NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
1,299 reportsClear category filter44,000 miles · Dec 9, 2010
Steering
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING FAILED AND THE WHEEL WAS DIFFICULT TO MANEUVER. THE CONTACT TURNED THE VEHICLE OFF AND RESTARTED IT TO RESET THE POWER STEERING. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS AP…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING FAILED AND THE WHEEL WAS DIFFICULT TO MANEUVER. THE CONTACT TURNED THE VEHICLE OFF AND RESTARTED IT TO RESET THE POWER STEERING. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 44,000.
NHTSA ODI #10369804
86,000 miles · Dec 6, 2010
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT STATED THAT THE POWER STEERING FAILED AND THE CONTACT HAD MINIMAL CONTROL OVER THE VEHICLE STEERING. NEITHER THE DEALER NOR THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT STATED THAT THE POWER STEERING FAILED AND THE CONTACT HAD MINIMAL CONTROL OVER THE VEHICLE STEERING. NEITHER THE DEALER NOR THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 86,000.
NHTSA ODI #10369343
46,000 miles · Nov 24, 2010
SteeringTraction Control System
I HAVE A 2006 CHEVY COBALT THAT IS HAVING POWER STEERING ISSUES. I THOUGHT THAT THE RECALL REPAIR WOULD FIX THE ISSUE AS I HAD IT REPAIRED A WEEK AGO. AFTER THE REPAIR THE POWER STEERING LIGHT CAME ON AND THE CAR BECAME HARD TO STEER. THE CAR WAS TAKEN BACK TO AN AUTHORIZED DEALER AND THEY CHARGED ME $43.00 TO DIAGNOSE THE PROBL…
Read full complaint
I HAVE A 2006 CHEVY COBALT THAT IS HAVING POWER STEERING ISSUES. I THOUGHT THAT THE RECALL REPAIR WOULD FIX THE ISSUE AS I HAD IT REPAIRED A WEEK AGO. AFTER THE REPAIR THE POWER STEERING LIGHT CAME ON AND THE CAR BECAME HARD TO STEER. THE CAR WAS TAKEN BACK TO AN AUTHORIZED DEALER AND THEY CHARGED ME $43.00 TO DIAGNOSE THE PROBLEM AND CAME UP WITH SEVERAL CODES IN THE COMPUTER BUT COULD NOT DUPLICATE THE ISSUE. THEY RESET THE COMPUTER AND IT HAPPENED AGAIN TODAY. NO POWER STEERING AND THE CAR STARTED SHUTTERING THE POWER STEERING LIGHT CAME ON AND THE TRACTION CONTROL LIGHT COMES ON. WHEN I TURNED THE CAR OFF AND RESTARTED IT I THEN HAD POWER STEERING BUT THE CHECK ENGINE LIGHT WAS STILL ON. THIS IS A VERY DANGEROUS SITUATION AND I DO NOT BELIEVE GM IS FIXING THE RIGHT PROBLEM. *TR
NHTSA ODI #10367824
80,681 miles · Nov 22, 2010
SteeringTraction Control System
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING 10 MPH INTO A PARKING SPACE, A CHIME SOUNDED AND THE POWER STEERING LIGHT ILLUMINATED ALONG WITH ENHANCED TRACTION SYSTEM WARNING INDICATORS. THERE WAS A LOSS OF POWER STEERING. THE CONTAC TURNED THE VEHICLE OFF. WHEN THE ENGINE WAS RESTARTED, THE VEHICL…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING 10 MPH INTO A PARKING SPACE, A CHIME SOUNDED AND THE POWER STEERING LIGHT ILLUMINATED ALONG WITH ENHANCED TRACTION SYSTEM WARNING INDICATORS. THERE WAS A LOSS OF POWER STEERING. THE CONTAC TURNED THE VEHICLE OFF. WHEN THE ENGINE WAS RESTARTED, THE VEHICLE OPERATED NORMALLY WITHOUT THE ILLUMINATION OF THE WARNING LIGHTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 10V073000 (STEERING: ELECTRIC POWER ASSIST SYSTEM). THE FAILURE CONTINUED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER THREE DIFFERENT TIMES FOR THE SAME FAILURE. THE ECM WAS REPLACED BUT THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS 80,681. UPDATED 1/21/11 *CN ALSO, THE TRACTION CONTROL LIGHT ILLUMIANTED. UPDATED 04/11/11
NHTSA ODI #10367089
64,325 miles · Nov 17, 2010
Steering
VEHICLE POWER STEERING FAILED AGAIN TWO WEEKS AFTER DEALER PERFORMED MANDATED RECALL WORK TO FIX POWER STEERING FAILURES WITH THIS MODEL OF VEHICLE. WITH MOST RECENT STEERING FAILURE, DEALER CLAIMS THEY CAN'T DUPLICATE THE PROBLEM AND THAT THEY DO NOT HAVE TO PERFORM ANY MORE WARRANTY WORK TO FIX THE POWER STEERING SINCE THEY S…
Read full complaint
VEHICLE POWER STEERING FAILED AGAIN TWO WEEKS AFTER DEALER PERFORMED MANDATED RECALL WORK TO FIX POWER STEERING FAILURES WITH THIS MODEL OF VEHICLE. WITH MOST RECENT STEERING FAILURE, DEALER CLAIMS THEY CAN'T DUPLICATE THE PROBLEM AND THAT THEY DO NOT HAVE TO PERFORM ANY MORE WARRANTY WORK TO FIX THE POWER STEERING SINCE THEY SAY THEY ALREADY DID THE REQUIRED RECALL WORK. WHAT LEAVES US WITH A VEHICLE THAT POTENTIALLY STILL SUFFERS FROM INTERMITTENT LOSE OF POWER ASSIST TO THE STEERING. *TR
NHTSA ODI #10366593
89,887 miles · Nov 4, 2010
Steering
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH, THE VEHICLE BEGAN TO SHAKE AND A LOSS OF POWER STEERING OCCURRED WITH THE ILLUMINATION OF THE POWER STEERING WARNING INDICATOR. THE SPEED ODOMETER ALSO BECAME INOPERABLE. IN ADDITION, THE ENGINE AND TRACTION CONTROL WARNING INDICATO…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH, THE VEHICLE BEGAN TO SHAKE AND A LOSS OF POWER STEERING OCCURRED WITH THE ILLUMINATION OF THE POWER STEERING WARNING INDICATOR. THE SPEED ODOMETER ALSO BECAME INOPERABLE. IN ADDITION, THE ENGINE AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED ON THE PREVIOUS DAY. THE CONTACT CONTINUED TO DRIVE WITH EXCESSIVE FORCE APPLIED TO THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY RECOMMENDED THAT THE VEHICLE BE TAKEN TO A DEALER. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 89,887.
NHTSA ODI #10363987
Mileage unknown · Oct 21, 2010
Steering
CHEVY 2006 COBALT POWER STEERING FAILED FOUR TIMES SINCE AUGUST 13TH POWER STEERING MOTOR REPLACED. *TR
NHTSA ODI #10361655
32,000 miles · Oct 21, 2010
Steering
MY DAUGHTER OWNS A 2006 CHEVY COBALT, (WHICH I PROVIDED MUCH OF THE $$ FOR) IT HAS APPROX 32K MILES. IT RECENTLY DEVELOPED AN ISSUE WITH A KNOCKING SOUND FROM UNDER THE DASHBOARD THAT CONTINUES FOR 10-15 SECONDS ALMOST EVERY TIME THE CAR IS STARTED. SHE TOOK THE CAR TO A LOCAL TRUSTED REPAIR SHOP, AND IT WAS DETERMINED TO BE…
Read full complaint
MY DAUGHTER OWNS A 2006 CHEVY COBALT, (WHICH I PROVIDED MUCH OF THE $$ FOR) IT HAS APPROX 32K MILES. IT RECENTLY DEVELOPED AN ISSUE WITH A KNOCKING SOUND FROM UNDER THE DASHBOARD THAT CONTINUES FOR 10-15 SECONDS ALMOST EVERY TIME THE CAR IS STARTED. SHE TOOK THE CAR TO A LOCAL TRUSTED REPAIR SHOP, AND IT WAS DETERMINED TO BE A POWER STEERING PROBLEM THAT THE MECHANIC FELT SHOULD /COULD BE A RECALL ITEM AND SUGGESTED THAT SHE TAKE IT TO THE DEALERSHIP; CHARGED $48. DEALERSHIP CHECKED OUT CAR FREE OF CHARGE (THAT IS SUSPICIOUS) FOR 2 HOURS, AND DETERMINED THAT IT WAS A PROBLEM WITH THE INTERMEDIATE STEERING SHAFT PART # 15800140. THEY REFERRED TO BULLETIN # 04-03-08-006D.THE APPROX COST TO REPAIR IT WOULD BE $1100, BUT IT WAS DEEMED SAFE TO DRIVE ALTHOUGH THE KNOCKING SOUND WOULD BE A NUISANCE. SOON AFTER I RESEARCHED THE INTERNET AND EASILY FOUND NUMEROUS COMPLAINTS, INJURIES, AND ACCIDENTS FROM COBALT STEERING PROBLEMS FOR 2005-2009 VEHICLES, YET IT WAS NOT A RECALL ITEM. I KNOW THAT MY DAUGHTER'S CURRENT ISSUE WILL ONLY GET MUCH WORSE AND THE VALUE OF THE CAR IS VERY DIMINISHED. THE ODDS OF SELLING IT ARE SLIM. PLEASE! MAKE CHEVROLET RECALL COBALT FOR THEIR STEERING DEFECTS A.S.A.P. WE WORK HARD AND CAN'T AFFORD TO REPAIR THIS VEHICLE. BUT, I WILL PAY TO HAVE IT REPAIRED TO SAVE MY DAUGHTER'S LIFE, WHAT CHOICE DO WE HAVE? *TR
NHTSA ODI #10361613
8,200 miles · Oct 14, 2010
Power TrainSteering
I HAVE A 06 CHEVY COBALT. SINCE OCTOBER 2007, THE POWER STEERING HAS BEEN GOING OUT AND THE TRANSMISSION HAS BEEN ACTING UP. AT THE BEGINNING, THE PROBLEM WOULD OCCUR ONLY ONCE IN A WHILE. NOW IT IS HAPPENING EVERYDAY. I'M CURRENTLY A NURSING STUDENT AND RELY ON MY CAR. THERE HAVE BEEN MANY TIMES WHEN MY CAR WOULD START ACT…
Read full complaint
I HAVE A 06 CHEVY COBALT. SINCE OCTOBER 2007, THE POWER STEERING HAS BEEN GOING OUT AND THE TRANSMISSION HAS BEEN ACTING UP. AT THE BEGINNING, THE PROBLEM WOULD OCCUR ONLY ONCE IN A WHILE. NOW IT IS HAPPENING EVERYDAY. I'M CURRENTLY A NURSING STUDENT AND RELY ON MY CAR. THERE HAVE BEEN MANY TIMES WHEN MY CAR WOULD START ACTING UP AND DURING DANGEROUS CONDITIONS SUCH AS THUNDERSTORMS OR JUST IN AN UNSAFE PART OF TOWN. I WAS HAPPY WHEN A POWER STEERING RECALL WAS ISSUED, BUT AFTER HAVING THE RECALLED FIXED, THE PROBLEM IS STILL OCCURRING! I'M A MICHIGAN NATIVE AND KNOW FIRST HAND THE IMPACT ON THE ECONOMY ON THE AMERICAN AUTO INDUSTRY. I WANTED TO SUPPORT THE LOCAL ECONOMY BY CHOOSING THIS CAR. NOW I DON'T THINK I WOULD EVER BUY A GM CAR AGAIN. SOMETHING MORE NEEDS TO BE DONE! THIS CAR IS NOT SAFE!!! *TR
NHTSA ODI #10360418
82,000 miles · Oct 12, 2010
Steering
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING 65 MPH, THE POWER STEERING FAILED WHEN THE CONTACT ATTEMPTED TO TURN LEFT TO EXIT THE HIGHWAY. SHE HAD TO USE ADDITIONAL FORCE TO COMPLETE THE TURN AND AVOID A CRASH. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WOULD NOT OFFER AS…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING 65 MPH, THE POWER STEERING FAILED WHEN THE CONTACT ATTEMPTED TO TURN LEFT TO EXIT THE HIGHWAY. SHE HAD TO USE ADDITIONAL FORCE TO COMPLETE THE TURN AND AVOID A CRASH. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WOULD NOT OFFER ASSISTANCE. THE CONTACT CALLED THE MANUFACTURER. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 86,000.
NHTSA ODI #10360112
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration