NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
56 reportsClear category filter118,000 miles · Jun 23, 2016
Engine
THE VEHICLE STALLED AFTER I STOPPED THE CAR AT A STOPLIGHT (CITY STREET). BEFORE THAT (10 MINS OR SO) IT WAS LOOSING ITS ACCELERATION POWER AND THE ENGINE LIGHT CAME ON. I HAD IT TOWED AND THE REPAIR PLACE SAID IT WAS A MANUFACTURING DEFECT AND THAT I WOULD HAVE TO HAVE THE WHOLE ENGINE REPLACED. THERE WAS A FAULTY TIMING CHAIN …
Read full complaint
THE VEHICLE STALLED AFTER I STOPPED THE CAR AT A STOPLIGHT (CITY STREET). BEFORE THAT (10 MINS OR SO) IT WAS LOOSING ITS ACCELERATION POWER AND THE ENGINE LIGHT CAME ON. I HAD IT TOWED AND THE REPAIR PLACE SAID IT WAS A MANUFACTURING DEFECT AND THAT I WOULD HAVE TO HAVE THE WHOLE ENGINE REPLACED. THERE WAS A FAULTY TIMING CHAIN COMPONENT.
NHTSA ODI #10876276
100,100 miles · Feb 24, 2016
Engine
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,100.
NHTSA ODI #10838042
108,000 miles · Jan 17, 2016
Electrical SystemEngine
THE CAR SHUTS COMPLETELY OFF WHILE DRIVING, IT HAS ONLY HAPPENED AT LOW SPEEDS AND ACTS LIKE IT JUST STALLED. ONCE RESTARTED, THE CAR RUNS FINE. THIS HAPPENS AT RANDOM TIMES BOTH WHEN FIRST STARTING THE CAR AND ALSO AFTER DRIVING LONG PERIODS.
NHTSA ODI #10820712
110,000 miles · Nov 17, 2015
Engine
AT ROUGHLY 110,000 ON A GENTLY USED 07 COBALT THE INTERNAL TIMING CHAIN BROKE AND RENDERED THE ENGINE USELESS. THE REPAIR - A TOTAL MOTOR SWAP FOR $5K! AFTER I RAN INTO THIS PROBLEM MY WIFE LOOKED UP OTHER REVIEWS ON THE COBALT AND FOUND OUT NUMEROUS PEOPLE HAVE HAD THIS PROBLEM. THIS IS A SUPPER EXPENSIVE ERROR THAT CHEVY HAS O…
Read full complaint
AT ROUGHLY 110,000 ON A GENTLY USED 07 COBALT THE INTERNAL TIMING CHAIN BROKE AND RENDERED THE ENGINE USELESS. THE REPAIR - A TOTAL MOTOR SWAP FOR $5K! AFTER I RAN INTO THIS PROBLEM MY WIFE LOOKED UP OTHER REVIEWS ON THE COBALT AND FOUND OUT NUMEROUS PEOPLE HAVE HAD THIS PROBLEM. THIS IS A SUPPER EXPENSIVE ERROR THAT CHEVY HAS OVERLOOKED AND COSTLY FOR THE CONSUMER - US! AS WITH OTHERS, I WENT THROUGH ALL THE OFFICIAL RECALLS SUCH AS THE IGNITION AND POWER STEERING, AND THEN I PAID AN ADDITIONAL $600 FOR THE FUEL SYSTEM TO REPLACE - ANOTHER NOTORIOUS PROBLEM OF THE COBALT, AND NOW THIS!? COMPLETELY UNACCEPTABLE. IF YOU CANT MAKE A CAR OUT OF QUALITY PARTS, DON'T MAKE ONE AT ALL! ANYWAYS, LUCKILY THIS HAPPENED WHILE WE WERE PARKED BUT OF COURSE IT WAS VERY INCONVENIENT PLUS WE HAD TO PAY FOR THE TOW. IT MIGHT HAVE SHOWED SYMPTOMS OF A PROBLEM TWO WEEKS PRIOR WITH OCCASIONAL DIFFICULTY STARTING THE CAR WITH EITHER PROLONGED CRANKING, OR EVEN A SECOND TRY WAS NEEDED. I DON'T KNOW WHAT EXACTLY IS FAILING WHETHER IT'S THE PLASTIC PARTS OR THE TIMING CHAIN ITSELF, BUT THERE IS SOMETHING HERE THAT SHOULD BE INVESTIGATED AND ULTIMATELY LIFTED TO A RECALL CAUSE THERE ARE A LOT OF PEOPLE OUT THERE AFFECTED BY THIS, AND $5K ISN'T SOMETHING THAT ANYBODY SHOULD HAVE TO PAY FOR A CORPORATION'S INCOMPETENCE.
NHTSA ODI #10794508
118,000 miles · Sep 15, 2015
Engine
I WAS DRIVING DOWN THE ROAD, WHEN A WARNING SIGNAL WENT OFF ON MY CAR, A MESSAGE CAME UP THAT SAID "ENGINE POWER REDUCED" AND MY CARS ACCELERATION WAS SIGNIFICANTLY REDUCED. I COULD NOT GO OVER 10 MILES AN HOUR AND THE CAR WAS SHAKING VIOLENTLY. I PULLED INTO A GAS STATION THAT I WAS LUCKILY CLOSE TO, AND THE CAR LURCHED FORWARD…
Read full complaint
I WAS DRIVING DOWN THE ROAD, WHEN A WARNING SIGNAL WENT OFF ON MY CAR, A MESSAGE CAME UP THAT SAID "ENGINE POWER REDUCED" AND MY CARS ACCELERATION WAS SIGNIFICANTLY REDUCED. I COULD NOT GO OVER 10 MILES AN HOUR AND THE CAR WAS SHAKING VIOLENTLY. I PULLED INTO A GAS STATION THAT I WAS LUCKILY CLOSE TO, AND THE CAR LURCHED FORWARD AS SOON AS I PUT IT IN PARK, ALMOST CAUSING ME TO HIT THE BUILDING DIRECTLY IN FRONT OF MY PARKING SPOT. I TURNED THE CAR OFF AND LET IT SIT FOR MINUTE, ONLY TO TURN IT BACK ON AND HAVE IT ACT COMPLETELY NORMAL. I HAVE HAD 3 DIFFERENT MECHANICS LOOK AT IT, AND SEVERAL THINGS REPLACED AND THE PROBLEM STILL PERSISTS. MY CAR CANNOT GO MORE THAN 10 MINUTES WITHOUT HAVING THIS ISSUE, AND THE NEXT TIME IT HAPPENED I WAS ON THE FREEWAY AND IT ALMOST KILLED ME AND THE PERSON BEHIND ME. I HAVE READ THE CHEVY FORUMS AND COMPLAINS AND I AM NOT THE ONLY PERSON HAVING THIS ISSUE. THERE ARE MANY PEOPLE, IN MY POSITION WHO CANNOT AFFORD NEW CARS, WHO BOUGHT CHEVY'S BC OF THE AMERICAN NAME TO ONLY BE SCREWED BY THE CORPORATION. I HAVE NO CHOICE BUT TO DRIVE THE CAR AS I HAVE TO GET TO AND FROM WORK IN ORDER TO LIVE, WHILE THIS CONTINUES TO HAPPEN EVERY TIME I DRIVE THE CAR. SOMEONE. NEEDS TO MAKE CHEVY ACCOUNTABLE FOR THEIR TERRIBLE CARS!
NHTSA ODI #10763982
180,000 miles · Aug 24, 2015
EngineSteering
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE POWER STEERING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10758984
Mileage unknown · Apr 18, 2015
EngineService BrakesSuspensionCrashInjury
BROUGHT 2007 COBALT ON 7/09/14. REPORTED THE PROBLEM OF THE VEHICLE SHUTTING- OFF ON ME AND NO INSPECTION STICKER WAS ON THE CAR 7/10/14. THEY WROTE A WORK ORDER OUT. BROUGHT THE VEHICLE TO ARCHER AUTO TO GET WORK PERFORMED AND FOR A INSPECTION STICKER. ARCHER AUTO KEPT MY 2007 COBALT FOR 3 MONTHS. UNTIL I CALLED BBB BUSINESS …
Read full complaint
BROUGHT 2007 COBALT ON 7/09/14. REPORTED THE PROBLEM OF THE VEHICLE SHUTTING- OFF ON ME AND NO INSPECTION STICKER WAS ON THE CAR 7/10/14. THEY WROTE A WORK ORDER OUT. BROUGHT THE VEHICLE TO ARCHER AUTO TO GET WORK PERFORMED AND FOR A INSPECTION STICKER. ARCHER AUTO KEPT MY 2007 COBALT FOR 3 MONTHS. UNTIL I CALLED BBB BUSINESS AND FILED A COMPLAINT. ARCHER AUTO SAID THEY FIX MY VEHICLE BUT DIDN'T. ARCHER AUTO PUT A ILLEGAL INSPECTION STICKER ON IT TO PASS THE EMISSION TEST. ARCHER AUTO RETURNED MY VEHICLE. THEN THE POWER STEERING WENT OUT. BROUGHT IT TO FIRESTONE TO GET FIX. THEN LATER FOUND OUT THERE WAS A RECALL ON THE POWER STEERING. THE 2007 COBALT WAS SHUTTING-OFF ON ME AND LOSING ALL POWER..THEN I TOOK IT BACK BECAUSE THEIR WAS ANOTHER RECALL ON THE VEHICLE. THEN ON 9/13/14 THE ENGINE SHUT-OFF ON ME. LOSING ALL POWER , LOCKING THE BRAKES AND POWER STEERING ALSO. I RAN INTO THE BACK OF A VEHICLE AND TOTALED PUT THE 2007 COBALT. *TR
NHTSA ODI #10706462
140,000 miles · Mar 17, 2015
EnginePower TrainVehicle Speed Control
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 70 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE SPEEDOMETER REMAINED ON 0 MPH. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO NUMEROUS DEALERS, WHO CONFIRMED THAT THE TRANSMISSION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 70 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE SPEEDOMETER REMAINED ON 0 MPH. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO NUMEROUS DEALERS, WHO CONFIRMED THAT THE TRANSMISSION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10694866
100,000 miles · Jan 27, 2015
EngineInjury
CAR JUST TURNED OFF WITH NO POWER, WHILE BACKING FROM DRIVEWAY. COULD NOT STOP THE VEHICLE AND RAN OVER MY BOYFRIENDS FOOT. TWO NEIGHBORS WERE ABLE TO STOP MY VEHICLE SINCE WASN'T GOING FAST. NO WARNING. VEHICLE WOULD NOT RESTART. JUST PASSED ANNUAL INSPECTION AND ALWAYS FOLLOWED MAINTENANCE SCHEDULE. IT SHOULD BE NOTED THAT …
Read full complaint
CAR JUST TURNED OFF WITH NO POWER, WHILE BACKING FROM DRIVEWAY. COULD NOT STOP THE VEHICLE AND RAN OVER MY BOYFRIENDS FOOT. TWO NEIGHBORS WERE ABLE TO STOP MY VEHICLE SINCE WASN'T GOING FAST. NO WARNING. VEHICLE WOULD NOT RESTART. JUST PASSED ANNUAL INSPECTION AND ALWAYS FOLLOWED MAINTENANCE SCHEDULE. IT SHOULD BE NOTED THAT MY BOYFRIEND INJURED HIS FOOT AND WANTS TO FILE A CLAIM WITH MY INSURANCE.IM TRYING TO TALK HIM OUT OF IT BECAUSE I DON'T FEEL I WAS AT FAULT AND I DON'T WANT MY RATES TO INCREASE. CHEVY CORP SHOULD RESOLVE THIS ISSUE BEFORE SOMEONE DIES. I TOOK MY VEHICLE TO THE CHEVY DEALER AND THEY WANT TO REPLACE MY ENGINE AT MY COST. $3800. *TR
NHTSA ODI #10679273
129,317 miles · Nov 17, 2014
Electrical SystemEngineFuel/propulsion System
I WAS DRIVING IN TOWN AND SUDDENLY LOST ALL POWER. I HAD TO USE THE MOMENTUM OF THE CAR TO MOVE OVER 2 LANES OF TRAFFIC IN ORDER TO GET PULLED TO THE SIDE OF THE ROAD. HAD IT TOWED TO THE MECHANIC AND FOUND OUT THAT BOTH THE FUEL PUMP AND THE ELECTRICAL PANEL UNDER MY FUSE BOX HAD GONE OUT. THIS COST ME OVER $1800.00 TO HAVE FIX…
Read full complaint
I WAS DRIVING IN TOWN AND SUDDENLY LOST ALL POWER. I HAD TO USE THE MOMENTUM OF THE CAR TO MOVE OVER 2 LANES OF TRAFFIC IN ORDER TO GET PULLED TO THE SIDE OF THE ROAD. HAD IT TOWED TO THE MECHANIC AND FOUND OUT THAT BOTH THE FUEL PUMP AND THE ELECTRICAL PANEL UNDER MY FUSE BOX HAD GONE OUT. THIS COST ME OVER $1800.00 TO HAVE FIXED AND THE MECHANIC STATES GM WAS AWARE OF THE FUSE BOX ISSUE AND TO WATCH FOR A RECALL. ALSO THE FUEL PUMP WAS A SPECIALTY THAT WAS NOT PLACED IN MOST CARS OF THIS YEAR/MODEL AND HAD TO BE ORDERED FROM THE FACTORY. THE PROBLEMS THAT ARE HAPPENING WITH THESE CARS ARE RIDICULOUS. GM SHOULD HAVE TO PAY THE OWNERS TO HAVE THE ENTIRE CAR REPLACED. *TR
NHTSA ODI #10658566
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration