NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
2,330 reports110,000 miles · Mar 19, 2014
Electrical SystemService BrakesCrash
TL* THE CONTACT OWNS A 2006 CHEVY COBALT. THE CONTACT BECAME INVOLVED IN A CRASH IN WHICH THE AIR BAGS DID NOT DEPLOY. THE DETAILS OF THE CRASH WERE LIMITED HOWEVER, THE CONTACT WAS TRAVELING 20 MPH WHEN THE CRASH OCCURRED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THE CONTACT ALSO STATED THAT T…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVY COBALT. THE CONTACT BECAME INVOLVED IN A CRASH IN WHICH THE AIR BAGS DID NOT DEPLOY. THE DETAILS OF THE CRASH WERE LIMITED HOWEVER, THE CONTACT WAS TRAVELING 20 MPH WHEN THE CRASH OCCURRED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THE CONTACT ALSO STATED THAT THE BRAKES MALFUNCTIONED. ADDITIONALLY, THE IGNITION SWITCH FAILED. THE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #10573563
30,000 miles · Mar 19, 2014
Service BrakesSteering
I PURCHASED MY 2006 COBALT IN FEBRUARY OF 2007 WITH MILEAGE OF +/- 30000, WITHIN THE FIRST 2 WEEKS I HAD TO HAVE THE STEERING COLUMN AND POWER STEERING ASSIST REPLACED AND HAD TO PAY FOR FRONT END ALIGNMENT CAUSED BY THE STEERING A) STEERING WHEEL SHAKING WHEN DRIVING AT HIGHWAY SPEEDS AND VERY VIOLENTLY WHEN BREAKING AND B) THE…
Read full complaint
I PURCHASED MY 2006 COBALT IN FEBRUARY OF 2007 WITH MILEAGE OF +/- 30000, WITHIN THE FIRST 2 WEEKS I HAD TO HAVE THE STEERING COLUMN AND POWER STEERING ASSIST REPLACED AND HAD TO PAY FOR FRONT END ALIGNMENT CAUSED BY THE STEERING A) STEERING WHEEL SHAKING WHEN DRIVING AT HIGHWAY SPEEDS AND VERY VIOLENTLY WHEN BREAKING AND B) THE POWER STEERING GOING OUT. THE CAR NOW HAS 107000 MILES ON IT AND HAVE HAD TROUBLE WITH THIS SAME SHAKING WHEN DRIVING AND IT BEING VIOLENT WHEN BREAKING. THE DEALERSHIP STATES GM IS AWARE BUT I STILL HAVE HAD TO REDO MY FRONT BRAKES TWICE (WHICH HELPS TEMPORARILY)..THE LAST TIME BEING IN JUNE OR AUGUST OF 2013. THE SHOP TELLS ME THE PROBLEM THE FIRST TIME WAS THE FRONT ROTORS WERE STICKING AND THE GROUND THEM DOWN SMOOTH. THEN THE SHAKING STARTED AGAIN. I HAD TO TAKE MY CAR IN TO HAVE THE ROTORS GROUND DOWN AGAIN AND HAVE A SERPENTINE BELT REPLACED. SO HERE I AM AGAIN 7 MONTHS LATER AND WILL HAVE TO DO THIS AGAIN BECAUSE THE SHAKING HAS STARTED AGAIN AND IS BECOMING SO BAD IT WILL HAVE TO GO TO THE SHOP AGAIN AT MY COST FOR SOMETHING THEY KNOW ABOUT BUT WILL NOT FIX. I HAVE ALREADY RECEIVED A RECALL LETTER REGARDING THE IGNITION PROBLEM BUT AM TOLD THAT THE PARTS ARE NOT AVAILABLE AND WILL BE INFORMED WHEN THEY ARE. THIS STEERING/BRAKING PROBLEM IS SERIOUS AND I SOME TIMES FEAR THAT EITHER SOMETHING WILL BREAK INSIDE THE CAR OR I WILL NOT BE ABLE TO HOLD ON TO THE STEERING WHEEL AND WILL WREAK. I AM AFRAID TO DRIVE MY CAR ANY DISTANCE OR SPEED BECAUSE I FEAR IT WILL FAIL AND I SEE THAT THIS HAS BEEN AN ONGOING PROBLEM SINCE 2007 AND PEOPLE HAVE COMPLAINED BUT HAVE RECEIVED NO SATISFACTION. *TR
NHTSA ODI #10573468
76,000 miles · Mar 19, 2014
Power Train
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO PARK. THE CONTACT DISASSEMBLED THE GEAR SHIFT ASSEMBLY TO FIND THAT THE PIN BECAME DETACHED. THE CONTACT PLACED THE PIN BACK IN POSITION AND WAS ABLE TO SHIFT INTO PARK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. T…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO PARK. THE CONTACT DISASSEMBLED THE GEAR SHIFT ASSEMBLY TO FIND THAT THE PIN BECAME DETACHED. THE CONTACT PLACED THE PIN BACK IN POSITION AND WAS ABLE TO SHIFT INTO PARK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 76,000.
