IllustrationWHILE DRIVING THE CAR THE POWER STEERING GOES OUT AND MAKES THE CAR HARD TO DRIVE. THE STEERING PUMP HAS BEEN CHANGED 2 TIMES SINCE ORIGINAL RECALL,BUT YET THE PROBLEM STILL EXISTS. *TR
2006 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1540–25K
42125–50K
55750–75K
34575–100K
331100–150K
142150K+
1,950 reports with mileage · 380 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
164 crash reports14 fire reports81 injury reports
What owners actually said
2,330 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED SHE WAS UNABLE TO SHIFT FROM DRIVE TO PARK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE A…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED THE FAILURE.
I HAVE A 2006 CHEVY COBALT. I HAVE HAD ISSUES WITH EVERY PART THAT HAS BEEN ISSUED A RECALL SO FAR AND THEN SOME. THE LATEST ISSUE IS THAT MY CAR IS LEAKING GASOLINE UNDER THE DRIVER SIDE DOOR. I SEE THAT THERE WAS A RECALL ISSUED FOR THIS IN 2009, BUT ONLY FOR VEHICLES IN CERTAIN STATES, IN WHICH I DO NOT RESIDE. I HAVE ALS…
Read full complaint
I HAVE A 2006 CHEVY COBALT. I HAVE HAD ISSUES WITH EVERY PART THAT HAS BEEN ISSUED A RECALL SO FAR AND THEN SOME. THE LATEST ISSUE IS THAT MY CAR IS LEAKING GASOLINE UNDER THE DRIVER SIDE DOOR. I SEE THAT THERE WAS A RECALL ISSUED FOR THIS IN 2009, BUT ONLY FOR VEHICLES IN CERTAIN STATES, IN WHICH I DO NOT RESIDE. I HAVE ALSO HAD ISSUES WITH MY IGNITION FOR SEVERAL YEARS, SO IT IS GOOD NEWS THAT A RECALL HAS COME UP FOR IT. BEFORE THE RECALL WAS ISSUED FOR THE POWER STEERING PUMP, I HAD NO POWER STEERING FOR SIX MONTHS PRIOR. I THINK THAT IT IS REPULSIVE THAT GM CAN MANUFACTURE THIS CAR AND JUST ISSUE RECALL AFTER RECALL WITH NO CONSEQUENCE. *TR
2006 CHEVROLET COBALT. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH, IGNITION LOCK CYLINDER AND KEY REPLACEMENT RECALL ISSUES. *SMD THE CONSUMER STATED HE ALWAYS EXPERIENCED PROBLEMS WITH THE VEHICLE, BUT COULD GET NEVER GET A RESOLUTION FROM THE DEALER, AS THEY COULD NEVER REPLICATE THE PROBLEM. THE CONSUMER RECEIVED THREE …
Read full complaint
2006 CHEVROLET COBALT. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH, IGNITION LOCK CYLINDER AND KEY REPLACEMENT RECALL ISSUES. *SMD THE CONSUMER STATED HE ALWAYS EXPERIENCED PROBLEMS WITH THE VEHICLE, BUT COULD GET NEVER GET A RESOLUTION FROM THE DEALER, AS THEY COULD NEVER REPLICATE THE PROBLEM. THE CONSUMER RECEIVED THREE RECALLS ABOUT THE URGENCY OF GETTING THE ISSUE FIXED. HOWEVER, THE DEALER DID NOT HAVE THE PARTS. *JB
HEAVY GAS ODOR AND GAS LEAK/SPOT UNDER CAR ON PASSENGER SIDE AT FUEL PUMP AREA ON 2006 COBALT. POOR GAS MILAGE AND SLUGGISH PERFORMANCE. *TR
MY CAR WAS PART OF THE GM RECALL FOR THE INCORRECT IGNITION SWITCHES. IT WAS RETURNED TO ME ON JULY 23RD, FIXED OR SO I WAS TOLD WITH A NEW IGNITION TO FIX THE ISSUE. HOWEVER WITHIN A WEEK OF HAVING THE CAR BACK, IT WAS DOING THE SAME AS BEFORE THE RECALL FIX WAS DONE. SLIPPING INTO ACCESSIBILITY MODE AND NOT GIVING ME ANY OPTIO…
Read full complaint
MY CAR WAS PART OF THE GM RECALL FOR THE INCORRECT IGNITION SWITCHES. IT WAS RETURNED TO ME ON JULY 23RD, FIXED OR SO I WAS TOLD WITH A NEW IGNITION TO FIX THE ISSUE. HOWEVER WITHIN A WEEK OF HAVING THE CAR BACK, IT WAS DOING THE SAME AS BEFORE THE RECALL FIX WAS DONE. SLIPPING INTO ACCESSIBILITY MODE AND NOT GIVING ME ANY OPTION TO HIT THE GAS, ONLY PULL OFF IF I WAS ABLE, TURN THE CAR OFF, THEN BACK ON AND GO. THIS HAPPENED A COUPLE OF TIMES WHEN I WAS GOING UPWARDS OF 40 MPH. THE LAST FEW TIMES THIS HAS HAPPENED WAS PULLING FROM MY STREET INTO A BUSY STREET WITH TRAFFIC GOING UPWARDS OF 55 MPH. I HAD TO PULL OFF AS QUICKLY AS I COULD ONTO THE SHOULDER AND TURN OFF THE CAR, BACK ON AGAIN AND GO MEANWHILE HOPING TO NOT BE HIT. I CONTACTED GM AGAIN AND WAS TOLD THAT MY RECALLED PART WAS FIXED AND THIS HAD TO BE ANOTHER ISSUE. HOWEVER, IT'S THE EXACT ISSUE THAT HAPPENED BEFORE MY CAR WAS FIXED. I'M 7 MONTHS PREGNANT AND OFTEN DRIVE WITH MY 16 MONTH OLD SON IN THIS CAR WITH ME. I DO NOT FEEL SAFE DRIVING IT AND CANNOT JUST GO PURCHASE A NEW CAR. I FEEL LIKE THIS NEEDS TO BE LOOKED INTO FURTHER TO FIND OUT IF THERE ARE MORE ISSUES AFTER THE INITIAL RECALL FIX. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM); HOWEVER, THE PARTS WERE UNAVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VIN WAS NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING VARIOUS SPEEDS, FUEL FUMES WERE EMITTED INTO THE VEHICLE. THE FAILURE OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING VARIOUS SPEEDS, FUEL FUMES WERE EMITTED INTO THE VEHICLE. THE FAILURE OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
POWER STEERING FAILURE SEEMS TO OCCUR AT RANDOM TIMES, AND BECOMING MORE FREQUENT. THERE IS A "POWER STEERING" DISPLAY ON DASHBOARD AND A WARNING CHIME. THEN THE SPEEDOMETER AND RPM'S GO BONKERS, THE CAR REPEATEDLY JUMPS FORWARD ABRUPTLY, AND THE POWER STEERING GOES OUT. SOMETIMES I CAN PARK, TURN THE CAR OFF AND BACK ON, AND TH…
Read full complaint
POWER STEERING FAILURE SEEMS TO OCCUR AT RANDOM TIMES, AND BECOMING MORE FREQUENT. THERE IS A "POWER STEERING" DISPLAY ON DASHBOARD AND A WARNING CHIME. THEN THE SPEEDOMETER AND RPM'S GO BONKERS, THE CAR REPEATEDLY JUMPS FORWARD ABRUPTLY, AND THE POWER STEERING GOES OUT. SOMETIMES I CAN PARK, TURN THE CAR OFF AND BACK ON, AND THE ISSUE GOES AWAY, AND SOMETIMES IT DOES NOT. THIS HAPPENED LAST YEAR, BUT THE POWER STEERING MOTOR RECALL (DONE IN JULY OF 2013) SEEMED TO FIX IT, BUT ONLY TEMPORARILY. IT IS IRRITATING AND SCARY TO HAVE TO DRIVE MY CAR LIKE THIS, AND I AM CONCERNED FOR MY SAFETY DURING THE UPCOMING WINTER MONTHS WHERE I WILL CERTAINLY BE DRIVING ON ICE AND SNOW. I HOPE THERE WILL BE ANOTHER RECALL TO PERMANENTLY SOLVE THIS ISSUE. THANK YOU. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.