Illustration2007 CHEVROLET COBALT. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE PROBLEMS. *SMD THE CONSUMER STATED THE VEHICLE WAS RECALLED FOR THE EXACT PROBLEM SHE EXPERIENCED. *JB
2007 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
Engine And Engine Cooling complaints
24 reportsI WAS DRIVING SOUTHBOUND ON THE LODGE FREEWAY IN DETROIT, MICHIGAN IN SNOWY CONDITIONS. MY CAR STALLED AND I SPENT OUT WITH NO CONTROL. I HAVE BEEN DRIVING FOR MANY YEARS AND I HAVE NEVER HAD A CAR STALL OUT ON ME AND SPEND OUT OF CONTROL SUCH AS THIS ONE. MY REAR DRIVER'S SIDE BUMPER AND FENDER WAS CRUSHED. I WAS UNAWARE OF…
Read full complaint
I WAS DRIVING SOUTHBOUND ON THE LODGE FREEWAY IN DETROIT, MICHIGAN IN SNOWY CONDITIONS. MY CAR STALLED AND I SPENT OUT WITH NO CONTROL. I HAVE BEEN DRIVING FOR MANY YEARS AND I HAVE NEVER HAD A CAR STALL OUT ON ME AND SPEND OUT OF CONTROL SUCH AS THIS ONE. MY REAR DRIVER'S SIDE BUMPER AND FENDER WAS CRUSHED. I WAS UNAWARE OF THE GM RECALL UNTIL PRESENT AND HAD GM DISCLOSED THE RECALL INFORMATION BEFORE I PURCHASED THE VEHICLE (PAID IN FULL) WITH MY CASH, HARD EARNED MONEY I WOULD HAVE NEVER DRIVEN TO MONROE MICHIGAN TO GET SUCH A VEHICLE AS THIS COULD HAVE HAPPENED TO MY WIFE OR DAUGHTER. GENERAL MOTORS HAD NO RIGHT TO WITHHOLD THIS INFORMATION AS THIS COULD HAVE BEEN FATAL. IN CONCLUSION, I THINK GM OWES ME A REFUND. *TR
WAS DRIVING CAR, HEARD A CLICKING NOISE, SMELLED SMOKE AND CAR BUSTED INTO FLAMES. STILL WAITING FOR INSURANCE COMPANY TO LOOK AT CAR. WAS A TOTAL LOSS, *TR
WAS DRIVING ON FREEWAY GOING 55 MPG, WEATHER CLEAR, ROAD CLEAR, WENT TO APPLY BRAKES AND NO POWER TO CAR WHAT SO EVER, CAR DID COMPLETE U-TURN ON FREEWAY AND HIT SIDE CURBING ON FREEWAY WHICH CAUSED TIRE AND RIM DAMAGE. LIGHTS CAME ON DASH AND CAR WAS NOT ON WHEN IT CRASHED. CAR WAS TAKEN TO RALLY CHEVROLET FOR REPAIRS AND I T…
Read full complaint
WAS DRIVING ON FREEWAY GOING 55 MPG, WEATHER CLEAR, ROAD CLEAR, WENT TO APPLY BRAKES AND NO POWER TO CAR WHAT SO EVER, CAR DID COMPLETE U-TURN ON FREEWAY AND HIT SIDE CURBING ON FREEWAY WHICH CAUSED TIRE AND RIM DAMAGE. LIGHTS CAME ON DASH AND CAR WAS NOT ON WHEN IT CRASHED. CAR WAS TAKEN TO RALLY CHEVROLET FOR REPAIRS AND I TOLD THEM THAT CAR JUST QUIT RESPONDING AND I HAD NO CONTROL OF CAR. THEY SAID THEY FOUND NOTHING MECHANICALLY WRONG, MY INSURANCE HAD TO PAY FOR REPAIRS AND I HAD TO PAY DEDUCTIBLE FOR REPAIRS, AN INVESTIGATOR CAME OUT TO CHECK MECHANICAL ISSUES WITH CAR, BUT CODES HAD BEEN ERASED FROM RALLY CHEVROLET. *TR
CHECK ENGINE LIGHT WITH THE CODE 0410. ON FRIDAY I TOOK MY CAR TO A SHOP BECAUSE MY CAR STARTED TO SMELL LIKE ELECTRICAL WIRES WERE BURNING AND THAT IS WHEN I NOTICED THE MY ENGINE LIGHT WAS ON. WHEN THE SHOP CHECKED IT HAD A CODE FOR 0410. I LOOKED THIS CODE UP AND I HAD SAID THERE WAS A RECALL ON THIS CODE BUT I NOTICED THAT M…
Read full complaint
CHECK ENGINE LIGHT WITH THE CODE 0410. ON FRIDAY I TOOK MY CAR TO A SHOP BECAUSE MY CAR STARTED TO SMELL LIKE ELECTRICAL WIRES WERE BURNING AND THAT IS WHEN I NOTICED THE MY ENGINE LIGHT WAS ON. WHEN THE SHOP CHECKED IT HAD A CODE FOR 0410. I LOOKED THIS CODE UP AND I HAD SAID THERE WAS A RECALL ON THIS CODE BUT I NOTICED THAT MY CAR WAS NOT ON THIS LIST.
