NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
2,330 reports126,000 miles · Jun 14, 2021
Fuel System, GasolineStructure
The contact owns a 2006 Chevrolet Cobalt. The contact stated that after turning off the vehicle, there was an abnormal fuel odor coming from the vehicle. Upon inspection, the contact discovered severe corrosion on the rear driver’s side undercarriage of the vehicle. Due to the rust, the fuel lines started leaking. The local deal…
Read full complaint
The contact owns a 2006 Chevrolet Cobalt. The contact stated that after turning off the vehicle, there was an abnormal fuel odor coming from the vehicle. Upon inspection, the contact discovered severe corrosion on the rear driver’s side undercarriage of the vehicle. Due to the rust, the fuel lines started leaking. The local dealer was contacted and informed the contact that the Vin was not under recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 126,000.
NHTSA ODI #11420860
Mileage unknown · May 25, 2021
Fuel/propulsion System
There is a recall for some vin numbers on the 2006 Chevy cobalt (recall # 09V419000). My vin number was not included but the exact recalled part was also defective on my car. I wanted to let you know because there are probably several more vins that should be included in this recall, as my car is proof of that.
NHTSA ODI #11418550
Mileage unknown · Apr 23, 2021
Electrical SystemFuel/propulsion SystemSuspension
HAD TO CHANGE MY FUEL PUMP DUE TO A CRACK ON IT. MY KEY GETS STUCK IN THE IGNITION SWITCH IN ORDER TO TAKE IT OUT I HAVE TO PUSH A BUTTON UNDER THE STEERING WHEEL. I TO CHANGE MY STEERING SHAFT BECAUSE IT DOES A CLACKING NOISE.
NHTSA ODI #11413628
94,000 miles · Mar 26, 2021
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, HE STARTED TO SMELL A FUEL ODOR. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. A DEALER WAS NOT CONTACTED. …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, HE STARTED TO SMELL A FUEL ODOR. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.
NHTSA ODI #11405035
90,000 miles · Mar 16, 2021
Electrical SystemSteeringVehicle Speed Control
INSTRUMENT CLUSTER LIGHTS DO NOT WORK AND ELECTRIC POWER STEERING DOSE NOT WORK
NHTSA ODI #11403193
80,000 miles · Mar 13, 2021
Fuel/propulsion System
FUEL LINE LEAK BY LEFT REAR WHEEL WELL. HEAT SHIELD SEEMS TO CAPTURE MOISTURE AND HAS RUSTED LINE BY CLIP. RESULTS IN FUEL LEAK BY EXHAUST SYSTEM.
NHTSA ODI #11402795
120,000 miles · Feb 8, 2021
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT A SLOW SPEED IN A PARKING LOT, HE HEARD THE VEHICLE CHIME AS THE POWER STEERING WARNING MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE CONTACT THEN STATED THAT THE POWER STEERING BECAME FIRM. THE CONTACT STATED THAT THE VEHICLE STALLED WITH THE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT A SLOW SPEED IN A PARKING LOT, HE HEARD THE VEHICLE CHIME AS THE POWER STEERING WARNING MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE CONTACT THEN STATED THAT THE POWER STEERING BECAME FIRM. THE CONTACT STATED THAT THE VEHICLE STALLED WITH THE ACCELERATOR PEDAL DEPRESSED. THE CONTACT RESTARTED THE VEHICLE AND THE CHECK ENGINE WARNING LIGHT APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THERE WERE SEVERAL RECALLS ON THE VEHICLE. A VIN SEARCH SHOWED NO OPEN RECALLS ON THE VEHICLE. THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING). NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
NHTSA ODI #11395206
100,000 miles · Jan 28, 2021
Air BagsFuel/propulsion SystemSteering
WHILE DRIVING ON EXPRESSWAY, CAR WENT DEAD> HAD TO MAKE AN EMERGENCY STOP. POWER STEERING WENT OUT, BUT AFTER RESTARTING THE CAR IT WAS OK. IT KEEPS HAPPENING OFF AND ON- ON OCCASIONS. I KEPT SMELLING GAS, TOOK IT TO CAR REPAIR SHOP WAS TOLD I COULD NOT DRIVE THE VEHICLE, WAS TOLD THE GAS TANK HAD TO BE REPLACED OR WHATEVER THE …
Read full complaint
WHILE DRIVING ON EXPRESSWAY, CAR WENT DEAD> HAD TO MAKE AN EMERGENCY STOP. POWER STEERING WENT OUT, BUT AFTER RESTARTING THE CAR IT WAS OK. IT KEEPS HAPPENING OFF AND ON- ON OCCASIONS. I KEPT SMELLING GAS, TOOK IT TO CAR REPAIR SHOP WAS TOLD I COULD NOT DRIVE THE VEHICLE, WAS TOLD THE GAS TANK HAD TO BE REPLACED OR WHATEVER THE PART INSIDE THE GAS TANK. NOTE: WHEN THE POWER STEERING PROBLEM ARRIVED I WAS LEAVING GOING TO WORK. I STARTED THE CAR BUT THE STEERING WAS HARD TO TURN SO I PULLED BACK INTO PARKING SPACE AND TURNED OFF THE ENGINE. I RESTARTED AFTER A FEW MINUTES-WAS ABLE TO STEER OK. UPON SMELLING GAS THIS WENT ON FOR SERVAL DAYS. I THOUGHT IT WAS FUMES FROM OTHER CARS. I WOULD SMELL GAS WHILE DRIVING IT. ONE DAY AS I PULLED UP TO WORK I GOT OUT OF THE CAR AND NOTICED SOMETHING WET NEXT TO MY FRONT TIRE. I COULD SMELL GAS FUMES. I TOOK IT TO REPAIR SHOP THE NEXT DAY. SHOP TOLD ME THE CAR COULD HAVE CAUGHT ON FIRE.
NHTSA ODI #11390483
149,897 miles · Jan 24, 2021
Fuel/propulsion System
THE COMPANY WRAPPED A HEAT SHIELD FIBER AROUND A BARE METAL FUEL LINE CAUSING PREMATURE FAILURE OF THE LINE IN THAT SPECIFIC LOCATION DUE TO RUST FROM THE TRAPPED MOISTURE. THE FUEL LINE BURSTS CAUSING A STEADY FLOW OF GASOLINE TO POUR FROM BENEATH THE VEHICLE CAUSING AN EXTREMELY HAZARDOUS SITUATION. THE CAR CONTINUES TO FUNCT…
Read full complaint
THE COMPANY WRAPPED A HEAT SHIELD FIBER AROUND A BARE METAL FUEL LINE CAUSING PREMATURE FAILURE OF THE LINE IN THAT SPECIFIC LOCATION DUE TO RUST FROM THE TRAPPED MOISTURE. THE FUEL LINE BURSTS CAUSING A STEADY FLOW OF GASOLINE TO POUR FROM BENEATH THE VEHICLE CAUSING AN EXTREMELY HAZARDOUS SITUATION. THE CAR CONTINUES TO FUNCTION, LEAVING A TRAIL OF GASOLINE EVERYWHERE YOU GO. THE HEAT WRAP DOES NOT APPEAR TO AFFECT THE BRAKE LINE DUE TO IT'S BLACK COATING. THE FUEL LINES SHOULD ALSO BE PROTECTED IN THIS AREA.
NHTSA ODI #11389666
Mileage unknown · Dec 18, 2020
Electrical SystemEngineSteering
POWER STEERING WARNING CAME ON WHILE DRIVING ON THE HIGHWAY AN THE SPEEDOMETER STOP WORKING NOW THE CAR WON'T START I HAVE CHECKED FUSES AN RELAYS UNHOOKED BATTERY TO RESET COMPUTER NOTHING WORKS
NHTSA ODI #11384095
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration