IllustrationAFTER TWO HUB FAILURES, STABILIZER LINK FAILURES, IGNITION COIL FAILURE, REAR DEFROSTER FAILURE, POWER LOCKS FAILURE, AND NOW THE STEERING RACK IS MAKING A GRINDING NOISE AND CAUSING PREMATURE WEAR TO THE FRONT RIGHT TIRE. I BELIEVE THERE IS A TSB ON THE STEERING RACK. THIS SHOULD BE A RECALL I WON'T EVER BY A GM AGAIN. *TR
2006 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1540–25K
42125–50K
55750–75K
34575–100K
331100–150K
142150K+
1,950 reports with mileage · 380 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
164 crash reports14 fire reports81 injury reports
Steering complaints
1,299 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING SYSTEM MALFUNCTIONED CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR CONTACT THE MANUFACTURER. THE FAILURE MILEAGE WAS 1…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING SYSTEM MALFUNCTIONED CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR CONTACT THE MANUFACTURER. THE FAILURE MILEAGE WAS 100,281. UPDATED 1/4/13*CN
I PURCHASED A 2006 COBALT FROM A PRIVATE OWNER THIS WEEK. I TEST DROVE IT 3 TIMES WITH NO PROBLEMS. AFTER BRINGING IT HOME, I ATTEMPTED TO TURN OFF THE CAR AND REMOVE THE KEY. IT WOULD NOT TURN OFF ALL THE WAY AND THE KEY WOULD NOT COME OUT. I WAS VERY UPSET AND SCARED. THE CAR WOULD RESTART SO I WAS ABLE TO PUT IT IN THE DRIVEW…
Read full complaint
I PURCHASED A 2006 COBALT FROM A PRIVATE OWNER THIS WEEK. I TEST DROVE IT 3 TIMES WITH NO PROBLEMS. AFTER BRINGING IT HOME, I ATTEMPTED TO TURN OFF THE CAR AND REMOVE THE KEY. IT WOULD NOT TURN OFF ALL THE WAY AND THE KEY WOULD NOT COME OUT. I WAS VERY UPSET AND SCARED. THE CAR WOULD RESTART SO I WAS ABLE TO PUT IT IN THE DRIVEWAY AND PARK IT NEXT TO THE GARAGE. SINCE I COULD NOT REMOVE THE KEY I PUT A CAR CLUB ON IT AND LOCKED THE DOOR. THEN I PARKED ANOTHER CAR BEHIND IT. I DID NOT THINK ABOUT IT BUT SINCE THE KEY WAS IN THE ACCESSORY POSITION THE BATTERY WENT DEAD. THE NEXT DAY I WAS NOT ABLE TO REMOVE THE KEY AND I WAS NOT ABLE TO START IT. I CALLED A LOCAL CHEVROLET DEALER. HE CHECKED THE VIN FOR RECALLS AND SAID THERE WAS NOT ONE ON THE 2006 COBALT RELATED TO THE STARTING SOLENOID BINDING UP. HE DID TELL ME IT IS COMMON AND MOST CARS THAT HAVE THE PROBLEM HAVE A RECALL ISSUED. THIS PROBLEM HAS CAUSED ME MAJOR DISTRESS AND COULD BE VERY UNSAFE IF THE CAR HAD EXPERIENCED THIS PROBLEM SOMEWHERE AWAY FROM HOME. I FOUND OUT HOW TO FIX IT BY READING ARTICLES ON THE INTERNET. MANY PEOPLE HAVE REPORTED THIS PROBLEM AND CHEVROLET HAS NOT LISTENED TO THE CONSUMERS BY ISSUING A RECALL AND REPAIRING THE PROBLEM. THERE IS A BUTTON IN THE STEERING COLUMN THAT NEEDS TO BE PRESSED BY A ROD TO TELL THE CAR THAT THE CAR IS IN PARK AND IT IS OK TO TURN IT OFF AND REMOVE THE KEY. THE CARS WITH PROBLEMS HAVE A ROD THAT DOES NOT DEPRESS THE BUTTON. PEOPLE HAVE TO REMOVE A COVER ON THE STEERING COLUMN AND REATTACH THE ROD WHEN THEY CAN NOT REMOVE THEIR KEY. HOWEVER, OVER TIME THE ROD SLIPS TO FAR THAT THIS IS NO LONGER A SOLUTION AND THE PARTS NEED TO BE REPLACED. WHY SHOULD THE CONSUMER HAVE TO SUFFER THIS STRESS AND WORRY ABOUT GETTING THEIR CAR STOLEN BECAUSE THEIR KEY IS STUCK IN IT? CHEVROLET NEEDS TO IMMEDIATELY TAKE CARE OF THIS ONGOING, LONG STANDING ISSUE. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE STEERING WHEEL PULLED TO THE LEFT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE VEHICLE NEEDED AN ALIGNMENT. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE STEERING WHEEL PULLED TO THE LEFT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE VEHICLE NEEDED AN ALIGNMENT. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 166,000. THE VIN WAS UNAVAILABLE.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE REPAIRED UNDER NHTSA CAMPAIGN I.D. 10V073000 (STEERING), THE POWER STEERING SYSTEM MALFUNCTIONED WHILE DRIVING 25 MPH WITH THE ILLUMINATION OF THE POWER STEERING WARNING LIGHT. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER. THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE REPAIRED UNDER NHTSA CAMPAIGN I.D. 10V073000 (STEERING), THE POWER STEERING SYSTEM MALFUNCTIONED WHILE DRIVING 25 MPH WITH THE ILLUMINATION OF THE POWER STEERING WARNING LIGHT. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER. THE FAILURE MILEAGE WAS 55,100. .... UPDATED 10-17-13 *BF THE POWER STEERING LIGHT ILLUMINATED FOUR DAYS AFTER THE CHECK ENGINE LIGHT ILLUMINATED.
WHILE DRIVING AT HIGHWAY SPEEDS THE ELECTRIC POWER STEERING WENT OUT DISPLAYING A "POWER STEERING FAILURE" MESSAGE IN THE DASH AND A BEEPING ALARM OCCURRED. THE CAR CRASHED INTO A GUARDRAIL SINCE THE STEERING WAS UNRESPONSIVE. THIS HAPPENED AFTER THE INITIAL RECALL, SO THE SUPPOSED "GOOD" ELECTRIC MOTOR WAS ALREADY INSTALLE…
Read full complaint
WHILE DRIVING AT HIGHWAY SPEEDS THE ELECTRIC POWER STEERING WENT OUT DISPLAYING A "POWER STEERING FAILURE" MESSAGE IN THE DASH AND A BEEPING ALARM OCCURRED. THE CAR CRASHED INTO A GUARDRAIL SINCE THE STEERING WAS UNRESPONSIVE. THIS HAPPENED AFTER THE INITIAL RECALL, SO THE SUPPOSED "GOOD" ELECTRIC MOTOR WAS ALREADY INSTALLED, AND IT STILL FAILED. THIS CAR IS DANGEROUS, EVEN AFTER THE RECALL AND I AM LUCKY TO BE ALIVE. THE CAR IS NOW WRECKED AND I HAVE BODILY INJURIES. I HOPE GM WILL HELP ASSIST WITH THE SEVERAL THOUSAND DOLLAR REPAIR BILL DUE TO THEIR KNOWINGLY FAULTY DESIGN. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING) AND REPAIRED. THE FOLLOWING DAY THE FAILURE RECURRED. THE VEHICLE HAD NOT BEEN TAKEN BA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING) AND REPAIRED. THE FOLLOWING DAY THE FAILURE RECURRED. THE VEHICLE HAD NOT BEEN TAKEN BACK TO THE DEALER. THE FAILURE AND CURRENT MILEAGE WAS 116,425.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH ,THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO SLIGHTLY JERK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE WAS REPAIRED UNDER A RECALL RELATED TO THE NHTSA CAMPAIGN ID NUMBER…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH ,THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO SLIGHTLY JERK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE WAS REPAIRED UNDER A RECALL RELATED TO THE NHTSA CAMPAIGN ID NUMBER 10V073000 (10V073000). AFTER THE REMEDY REPAIR WAS PERFORMED THE FAILURE RECURRED. THE DEALER INFORMED THAT THE SECOND REPAIR WOULD BE AT THE OWNER'S EXPENSE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 116,368.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DECELERATING FROM 55 MPH, THE POWER STEERING WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE IGNITION SWITCH, ELECTRICAL COMPONENT, AXLE, AND SHIFT WAS REPAIRED. THE FAILURE RECURRED AND THE POWER STEERING WARNING …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DECELERATING FROM 55 MPH, THE POWER STEERING WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE IGNITION SWITCH, ELECTRICAL COMPONENT, AXLE, AND SHIFT WAS REPAIRED. THE FAILURE RECURRED AND THE POWER STEERING WARNING LAMP RE-ILLUMINATED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 148,000.
THE KEY GETS STUCK IN IGNITION AND WILL NOT COME OUT. THE KEY ACTS JAMMED AND WONT TURN AND CANT BE PULLED OUT. HAS BEEN DOING THIS FOR A WHILE AND HAS LEFT ME STRANDED MULTIPLE TIMES. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.