MY EXHAUST PIPE BROKE RIGHT BEFORE IT CONNECTS TO THE HEADERS. ON THE 4 1/2" RIPPLED STEEL THAT LOOKS LIKE IT IS SUPPOSED TO ABSORB VIBRATIONS. FROM THE LOOK OF THE STEAL IT IS TOO THIN TO WITHSTAND VIBRATIONS. THERE IS NO EVIDENCE OF ANY PRESSURE OR FORCED PULLING AGAINST THE AREA OF PROBLEM."LIKE BOTTOMING OUT THE CAR". TH…
Read full complaint
MY EXHAUST PIPE BROKE RIGHT BEFORE IT CONNECTS TO THE HEADERS. ON THE 4 1/2" RIPPLED STEEL THAT LOOKS LIKE IT IS SUPPOSED TO ABSORB VIBRATIONS. FROM THE LOOK OF THE STEAL IT IS TOO THIN TO WITHSTAND VIBRATIONS. THERE IS NO EVIDENCE OF ANY PRESSURE OR FORCED PULLING AGAINST THE AREA OF PROBLEM."LIKE BOTTOMING OUT THE CAR". THERE ARE NO SCRAPES, DENTS, OR SCRATCHES ON ANY PART OF MY EXHAUST PIPE THEREFORE I SUGGEST YOU LOOK INTO THIS IMMEDIATELY. FOR THIS HAPPENED TO MY VEHICLE SO EASILY. THERE WILL BE MORE OF YOUR VEHICLES HAVING THE SAME PROBLEM. *TR
I WAS DRIVING MY 2007 COBALT AND STOPPED AT A STOP SIGN, WHEN I SAW SMOKE ROLLING OUT FROM THE CAR. LUCKILY MY CHILDREN WERE NOT IN THE CAR. WITHIN MINUTES MY CAR WAS UP IN FLAMES. THE ENTIRE CAR, EXCEPT THE TRUNK WAS GONE. THERE WAS NO SAVING THE CAR. EVERYTHING WAS BURNED TO A CRISP. TODAY I HEARD ABOUT THE RECALL, I W…
Read full complaint
I WAS DRIVING MY 2007 COBALT AND STOPPED AT A STOP SIGN, WHEN I SAW SMOKE ROLLING OUT FROM THE CAR. LUCKILY MY CHILDREN WERE NOT IN THE CAR. WITHIN MINUTES MY CAR WAS UP IN FLAMES. THE ENTIRE CAR, EXCEPT THE TRUNK WAS GONE. THERE WAS NO SAVING THE CAR. EVERYTHING WAS BURNED TO A CRISP. TODAY I HEARD ABOUT THE RECALL, I WAS WONDERING IF THAT HAD SOMETHING TO DO WITH MY FIRE. I DO KNOW IM NOT SATISFIED. *TR
I HAVE A 2007 CHEVROLET COBALT. MY POWER STEERING LIGHT STARTED TO FLASH WHEN I WAS HEADED TO WORK THEN MY GAS GAGE WENT FROM 1/2 A TANK TO EMPTY, IT THEN STARTED TO FEEL WEIRD LIKE IT WAS GETTING HARDER TO TURN SO I PARKED IT AND SHUT THE CAR. WHEN I COME BACK AFTER WORK AND STARTED IT AND WAS ABLE TO MAKE IT HOME AND PARKED IT…
Read full complaint
I HAVE A 2007 CHEVROLET COBALT. MY POWER STEERING LIGHT STARTED TO FLASH WHEN I WAS HEADED TO WORK THEN MY GAS GAGE WENT FROM 1/2 A TANK TO EMPTY, IT THEN STARTED TO FEEL WEIRD LIKE IT WAS GETTING HARDER TO TURN SO I PARKED IT AND SHUT THE CAR. WHEN I COME BACK AFTER WORK AND STARTED IT AND WAS ABLE TO MAKE IT HOME AND PARKED IT CAUSE IM TO SCARED TO DRIVE IT WITH MY TWO KIDS. WHAT SHOULD I DO I BEEN READING UP ON THESE KIND OF CARS AND IT SEEMS THERE ARE ALOT OF PROBLEMS JUST LIKE MINE. *TR
MY HUSBAND AND I PURCHASED THE VEHICLE IN QUESTION IN APRIL 2007, AT APPROX. 50,000 MILES MY CAR STARTED TO MISS, THEN BEGAN TO ACCELERATE ON ITS OWN AND LUNGE AS I WAS COMING TO A STOP. WE BROUGHT THE CAR BACK TO DEALER WHERE PURCHASED, WE WERE THEN SENT ON "WILD GOOSE CHASE," FIRST WE WERE TOLD IT WAS A FUEL PEDAL SENSOR, NXT …
Read full complaint
MY HUSBAND AND I PURCHASED THE VEHICLE IN QUESTION IN APRIL 2007, AT APPROX. 50,000 MILES MY CAR STARTED TO MISS, THEN BEGAN TO ACCELERATE ON ITS OWN AND LUNGE AS I WAS COMING TO A STOP. WE BROUGHT THE CAR BACK TO DEALER WHERE PURCHASED, WE WERE THEN SENT ON "WILD GOOSE CHASE," FIRST WE WERE TOLD IT WAS A FUEL PEDAL SENSOR, NXT THEY REPLACED THE COMPUTER, FOLLOWED BY THE WIRING HARNESS, THIS HOWEVER, DID NOT FIX THE PROBLEM, WE TOOK IT BACK FOR A FOURTH TIME AND THE ENDED UP REBUILDING THE HEAD ON THE MOTOR, CAR HAS NOT RAN CORRECTLY EVER SINCE. WE TRIED TO FILE A LEMON LAW CLAIM BUT NEEDED FOUR RECEIPTS TO PROVE WARRANTY WORK, WE HAD THREE AND AFTER THE FOURTH WHEN PICKED UP CAR THE DEALER WOULD NOT RELEASE FOURTH, THAT WAS A YEAR AGO. MY CAR NOW HAS 88,000 MILES ON IT, IT IS BEGINNING TO IDLE ROUGH AGAIN AND WHEN I PUT FUEL IN IT, THE CAR DOES NOT WANT TO START, AT FIRST IT WILL NOT DO ANYTHING, AND THEN IT WILL TRY TO TURN OVER BUT WILL NOT START I THEN HAVE TO SLAM THE FUEL TO IT IN ORDER TO GET IT STARTED, ONCE IT STARTS IT WILL IDLE ROUGH AND I HAVE TO KEEP GIVING IT FUEL IN ORDER FOR THE IDLE TO SMOOTH. THIS IS THE WORST VEHICLE I HAVE EVER OWNED, I WILL BE HARD PRESSED TO EVER BUY ANOTHER CHEVY!!!!!!! *TR
MY HUSBAND BOUGHT HIS CAR NOV.6, 2008 AND SINCE THAT WE DIDN'T HAVE A PROBLEM ANYTHING BUT THAT ONE WINDOW ON THE RIGHT OF THE BACK SEAT WON'T MOVE. ANYWAY, ON OCT.22, 2011, MY HUSBAND WAS COMING HOME FROM WORK WHEN THE POWER STEERING WENT OFF, THANK GOD HE MADE IT SAFE TO OUR HOME. ON MONDAY, HE MADE THE APPOINTMENT TO THE DEAL…
Read full complaint
MY HUSBAND BOUGHT HIS CAR NOV.6, 2008 AND SINCE THAT WE DIDN'T HAVE A PROBLEM ANYTHING BUT THAT ONE WINDOW ON THE RIGHT OF THE BACK SEAT WON'T MOVE. ANYWAY, ON OCT.22, 2011, MY HUSBAND WAS COMING HOME FROM WORK WHEN THE POWER STEERING WENT OFF, THANK GOD HE MADE IT SAFE TO OUR HOME. ON MONDAY, HE MADE THE APPOINTMENT TO THE DEALER PLACE FOR THE RECALL WE KEPT ON PUTTING OFF. SO THE FOLLOWING MORNING, TUESDAY, THE DEALER REPLACED THE ELECTRIC POWER STEERING. THE CAR WAS WORKING FINE THAT WHOLE DAY. THE NEXT MORNING, THE CAR WON'T DO ANYTHING AT ALL. THE UN/LOCK BUTTON WON'T WORK AS IF THERE'S NO POWER AND THE CAR WON'T START. *TT
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.