLD ME THAT I COULD NOT SCHEDULE AN APPOINTMENT SINCE HE DID NOT ANTICIPATE HAVING PARTS AVAILABLE BECAUSE HE WAS ONLY RECEIVING 15 PARTS AND THEY WOULD BE USED FOR FIRST COME FIRST SERVE CUSTOMERS. I WORK FULL TIME AND AM A DISTANCE AWAY FROM THE DEALERSHIP SO I HAVE TO HAVE AN APPOINTMENT AND ACCORDING TO HIM THE RECALL CHECK WOULD REQUIRE MY LEAVING CAR FOR THE DAY. ALL OF WHICH IS QUITE DIFFERENT TO WHAT WAS DESCRIBED ON THE RECALL NOTICE OF A 15 MINUTE CHECK AND AN HOUR AND A HALF REPLACEMENT TIME IF NECESSARY. SO NOW I AM AT A DISADVANTAGE IF I CAN NOT TAKE CARE OF THIS ISSUE AND COULD BE JEOPARDIZING MY SAFETY. *TR
NHTSA ODI #10308855
45,000 miles · Dec 3, 2009
Electronic Stability Control (esc)Fuel System, Gasoline
POWER STEERING FAILURE, POWER STEERING LOCKS UP AND POWER STEERING FLASHES ON COMMUNICATION SYSTEM AFTER HEARING 3 DINGS. ALSO SMELL GAS IN CAR SMELL IS VERY HEAVY AT TIMES, THIS IS A 2007 CHEVY COBALT AND CAR IS NOT UNDER WARRANTY. *TR
NHTSA ODI #10294448
70,000 miles · Oct 5, 2009
Fuel System, Gasoline
2007 CHEVROLET COBALT WITH 68000 MILES ON IT HAS FUEL LEAKING FROM TOP OF TANK. MECHANIC AND PARTS HOUSE SAY THIS IS VERY COMMON FOR THIS VEHICLE. THIS SEEMS TO BE A REAL SAFETY ISSUE THAT I AND OTHERS BELIEVE SHOULD WARRANT A RECALL. *TR
NHTSA ODI #10286346
57,000 miles · Jun 29, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED GASOLINE LEAKING FROM THE VEHICLE. HE PULLED OVER AND NOTICED A LIGHT ILLUMINATING. A MECHANIC STATED THAT THE LIGHT WAS DUE TO THE LINES THAT FAILED, WHICH WERE CONNECTED TO THE FUEL PUMP. THE DEALER STATED THAT NOTHING COULD…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED GASOLINE LEAKING FROM THE VEHICLE. HE PULLED OVER AND NOTICED A LIGHT ILLUMINATING. A MECHANIC STATED THAT THE LIGHT WAS DUE TO THE LINES THAT FAILED, WHICH WERE CONNECTED TO THE FUEL PUMP. THE DEALER STATED THAT NOTHING COULD BE DONE TO REPAIR THE FAILURE. THE MECHANIC STATED THAT THIS SHOULD NOT HAVE HAPPENED TO A NEWER VEHICLE. THE VEHICLE HAS BEEN REPAIRED. THE FAILURE MILEAGE WAS 57,000 AND CURRENT MILEAGE WAS 59,800. UPDATED 08/21/09. *LJ UPDATED 08/26/09.*JB
NHTSA ODI #10275263
21,900 miles · Jun 1, 2009
Fuel System, Gasoline
PROBLEM: I HAVE A 2007 CHEVY COBALT THAT IS LEAKING FUEL FROM UNDER THE CAR AT THE GAS TANK. I CALLED THE PARTS DEPARTMENT WERE WE PURCHASED THE CAR TO SEE WERE THE FUEL FILTER IS LOCATED. HE TOLD ME THAT JUST YESTERDAY A CUSTOMER CAME IN WHO OWNED THE SAME YEAR AND MODEL WHO ALSO HAD A LEAK AT THE SAME LOCATION AT THE FUEL T…
Read full complaint
PROBLEM: I HAVE A 2007 CHEVY COBALT THAT IS LEAKING FUEL FROM UNDER THE CAR AT THE GAS TANK. I CALLED THE PARTS DEPARTMENT WERE WE PURCHASED THE CAR TO SEE WERE THE FUEL FILTER IS LOCATED. HE TOLD ME THAT JUST YESTERDAY A CUSTOMER CAME IN WHO OWNED THE SAME YEAR AND MODEL WHO ALSO HAD A LEAK AT THE SAME LOCATION AT THE FUEL TANK. THE PARTS PERSON TOLD ME THAT THE FUEL PUMP IS IN THE TANK. THE SMELL OF GASOLINE IN THE CAR IS EXTREMELY BAD. IT ALMOST SMELLS LIKE IT IS LEAKING INTO THE CAR. QUESTION: IS THIS A PROBLEM THAT OTHER 2007 CHEVY CUSTOMERS ARE HAVING? WHAT CAN I DO ABOUT THIS DANGEROUS SITUATION? *TR
NHTSA ODI #10272589
10,641 miles · Mar 4, 2009
Fuel System, Gasoline
PURCHASED A 2007 COBALT AUG 13, 2007; 1 YEAR LATER AND TILL DATE HAD TO BRING CAR IN FOR ALL ISSUES PERTAINING TO THE FUEL SYSTEM OF THE CAR. I HAVE BROKEN DOWN AS A RESULT OF THE FUEL SYSTEM IN MY CAR, HAVE HAD TO PAY FOR RENTAL CAR'S AND MISS TIME FROM WORK. DEALERSHIP AND GM DOES NOT FEEL MY CAR SHOULD BE REPLACED. *TR
NHTSA ODI #10260714
64,784 miles · Feb 5, 2009
Fuel System, Gasoline
YESTERDAY I FILLED UP THE CAR WITH GAS AND I SMELLED THE GASOLINE. I CHECKED OUT MY CAR AND I FOUND OUT THAT MY GAS TANK WAS LEAKING FROM THE CONNECTOR THAT CONNECTS THE GAS TANK TO THE RUBBER HOSE THAT LEADS TO THE METAL PIPE THAT YOU INSERT GAS FROM. THIS HAPPENED TWO TIMES AFTER FILLING UP COMPLETELY. IT APPEARS THAT THE WELD…
Read full complaint
YESTERDAY I FILLED UP THE CAR WITH GAS AND I SMELLED THE GASOLINE. I CHECKED OUT MY CAR AND I FOUND OUT THAT MY GAS TANK WAS LEAKING FROM THE CONNECTOR THAT CONNECTS THE GAS TANK TO THE RUBBER HOSE THAT LEADS TO THE METAL PIPE THAT YOU INSERT GAS FROM. THIS HAPPENED TWO TIMES AFTER FILLING UP COMPLETELY. IT APPEARS THAT THE WELD PROCESS THAT SEALS THE CONNECTOR TO THE GAS TANK WAS NOT SEALED PROPERLY AND STARTED TO CRACK. TODAY I HAD TO REPLACE MY GAS TANK FOR THE FIRST TIME AND I DON'T BELIEVE I AM GOING TO BE THE ONLY ONE WITH THIS PROBLEM. PERSONALLY I THINK ITS A PROBLEM CHEVROLET HAS HAD FOR AWHILE. I ALSO HEARD ON THE RADIO THAT THE NEW VERSION OF THE TRIAL BLAZERS HAD A RECALL ON THEIR GASOLINE TANKS FOR LEAKING PROBLEMS TOO. MY PURPOSE FOR MY COMPLAINT IS TO PREVENT THIS FROM HAPPENING TO ANYONE ELSE AND NOTIFY CHEVROLET OF THE PROBLEM SO THEY CAN FIX IT. YES I DO STILL HAVE THE OLD PART. *TR
NHTSA ODI #10257651
3,500 miles · Apr 27, 2007
Fuel System, Gasoline
CAR MAKES A SERIES OF KNOCKS ON A COLD START---SOUNDS AS IF SOMEONE IS LOCKED INSIDE THE TRUNK OF THE VEHICLE. CHEVY HAS LOOKED AT MY VEHICLE AND SAID IT WAS DUE TO A BULLETIN STATING A NOISY EVAP SYSTEM, WHICH IT IS NOT FIXABLE. I AM STILL WAITING TO SEE WHAT ACTION WILL BE TAKEN. *JB
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
2007 Chevrolet Cobalt Problems, Complaints & Recalls | Skip That Year
Illustration