NHTSA ODI #10573384
80,000 miles · Mar 19, 2014
Electrical SystemEngineService Brakes
DRIVING DOWN THE ROAD AND ALL ITEMS ON GAUGE CLUSTER DIE AND COME BACK ON OVER AND OVER AGAIN. SECURITY LIGHT POPS ON ABS LIGHT COMES ON AIR BAG LIGHT COMES ON. I LOSE POWER STEERING WHEN THIS HAPPENS AND SOMETIME VEHICLE WONT START AND MY SECURITY LIGHT POPS ON. SOMETIMES NOTHING IN MY GAUGE CLUSTER WONT WORK AND ALL WARNING L…
Read full complaint
DRIVING DOWN THE ROAD AND ALL ITEMS ON GAUGE CLUSTER DIE AND COME BACK ON OVER AND OVER AGAIN. SECURITY LIGHT POPS ON ABS LIGHT COMES ON AIR BAG LIGHT COMES ON. I LOSE POWER STEERING WHEN THIS HAPPENS AND SOMETIME VEHICLE WONT START AND MY SECURITY LIGHT POPS ON. SOMETIMES NOTHING IN MY GAUGE CLUSTER WONT WORK AND ALL WARNING LIGHTS WILL APPEAR WHEN DRIVING DOWN THE ROAD OR AS SOON AS I START MY VEHICLE. *TR
NHTSA ODI #10573316
22,000 miles · Mar 18, 2014
Power TrainSteeringCrashInjury
WHEN THE ACCIDENT HAPPEN, MY SON AND HIS FRIEND WERE GOING TO HIS OTHER FRIEND HOUSE TO STAY. HIS FRIEND THAT LIVED SAID HE WAS HAVING TROUBLE CONTROLLING THE STEERING THEY RAN OFF THE ROAD HITTING THE SIDE OF THE ROAD FLIPPING THE CAR, MY SON WAS THROWN OUT OF THE CAR AND WAS DEAD ON THE SCENE. *TR
NHTSA ODI #10573272
22,000 miles · Mar 18, 2014
Power TrainSteeringUnknown Or OtherCrashInjury
YOU KNOW WHEN MY SON BOUGHT THIS CAR, I KNOW HE THOUGHT HE HAD THE BEST, THIS IS PART OF YOUR REVIEWS. NEW FOR 2006 ARE SS SEDAN AND COUPE MODELS WITH NORMALLY ASPIRATED ENGINES. THESE NEW SS MODELS FIT BETWEEN THE LT AND SS SUPERCHARGED MODELS. THEIR PRICE, POWER AND PERFORMANCE AND BODY WORK ARE ALL TONED DOWN FROM THE SS SUPE…
Read full complaint
YOU KNOW WHEN MY SON BOUGHT THIS CAR, I KNOW HE THOUGHT HE HAD THE BEST, THIS IS PART OF YOUR REVIEWS. NEW FOR 2006 ARE SS SEDAN AND COUPE MODELS WITH NORMALLY ASPIRATED ENGINES. THESE NEW SS MODELS FIT BETWEEN THE LT AND SS SUPERCHARGED MODELS. THEIR PRICE, POWER AND PERFORMANCE AND BODY WORK ARE ALL TONED DOWN FROM THE SS SUPERCHARGED COUPE, BUT THEY'RE SPORTY CARS AND POSSIBLY THE BEST CHOICE IN THE LINEUP, BOASTING 171-HORSEPOWER ENGINES AND SPORTS SUSPENSIONS.THIS CAR WAS SUPPOSE TO HANDLE GOOD. BUT NOW HE IS DEAD BECAUSE OF THIS CAR. DO YOU PEOPLE AT CHEVORLET EVEN KNOW HOW PEOPLE FEEL OR WHAT KIND OF EMOTION A PARENT GOES THROUGH WITH LOSING A CHILD AND HOW MY LIFE HAS CHANGED. I WILL NEVER SEE HIM GET MARRIED, HAVE CHILDREN. I WILL NEVER BE ABLE TO TALK TO HIM, FEEL HIM, TELL HIM I LOVE HIM. YES, I'M HURT. I WANT YOU TO PAY FOR THE MESS YOU HAVE DONE FOR MY SON'S LIFE AND THE LIFE OF OTHERS. BECAUSE YOU GUYS HID THIS MESS FOR YEARS YOU KNEW. HOW MANY PEOPLE HAVE TOO GET INJURED OR DIE. JUST LOOK AT ALL THE RECALLS JUST FOR THIS CAR. JUST TO THINK CHEVROLET HAS BEEN THE CHOICE OF VEHICLES WE HAVE ALWAYS DRIVEN. *TR
NHTSA ODI #10573270
48,000 miles · Mar 17, 2014
Electrical System
DEAR SIRS, I NO LONGER FEEL SAFE SENDING MY DAUGHTER BACK AND FORTH TO COLLEGE WITH HER CHEVY COBALT. IF SOMETHING DOES HAPPEN WITH HER CAR KNOWING WHAT I KNOW NOW.....I WILL BE THE ONE WHO IS AT BLAME. SHE WENT BACK TO COLLEGE THIS MORNING......DRIVING THE COBALT. I AM SUFFERING TO MUCH ANXIETY OVER THIS. WHY DID I LET HER…
Read full complaint
DEAR SIRS, I NO LONGER FEEL SAFE SENDING MY DAUGHTER BACK AND FORTH TO COLLEGE WITH HER CHEVY COBALT. IF SOMETHING DOES HAPPEN WITH HER CAR KNOWING WHAT I KNOW NOW.....I WILL BE THE ONE WHO IS AT BLAME. SHE WENT BACK TO COLLEGE THIS MORNING......DRIVING THE COBALT. I AM SUFFERING TO MUCH ANXIETY OVER THIS. WHY DID I LET HER GO! COULD YOU PLEASE GIVE HER A SAFER CAR TO DRIVE? ....MAYBE AT LEAST UNTIL HER CAR IS FIXED? *TR
NHTSA ODI #10572867
62,300 miles · Mar 17, 2014
Electrical SystemEngine
I CALLED TWO LOCAL CHEVY DEALERSHIPS TODAY. ONE SAID THEY ARE WAITING ON INSTRUCTIONS FROM GM TO DECIDE HOW TO RESOLVE THE SITUATION. THE OTHER SAID THEIR SERVICE MANAGER IS OUT UNTIL WEDNESDAY AND ONLY THEN CAN THEY APPLY THROUGH GM FOR A LOANER CAR AND THAT PROCESS TAKES A FEW DAY. I HAVE WATCHED SOMEONE DIE IN A CAR CRASH AN…
Read full complaint
I CALLED TWO LOCAL CHEVY DEALERSHIPS TODAY. ONE SAID THEY ARE WAITING ON INSTRUCTIONS FROM GM TO DECIDE HOW TO RESOLVE THE SITUATION. THE OTHER SAID THEIR SERVICE MANAGER IS OUT UNTIL WEDNESDAY AND ONLY THEN CAN THEY APPLY THROUGH GM FOR A LOANER CAR AND THAT PROCESS TAKES A FEW DAY. I HAVE WATCHED SOMEONE DIE IN A CAR CRASH AND I DIDN'T QUITE UNDERSTAND THE SEVERITY OF THIS ISSUE UNTIL I REALIZED THAT PEOPLE HAVE BEEN KILLED. AS A ONE CAR FAMILY, GETTING TO WORK SO THAT WE CAN KEEP OUR HEAD ABOVE WATER IS ALWAYS MY MAIN PRIORITY. GM IS NOT HELPING ME, I HAVE ALSO SENT THEM THE SAME INFORMATION I AM SENDING YOU. MY HUSBAND CANNOT DRIVE THIS CAR TO WORK UNTIL THE PROBLEM IS FIXED, IT IS NOT SAFE AND WE ARE FINANCIALLY SCREWED. I HAVE DRIVEN HUNDRED OF MY CLIENTS, ALL WITH DEVELOPMENTAL DISABILITIES IN MY COBALT. GM NOT ONLY KNOWINGLY PUT MY FAMILY'S LIVES AT RISK, THEY PUT THE LIVES OF HUNDREDS OF INDIVIDUALS WITH DEVELOPMENTAL DISABILITIES AT RISK ALSO. IF YOU NEED A TEXT BOOK EXAMPLE OF THE IGNITION SWITCH ISSUE ON THE COBALT, BY ALL MEANS, COME GET MINE. IT WILL RELIABLY FAIL. *TR
NHTSA ODI #10572786
62,300 miles · Mar 17, 2014
Electrical SystemEngine
I WOULD HAVE FILED SOONER BUT WAS UNAWARE OF YOUR AGENCY AND ASSUMED THAT I SHOULD CONTACT MY LOCAL GM DEALERSHIP. 2 DAYS AFTER I BOUGHT MY 2006 CHEVY COBALT, THE KEYS REMAINED LOCKED IN THE IGNITION. I HAVE TO USE THE EMERGENCY KEY RELEASE BUTTON TO GET MY KEYS OUT. I REPORTED THIS TO THE DEALERSHIP WHO INFORMED ME IN 2012 THA…
Read full complaint
I WOULD HAVE FILED SOONER BUT WAS UNAWARE OF YOUR AGENCY AND ASSUMED THAT I SHOULD CONTACT MY LOCAL GM DEALERSHIP. 2 DAYS AFTER I BOUGHT MY 2006 CHEVY COBALT, THE KEYS REMAINED LOCKED IN THE IGNITION. I HAVE TO USE THE EMERGENCY KEY RELEASE BUTTON TO GET MY KEYS OUT. I REPORTED THIS TO THE DEALERSHIP WHO INFORMED ME IN 2012 THAT THERE WAS NO RECALL AND I WOULD HAVE TO PAY TO RESOLVE THE ISSUE MYSELF. I BOUGHT A COBALT BECAUSE IT WAS ECONOMICAL AND WE DID NOT HAVE THE MONEY TO PAY FOR THE REPAIRS. TO THIS DAY, WE USE THE EMERGENCY SWITCH TO RELEASE MY KEYS. 1 WEEK AFTER I BOUGHT MY COBALT, THE ENGINE AND ALL POWER WOULD DIE AND I WOULD HAVE TO RESTART THE CAR. THIS HAPPENED WHEN I WAS IDLING, GOING 25 MILES/HR AND UP TO 65 MILES/HR. I CALLED THE CHEVY DEALERSHIP WHO INFORMED ME THAT THERE IS NOTHING THEY COULD DO, UNLESS I WANTED TO PAY TO HAVE THE ISSUE FIXED. I EVEN HAD ANOTHER RECALL REPAIRED LAST YEAR AT THE CHEVY DEALERSHIP AND AGAIN ADDRESSED THE POWER FAILURE. THEY LOOKED FOR AN ISSUE, DID NOT FIND ONE AND LITERALLY MADE ME BELIEVE IT WAS "USER ERROR". MY CAR STILL SHUTS OFF IN THE MIDDLE OF DRIVING, ALMOST ON A DAILY BASIS. I ADDRESSED THE SITUATION, I WAS IGNORED. I DID NOT HAVE THE MONEY TO EXPLORE THE ISSUE MORE THOROUGHLY, WE HAD NO CHOICE BUT TO DEAL WITH IT. I AM SENDING A SECOND MESSAGE TO YOU FOLLOWING THIS BECAUSE I AM OVER ON THE WORD COUNT. PLEASE LOOK FOR IT. *TR
NHTSA ODI #10572785
143,000 miles · Mar 17, 2014
Electrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE INTERIOR LIGHTS BEGAN TO FLICKER INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE INTERIOR LIGHTS BEGAN TO FLICKER INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000.
NHTSA ODI #10572750
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration