NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
2,330 reports139,000 miles · Mar 10, 2014
Engine
I WAS DRIVING EAST ON US HWY 2 AT 35 MPH WHEN MY CAR SUDDENLY SHUT OFF. I WAS IN THE MIDDLE LANE AND WAS ABLE TO PULL TO THE RIGHT LANE WITH NO TRAFFIC COMING. THIS HAPPENED 3 MORE TIMES IN A 2 MILE DISTANCE. I PARKED THE CAR AND IMMEDIATELY NOTIFIED CHEVY AND MY LOCAL CHEVY DEALER. CHEVY TOLD ME MY CAR HAD A RECALL THAT WOULD N…
Read full complaint
I WAS DRIVING EAST ON US HWY 2 AT 35 MPH WHEN MY CAR SUDDENLY SHUT OFF. I WAS IN THE MIDDLE LANE AND WAS ABLE TO PULL TO THE RIGHT LANE WITH NO TRAFFIC COMING. THIS HAPPENED 3 MORE TIMES IN A 2 MILE DISTANCE. I PARKED THE CAR AND IMMEDIATELY NOTIFIED CHEVY AND MY LOCAL CHEVY DEALER. CHEVY TOLD ME MY CAR HAD A RECALL THAT WOULD NOT BE AVAILABLE UNTIL APRIL 1. VON HOLZEN CHEVY DEALER SAID UNLESS THEY KNEW WHAT WAS WRONG AND I PAID 600 THEY WOULD NOT FIX IT. *TR
NHTSA ODI #10568128
36,998 miles · Mar 8, 2014
Fuel System, Gasoline
RECALL CAMPAIGN NUMBER 09V419000 COMPONENTS: FUEL SYSTEM GASOLINE RECALL #090226 UNDER MY VEHICLE SUPPOSEDLY THIS WAS UNDER WARRANTY AND WAS REPLACED IN 2008. I SERVICES MY VEHICLE IN 2010 AND MY VEH REPORT INDICATES REPLACEMENT OF FUEL TANK MODULE WAS ALREADY DONE UNDER RECALL #09226. MY VEHICLE WAS WORKED ON 2/28/2014 HAVE BE…
Read full complaint
RECALL CAMPAIGN NUMBER 09V419000 COMPONENTS: FUEL SYSTEM GASOLINE RECALL #090226 UNDER MY VEHICLE SUPPOSEDLY THIS WAS UNDER WARRANTY AND WAS REPLACED IN 2008. I SERVICES MY VEHICLE IN 2010 AND MY VEH REPORT INDICATES REPLACEMENT OF FUEL TANK MODULE WAS ALREADY DONE UNDER RECALL #09226. MY VEHICLE WAS WORKED ON 2/28/2014 HAVE BEEN HAVE GAS LEAK AND ODOR HAD ME WORRIED, COME TO FIND OUT FUEL PUMP MODULE NEEDS TO BE REPLACED. I SPENT $112.07 FOR WORK SEAL REPLACEMENT AND LABOR. WAS NOT ABLE TO AFFORD TO PAY ESTIMATE COST FOR PARTS AND LABOR FUEL PUMP MODULE IS $569.38. I FORGOT I HAD THIS REPLACED IN 2008... I RECENTLY TOOK MY VEHICLE IN TO CHEVY SERVICE CENTER ON CAPITOL EXPRESSWAY IN SAN JOSE. [XXX] LAWTON PULLED UP MY VEHICLE REPORT AND I COMPLAINED ABOUT THE GAS LEAK FIRST THING CAME OUT OF HIS RUDE MOUTH WAS YOU MUST OF HEARD THIS ON THE NEWS RIGHT! I TOLD ABOUT THE GAS LEAK HE SAID THIS PART WAS ALREADY REPLACED AND I ASKED THEN WHY IS IT HAPPENING AGAIN SAID MAYBE COULD HAVE BEEN A DEFECTIVE PART. I NOW SEE THAT THERE IS A RECALL ON ELECTRICAL SYSTEM IGNITION SWITCH AND CAN CAUSE THE VEHICLE IN A CRASH. [XXX] SAID I HAD NO REPORTS ON MY VEHICLE FOR RECALL. NOW IM REALLY CONCERNED IF I GET INTO A COLLISION AND MY VEHICLE IS CURRENTLY SPOTTING WITH FUEL AND ODOR IS PRETTY STRONG SHOULD I HAPPEN TO HAVE A COLLISION IM SURE WILL CAUSE A COMBUSTION TO CHARGE A FIRE. FUEL PUMP MODULE'S. GAS LEAK, FUEL LEAK, ODOR. SAFETY COMES FIRST. THIS NEEDS TO BE ADDRESSED TO ALL SERVICE CONSULTANTS. ACROSS THE BOARD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10567949
53,000 miles · Mar 8, 2014
Structure
2006 CHEVROLET COBALT DOORS WON'T OPEN FROM EITHER THE INSIDE OR THE OUTSIDE AFTER RAIN. THE HANDLE MOVES, BUT THE DOOR WON'T OPEN. THIS AFFECTS BOTH PASSENGER AND DRIVER DOORS, BUT FORTUNATELY HASN'T YET AFFECTED BOTH AT THE SAME TIME. WHEN THIS HAPPENS, WE CAN ONLY GET OUT OF THE CAR BY THE ONE WORKING DOOR. IT TAKES DAYS BEFO…
Read full complaint
2006 CHEVROLET COBALT DOORS WON'T OPEN FROM EITHER THE INSIDE OR THE OUTSIDE AFTER RAIN. THE HANDLE MOVES, BUT THE DOOR WON'T OPEN. THIS AFFECTS BOTH PASSENGER AND DRIVER DOORS, BUT FORTUNATELY HASN'T YET AFFECTED BOTH AT THE SAME TIME. WHEN THIS HAPPENS, WE CAN ONLY GET OUT OF THE CAR BY THE ONE WORKING DOOR. IT TAKES DAYS BEFORE THE DOOR WORKS AGAIN. WE'RE CONCERNED ABOUT BEING TRAPPED IN THE CAR IN THE EVENT OF AN ACCIDENT, FIRE, ETC. WE HAD THE DOOR LOCK/LATCH REPLACED, BUT THE SAME PROBLEM STILL OCCURS. *TR
NHTSA ODI #10567945
85,000 miles · Mar 6, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE SUDDENLY STALLED. THE ENGINE WAS RESTARTED AND THE VEHICLE RESUMED NORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE BATTERY, CLEANED THE FUEL SYSTEM AND CHANGED THE SPARK PLUGS BUT THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE SUDDENLY STALLED. THE ENGINE WAS RESTARTED AND THE VEHICLE RESUMED NORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE BATTERY, CLEANED THE FUEL SYSTEM AND CHANGED THE SPARK PLUGS BUT THE FAILURE PERSISTED. ADDITIONALLY, THE CONTACT STATED THAT THE KEY WOULD SPORADICALLY BECOME STUCK IN THE IGNITION SWITCH. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 14V047000(AIR BAGS , ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE VEHICLE HAD EXPERIENCED THE SAME DEFECT LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 85,000. *TR
NHTSA ODI #10567629
85,000 miles · Mar 5, 2014
Power TrainCrash
WHEN MY DAUGHTER EXITED HER CAR SHE GRABBED HER BACKPACK FROM THE PASSENGER SEAT. ONE OF THE STRAPS FROM THE BACKPACK HOOKED AROUND THE SHIFTER AND MOVED IT TO NEUTRAL. WE DID NOT KNOW THE SHIFTER DID NOT LOCK WHEN YOU PUT IT IN PARK.THE CAR STARTED ROLLING BACKWARD DOWN OUR DRIVEWAY WITH THE DRIVERS DOOR OPEN. THE DOOR CAUGHT O…
Read full complaint
WHEN MY DAUGHTER EXITED HER CAR SHE GRABBED HER BACKPACK FROM THE PASSENGER SEAT. ONE OF THE STRAPS FROM THE BACKPACK HOOKED AROUND THE SHIFTER AND MOVED IT TO NEUTRAL. WE DID NOT KNOW THE SHIFTER DID NOT LOCK WHEN YOU PUT IT IN PARK.THE CAR STARTED ROLLING BACKWARD DOWN OUR DRIVEWAY WITH THE DRIVERS DOOR OPEN. THE DOOR CAUGHT ONE OF OUR TREES IN OUR YARD PINNING IT AGAINST THE FRONT FENDER DAMAGING THE DOOR AND FRONT FENDER. SHE HAD HER KEY IN HER HAND SO THE IGNITION WAS NOT ON. AFTER READING ON THE INTERNET SEVERAL OF THESE SHIFTERS ARE DEFECTIVE. THIS IS A DANGEROUS ISSUE THAT GM IS IGNORING. *TR
NHTSA ODI #10567159
110,000 miles · Mar 5, 2014
Electrical SystemSuspensionVehicle Speed Control
DRIVING ON 127 NORTH TOWARD LANSING MICHIGAN AT 75 MILES PER HOUR WHEN THE ENGINE LOST CONTROL CAUSING THE CAR TO GO NO FASTER THAN 15 MILES PER HOUR ON THE HIGHWAY. THIS IS A SAFETY RISK TO THE DRIVER AS WELL AS OTHERS. I HAVE REPLACED THE GAS PEDDLE SENSOR WHICH DID NOT CORRECT THE PROBLEM, NEXT I WILL REPLACE THE THROTTLE BOD…
Read full complaint
DRIVING ON 127 NORTH TOWARD LANSING MICHIGAN AT 75 MILES PER HOUR WHEN THE ENGINE LOST CONTROL CAUSING THE CAR TO GO NO FASTER THAN 15 MILES PER HOUR ON THE HIGHWAY. THIS IS A SAFETY RISK TO THE DRIVER AS WELL AS OTHERS. I HAVE REPLACED THE GAS PEDDLE SENSOR WHICH DID NOT CORRECT THE PROBLEM, NEXT I WILL REPLACE THE THROTTLE BODY. THE CODES CAN BE RESET TO CORRECT THE PROBLEM TEMPORARY IF YOU PURCHASE A $300 DOLLAR CODE READER. I HAVE ALSO HAD TO REPLACE THE FRONT BEARINGS TWICE. ON 2/16/2014 I HIT A POT HOLE AND KNOCKED A BOLT LOOSE THAT HOLDS THE CARS FRAME TOGETHER SO AT THIS POINT THE CAR IS UNSAFE TO DRIVE. AT LEAST I'M HOPING ITS LOOSE AND NOT BROKE. THE CAR SHAKES TERRIBLY DUE TO THE FRAME BOLT. THIS IS A BIG SAFETY CONCERN. *TR
NHTSA ODI #10567149
118,000 miles · Mar 4, 2014
Air BagsElectrical SystemSteering
MY WIFE AND HER MOTHER WERE DRIVING ON A STREET IN THE CITY THAT WE LIVE IN. THIS STREET DOES HAVE A MILD TO MODERATE AMOUNT OF TRAFFIC DEPENDING ON THE TIME OF DAY. IT IS A TWO LANE ROAD THAT FOR THE MOST PART GOES THROUGH THE RESIDENTIAL AREA OF THE CITY THAT WE LIVE IN AS WELL AS THE NEIGHBORING CITY. THE SPEED LIMIT PREDOMIN…
Read full complaint
MY WIFE AND HER MOTHER WERE DRIVING ON A STREET IN THE CITY THAT WE LIVE IN. THIS STREET DOES HAVE A MILD TO MODERATE AMOUNT OF TRAFFIC DEPENDING ON THE TIME OF DAY. IT IS A TWO LANE ROAD THAT FOR THE MOST PART GOES THROUGH THE RESIDENTIAL AREA OF THE CITY THAT WE LIVE IN AS WELL AS THE NEIGHBORING CITY. THE SPEED LIMIT PREDOMINATELY IS 35 MPH. AT THE TIME OF THE INCIDENT, MY WIFE WAS TRAVELING TO THE SOUTH IN WHICH THE ROADWAY PROCEEDS DOWN A SHORT, MILD DOWNGRADE IN TO A NATURAL WASH OR STREAM BED AND THEN BACK UP AN UPGRADE TO THE SOUTH SIDE OF TOWN AND THE NEIGHBORING CITY. MY WIFE WAS TRAVELING DOWNHILL WHEN SUDDENLY SHE LOST POWER TO THE VEHICLE AND THE STEERING LOCKED UP. THE ENGINE WAS STILL RUNNING BUT ALL THE ELECTRICAL COMPONENTS OF THE VEHICLE SUCH AS THE GAUGES AND THE CAR STEREO CEASED TO WORK.DUE TO THE STEERING LOCKING UP AND MY WIFE BEING UNABLE AT THE TIME TO CONTROL THE VEHICLE, SHE DRIFTED IN THE OPPOSITE LANE, BOUNCED OFF A CURB ON THAT SIDE OF THE ROAD AND THEN DRIFTED BACK INTO THE APPROPRIATE LANE BEFORE COMING TO A STOP. FORTUNATELY FOR THE SAFETY AND WELL-BEING OF MY WIFE AND HER MOTHER, NO OTHER VEHICLE WAS IN OR APPROACHING THE OPPOSITE LANE. WHEN THE VEHICLE CAME TO A STOP, THE ENGINE STALLED WHEN THE KEY IGNITION WAS IN THE RUN POSITION. MY WIFE PROCEEDED TO SWITCH THE KEY IN THE OFF POSITION AND THEN PROCEEDED TO RESTART THE VEHICLE. THE VEHICLE THEN STARTED UP LIKE NORMAL. MY WIFE PROCEEDED TO DRIVE THE VEHICLE TO HER ORIGINAL DESTINATION WHICH WAS ONLY A COUPLE OF MILES AWAY. SHE THEN NOTIFIED ME BY CELLPHONE IN WHICH WE STARTED THE PROCESS OF TRYING TO GET THIS ISSUE RESOLVED. *TR
NHTSA ODI #10566989
Mileage unknown · Mar 4, 2014
Electrical System
THE DRIVER DOOR IS JAMMED, IT WILL NOT OPEN FROM INSIDE OR OUT. HAPPENED BEFORE AND THEN OPENED AFTER AWHILE AND THEN IT HAPPENED AGAIN. I'VE HAD THE DOOR FIXED AND IT WORKED FOR ABOUT 3 WEEKS AND IS NOW JAMMED AGAIN. IT IS A SAFETY HAZARD, I HAVE TO GO INTO THE CAR THROUGH THE PASSENGER SIDE. MY SPEAKERS IN ALL DOORS WILL NOT W…
Read full complaint
THE DRIVER DOOR IS JAMMED, IT WILL NOT OPEN FROM INSIDE OR OUT. HAPPENED BEFORE AND THEN OPENED AFTER AWHILE AND THEN IT HAPPENED AGAIN. I'VE HAD THE DOOR FIXED AND IT WORKED FOR ABOUT 3 WEEKS AND IS NOW JAMMED AGAIN. IT IS A SAFETY HAZARD, I HAVE TO GO INTO THE CAR THROUGH THE PASSENGER SIDE. MY SPEAKERS IN ALL DOORS WILL NOT WORK ALONG WITH THE RADIO SCREEN WILL FLICKER ON AND OFF. THE AUTOMATIC LOCKS WORKED ON A FEW DOORS BUT WILL NOT WORK ON ANY NOW. I'VE SEEN AND HEARD MANY COMPLAINTS ABOUT THE SAME PROBLEMS I'M HAVING THAT OTHER COBALT OWNERS HAVE/HAD. *TR
NHTSA ODI #10566977
149,000 miles · Mar 3, 2014
Steering
I WAS ATTEMPTING TO TURN INTO A DRIVE AND THE STEERING BECAME HARD TO TURN. AFTERWARDS POWER STEERING APPEARED TO WORK NORMAL. *TR
NHTSA ODI #10566856
110,482 miles · Feb 28, 2014
Steering
I WAS DRIVING ON THE HIGHWAY IN NORTH CAROLINA ON VACATION AT 65-70 MPH WHEN THE IGNITION KICKED OFF LUCKILY I ACTED QUICKLY AND RESTARTED THE CAR THERE HAVE BEEN A FEW OTHER INSTANCES WHEN THE IGNITION HAS JUST SHUT OFF WITH OUT WARNING. I DRIVE A 5 SPEED SO I THOUGHT IT WAS BECAUSE I TOOK MY FOOT AWAY FROM THE GAS, BUT I JUST …
Read full complaint
I WAS DRIVING ON THE HIGHWAY IN NORTH CAROLINA ON VACATION AT 65-70 MPH WHEN THE IGNITION KICKED OFF LUCKILY I ACTED QUICKLY AND RESTARTED THE CAR THERE HAVE BEEN A FEW OTHER INSTANCES WHEN THE IGNITION HAS JUST SHUT OFF WITH OUT WARNING. I DRIVE A 5 SPEED SO I THOUGHT IT WAS BECAUSE I TOOK MY FOOT AWAY FROM THE GAS, BUT I JUST LEARNED THAT GM HAS A RECALL OUT ON THIS MODEL FOR SIMILAR PROBLEMS. *TR
NHTSA ODI #10566424
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration