NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
1,299 reportsClear category filter50,000 miles · Mar 10, 2011
Steering
I AM REQUESTING THAT DOT NHTSA INVESTIGATE THE 2006 CHEVROLET COBALT INTERMEDIATE STEERING SHAFT (PART# 10394225) SAFETY PROBLEM. THIS PROBLEM OCCURS WHEN I AM ACCELERATING, DECELERATING, COASTING (NEUTRAL), AND BRAKING. WHEN I TURN THE STEERING WHEEL BACK AND FORTH IT MAKES A "CLUNKING" NOISE GIVING ME THE NOTION THAT THERE IS …
Read full complaint
I AM REQUESTING THAT DOT NHTSA INVESTIGATE THE 2006 CHEVROLET COBALT INTERMEDIATE STEERING SHAFT (PART# 10394225) SAFETY PROBLEM. THIS PROBLEM OCCURS WHEN I AM ACCELERATING, DECELERATING, COASTING (NEUTRAL), AND BRAKING. WHEN I TURN THE STEERING WHEEL BACK AND FORTH IT MAKES A "CLUNKING" NOISE GIVING ME THE NOTION THAT THERE IS INDEED SOMETHING IN THE STEERING FUNCTION THAT IS BROKEN. THERE HAVE BEEN NUMEROUS OCCASIONS UPON ACCELERATING WHERE THE STEERING WHEEL HAS OVERPOWERED MY GRIP ON THE STEERING WHEEL CAUSING MY CAR TO STEER VERY HARD TO THE LEFT ALMOST CAUSING COLLISION WITH OTHER CARS. THE LOSS OF CONTROL ON STEERING IS EVEN WORSE UPON LOW SPEED BRAKING; THE WHEELS HAVE IN THE PAST TURNED AT A 45 DEGREE ANGLE. AGAIN, THIS HAS ALMOST CAUSED A NUMBER OF COLLISIONS AT STOP LIGHTS WHERE THERE ARE 2 OR MORE LANES, OR THERE IS A TURNING LANE. IT IS ONLY A MATTER OF TIME BEFORE IRREPARABLE DAMAGE IS DONE. COBALTS HAVE BEEN KNOWN TO REPLACE THIS PART 2-3 TIMES OVER THE COURSE OF 5 YEARS IN OPERATION. SO FAR NO ACTION TO REPLACE THE PART HAS BEEN DONE ON MY PART. CURRENTLY THERE IS A TECHNICAL SERVICE BULLETIN FOR THE PROBLEM BUT THERE IS NO RECALL. THERE ARE SIGNIFICANT AMOUNTS OF TESTIMONIES AND EVIDENCE THAT THERE IS A SERIOUS SAFETY PROBLEM HERE AND I WISH YOU TO FORMALLY INVESTIGATE. THERE IS NO INCIDENT REPORT YET, DISREGARD INCIDENT DATE. *TR
NHTSA ODI #10389715
Mileage unknown · Mar 7, 2011
Electrical SystemSteering
TL* THE CONTACT OWNS 2006 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER RECEIVING REPAIRS UNDER NHTSA CAMPAIGN: 10V073000 (STEERING: ELECTRIC POWER ASSIST), THE VEHICLE BEGAN STALLING SPORADICALLY AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE DEALER ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY THE WIRING HARNESS …
Read full complaint
TL* THE CONTACT OWNS 2006 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER RECEIVING REPAIRS UNDER NHTSA CAMPAIGN: 10V073000 (STEERING: ELECTRIC POWER ASSIST), THE VEHICLE BEGAN STALLING SPORADICALLY AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE DEALER ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY THE WIRING HARNESS UNDER THE DASHBOARD WHICH HE DISCOVERED WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER TWICE YET THE DEALER WAS UNABLE TO PINPOINT THE FAILURE AND COULD ONLY SUGGEST THAT IT WAS THE WIRING HARNESS, WHICH WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 68,000. UPDATED 04/15/11*LJ THE CONSUMER STATED THE DEALER KEPT THE VEHICLE FOR A WEEK TO CORRECT THE PROBLEM. THE VEHICLE IS CURRENTLY OPERATING IN A NORMAL MANNER. UPDATED 11/04/11
NHTSA ODI #10386735
23,000 miles · Feb 17, 2011
Steering
OUR 2006 CHEVY COBALT HAS ISSUES WITH THE POWERSTEERING. IT MALFUNCTIONS OFTEN BUT WITH NO APPARENT TRIGGER. THE WARNING SYSTEM IS NOT RELIABLE BECAUSE IT DOESN'T ALWAYS GIVE WARNING OF THE FAILURE, AND SOMETIMES IT DINGS AND NO FAILURE OCCURS. WHEN MALFUNCTIONING THE STEERING IS EXTREMELY DIFFICULT TO USE. A GREAT AMOUNT OF…
Read full complaint
OUR 2006 CHEVY COBALT HAS ISSUES WITH THE POWERSTEERING. IT MALFUNCTIONS OFTEN BUT WITH NO APPARENT TRIGGER. THE WARNING SYSTEM IS NOT RELIABLE BECAUSE IT DOESN'T ALWAYS GIVE WARNING OF THE FAILURE, AND SOMETIMES IT DINGS AND NO FAILURE OCCURS. WHEN MALFUNCTIONING THE STEERING IS EXTREMELY DIFFICULT TO USE. A GREAT AMOUNT OF FORCE IS REQUIRED TO TURN THE STEERING WHEEL. THE PROBLEM MAY OCCUR AT ANY TIME AND AT ANY SPEED. THEN WHEN THE STEERING IS LOCKED IT OFTEN FREES UP SPONTANEOUSLY! THIS IS VERY DANGEROUS!!! THIS IS MY SECOND COMPLAINT. WE PURCHASED OUR 2006 CHEVY COBALT NEW AND AT ABOUT 23K MILES WE BEGAN TO HAVE PROBLEMS WITH THE POWER STEERING. THE POWER STEERING ASSIST MOTOR HAS BEEN REPLACED SEVERAL TIMES AND THE COLUMN WAS ALSO REPLACED. WE JUST HAD THE PSA MOTOR REPLACED THROUGH THE RECALL FOR THE SECOND TIME. OUR PARTICULAR CAR WAS NOT EVEN LISTED IN THE RECALL BUT THE DEALERSHIP DID THE REPAIRS BECAUSE OF OUR LONGTERM ISSUE. I BELIEVE THERE MUST BE SOME OTHER PART CAUSING THE PROBLEM (SPORADIC AND UNRELIABLE STEERING) BECAUSE THE PSA MOTOR HAS BEEN REPLACED SEVERAL TIMES BUT THE PROBLEM CONTINUES TO REOCCUR. NOW OUR CAR HAS HIGH MILEAGE AND GM IS UNWILLING TO "DO" ANYTHING TO MAKE THIS RIGHT. WE HAVE BEEN PAYING FOR THIS DEFECTIVE AND DANGEROUS CAR FOR 4 YEARS NOW AND THE PROBLEM HAS STILL NOT BEEN RESOLVED! I'M AFRAID THIS ISSUE WILL CAUSE SERIOUS INJURY OR DEATH, IT MUST BE FIXED! THIS DEFECTIVE PRODUCT IS A HAZARD TO ALL PEOPLE ON THE ROAD. THE 'NEW' PSA MOTOR DOES NOT WORK ANY BETTER THEN THE ORIGINAL PART. *TR
NHTSA ODI #10383029
49,800 miles · Feb 16, 2011
Steering
WHEN TURNING SHARP RIGHT IN MY 2006 CHEVY COBALT LS 4DR, THERE IS A LOUD, METAL RUBBING SOUND COMING FROM THE PASSENGER SIDE WHEEL WELL, AS IF STEERING IS HITTING SOMETHING UNDERNEATH. ONLY HAPPENS WHEN TURN IS SHARP, SUCH AS A U-TURN OR COMING OUT FROM AN ALLEY, DRIVEWAY, ETC. *TR
NHTSA ODI #10382897
93,245 miles · Feb 11, 2011
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT WAS DRIVING 60 MPH WHEN THE STEERING WHEEL EXHIBITED A BEEPING SOUND AND BECAME EXTREMELY STIFF AND HARD TO TURN. SHE THEN TURNED THE VEHICLE ON AND OFF REPEATEDLY AS THE STEERING WHEEL RESET TEMPORARILY BEFORE RECURRING WITHIN A FEW MINUTES. THE POWER STEERING WARNING LI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT WAS DRIVING 60 MPH WHEN THE STEERING WHEEL EXHIBITED A BEEPING SOUND AND BECAME EXTREMELY STIFF AND HARD TO TURN. SHE THEN TURNED THE VEHICLE ON AND OFF REPEATEDLY AS THE STEERING WHEEL RESET TEMPORARILY BEFORE RECURRING WITHIN A FEW MINUTES. THE POWER STEERING WARNING LIGHT WAS THEN ILLUMINATED AND THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED WHO ADVISED THE CONTACT THAT THEY WOULD RESEARCH THE FAILURE AND CONTACT HER WITH A DECISION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 93,245.
NHTSA ODI #10381615
65,000 miles · Feb 3, 2011
EquipmentSteering
STEERING: ELECTRIC POWER ASSIST SYSTEM - I HAVE A 2006 CHEVROLET COBALT. FOUR MONTHS AGO, I TOOK THE VEHICLE TO THE DEALERSHIP TO HAVE NHTSA RECALL CAMPAIGN NUMBER: PE10005 10V073000 COMPLETED. FOR THE LAST FOUR MONTHS THE VEHICLE PERFORMED AS IT HAD PRIOR TO EXPERIENCE THE POWER STEERING ISSUE THAT PROMPTED ME TO HAVE…
Read full complaint
STEERING: ELECTRIC POWER ASSIST SYSTEM - I HAVE A 2006 CHEVROLET COBALT. FOUR MONTHS AGO, I TOOK THE VEHICLE TO THE DEALERSHIP TO HAVE NHTSA RECALL CAMPAIGN NUMBER: PE10005 10V073000 COMPLETED. FOR THE LAST FOUR MONTHS THE VEHICLE PERFORMED AS IT HAD PRIOR TO EXPERIENCE THE POWER STEERING ISSUE THAT PROMPTED ME TO HAVE THE RECALL PERFORMED. FOR THE LAST WEEK, I HAVE EXPERIENCED INTERMITTENT POWER STEERING LOSS. EACH TIME, WHILE DRIVING THE POWER STEERING LOSS WARNING MESSAGE APPEARS AND I HAVE A OVERALL LOSS OF POWER STEERING, THE BRAKING SYSTEM IS COMPROMISED AS IT IS SLOW TO RESPOND AND THE VEHICLE (AN AUTOMATIC TRANSMISSION) SHAKES VIOLENTLY AS IF IT WAS TRYING TO SHIFT GEARS. THIS LOSS TYPICALLY SUBSIDES AT HIGHER SPEEDS. I BELIEVE THAT THE REPLACEMENT PART IS ALSO DEFECTIVE. THE POWER STEERING RETURNS IF THE VEHICLE IS STOPPED AND THE ENGINE IS TURNED OFF THEN BACK ON, HOWEVER AFTER LESS THAN 1/2 A MILE THE POWER STEERING LOSS WARNING MESSAGE APPEARS AGAIN AND THE ISSUES RETURN. *TR
NHTSA ODI #10380150
75,000 miles · Jan 10, 2011
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 10V073000 (STEERING: ELECTRIC POWER ASSIST SYSTEM) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. AFTER HAVING THE REPAIRS PERFORMED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY WHEN DRIVING AT VARIOUS SPEEDS. IN ADDITION, THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 10V073000 (STEERING: ELECTRIC POWER ASSIST SYSTEM) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. AFTER HAVING THE REPAIRS PERFORMED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY WHEN DRIVING AT VARIOUS SPEEDS. IN ADDITION, THE ENGINE WOULD EXHIBIT AND UNUSUALLY LOUD GRINDING NOISE. THE CHECK ENGINE LIGHT WAS ILLUMINATED AFTER THE VEHICLE BEGAN THE FAILURE. THE VEHICLE WAS INSPECTED BY THE DEALER YET HE WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
NHTSA ODI #10375429
64,400 miles · Jan 5, 2011
Steering
PROBLEMS WITH THE POWER STEERING..HAD THE[XXX] MOTO REPLACED AND NOW THEY TELLING ME I NEED 2000 WORTH OF WORK TO FIX THE ISSUE.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10374799
36,000 miles · Dec 28, 2010
Air BagsSteeringCrashInjury
I HAVE HAD A PROBLEM WITH MY 06 COBALT BACK IN EARLY 07 IT WAS UNDER WARRANTY AT THE 7 TIMES I TOOK IT TO THE DEALER FOR STEERING CONCERNS. THE DEALERSHIP COULD NOT DUPLICATE THE HARD STEERING PROBLEM OR PRODUCE COMPUTER PROBLEM. I WAS VERY ADAMANT ABOUT THIS AND ALSO GOT NEW TIRES THINKING THAT WAS THE PROBLEM. IT WAS NOT ! I …
Read full complaint
I HAVE HAD A PROBLEM WITH MY 06 COBALT BACK IN EARLY 07 IT WAS UNDER WARRANTY AT THE 7 TIMES I TOOK IT TO THE DEALER FOR STEERING CONCERNS. THE DEALERSHIP COULD NOT DUPLICATE THE HARD STEERING PROBLEM OR PRODUCE COMPUTER PROBLEM. I WAS VERY ADAMANT ABOUT THIS AND ALSO GOT NEW TIRES THINKING THAT WAS THE PROBLEM. IT WAS NOT ! I WAS NOT AWARE OF ANY SERIOUS PROBLEM WITH THE POWER STEERING, AND WAS LEARY TO DRIVE MY CAR (A GIFT FROM MY MOM) BUT HAD NOTHING ELSE TO DRIVE. IN MARCH OF THIS YEAR ON THE 30TH I WAS COMING FROM A FRIENDS HOME AND WAS ON A SIDE ROAD I SLOWED TO MAKE A RIGHT TURN AND I COULD NOT GET THE CAR TO GO RIGHT, IT WAS VERY HARD TO TURN, AND I WENT THROUGH THE LIGHT AND HIT A TREE HEAD ON AND THE AIR BAG DID NOT DEPLOY. I WAS TOLD LATER I MISSED THE SENSOR. THE CAR WAS TOTALED AND G.M. WON'T DO ANYTHING ABOUT THIS. I WAS TOLD THAT EVEN THOUGH THE CAR SAT FOR 2 MONTHS WITH A DEAD BATTERY THE COMPUTER DOES NOT LOOSE DATA. (G.M.) I KNOW OF SEVERAL COBALT OWNERS WHO HAVE HAD THE POWER ASSIST REPLACED ON MORE THAN ONE OCCASION AND IT STILL WENT OUT. THE MECHANICS (A.S.E.)CERTIFIED INFORMED ME IT IS NOT THE POWER ASSIST IT IS IN THE STEERING COLUMN, AND SHOULD BE REPLACED, BUT G.M. WON'T DO THAT IT WOULD COST TOO MUCH MONEY. IT IS NICE TO KNOW THAT G.M. WOULD RATHER SACRIFICE THE CONSUMER RATHER THAN TAKE CARE OF THEM. I ALSO UNDERSTAND THE COMPUTER HAS A HISTORY OF NOT RECORDING PROPERLY WHEN THERE IS A PROBLEM. THE REST OF US WHO HAVE HAD A CRASH WITH AND WITHOUT AIR BAGS NEED SOME KIND OF SOLUTION. G.M. IS SWEEPING THIS UNDER THE RUG!!!! THANK YOU FOR YOUR TIME. UPDATED PORTABLE 06/22/11
NHTSA ODI #10374139
93,057 miles · Dec 13, 2010
Steering
IN APRIL I RECEIVED A RECALL FOR THE CHEVY COBALT 2006, IT WAS FOR THE POWER STEERING ASSIST MOTOR, I WAITED NEARLY 7 MONTHS EVEN THOUGH I PLACED ORDER IN APRIL. I FINALLY GOT IT DONE AFTER THE POWER STEERING LIGHT WENT OFF IN DEC. AND CALLED THE DEALERSHIP WITH MY FRUSTRATION BECAUSE I NEVER RECEIVED A CALL THAT THE PART WAS IN…
Read full complaint
IN APRIL I RECEIVED A RECALL FOR THE CHEVY COBALT 2006, IT WAS FOR THE POWER STEERING ASSIST MOTOR, I WAITED NEARLY 7 MONTHS EVEN THOUGH I PLACED ORDER IN APRIL. I FINALLY GOT IT DONE AFTER THE POWER STEERING LIGHT WENT OFF IN DEC. AND CALLED THE DEALERSHIP WITH MY FRUSTRATION BECAUSE I NEVER RECEIVED A CALL THAT THE PART WAS IN. A WEEK LATER THE POWER STEERING LIGHT WENT OFF AGAIN, COME TO FIND OUT I NEED A NEW POWER STEERING COLUMN (THIS IS A 4 YEAR OLD CAR!!!), SO THE RECALL SHOULD NOT JUST BE THE MOTOR BUT THE STEERING COLUMN AS WELL, THIS IS VERY DANGEROUS, THE STEERING COMPLETELY GOES AND YOU CAN BARELY TURN THE STEERING WHEEL. THIS NEEDS TO BE LOOKED INTO ASAP BEFORE SOMEONE GETS HURT OR KILLED. *TR
NHTSA ODI #10370487
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration