TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING 15 MPH AND MAKING A LEFT TURN, THE STEERING COLUMN FAILED. THE CONTACT'S VEHICLE ALMOST CRASHED INTO ANOTHER VEHICLE. THE VEHICLE WAS ABLE TO BE SAFELY MANEUVERED INTO A PARKING SPACE, BUT THE STEERING WAS VERY STIFF WHEN ATTEMPTING TO PARK. THE VEHICLE WAS TAKEN TO …
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING 15 MPH AND MAKING A LEFT TURN, THE STEERING COLUMN FAILED. THE CONTACT'S VEHICLE ALMOST CRASHED INTO ANOTHER VEHICLE. THE VEHICLE WAS ABLE TO BE SAFELY MANEUVERED INTO A PARKING SPACE, BUT THE STEERING WAS VERY STIFF WHEN ATTEMPTING TO PARK. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE POWER STEERING MOTOR FAILED. THE COST TO REPAIR THE VEHICLE WOULD BE $600. NO REPAIRS HAVE BEEN MADE. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE CURRENT AND FAILURE MILEAGES WERE 50,000.
NHTSA ODI #10252557
47,500 miles · Dec 22, 2008
Steering
I OWN A 2006 CHEVROLET COBALT LS. WHEN I PURCHASED IT IN JANUARY 2008 IT HAD APPROXIMATELY 62,000 KMS. IN THE LAST YEAR I HAVE DRIVEN IT FOR APPROX. 9000 KM. IN JULY 2008 I HAD MY FIRST PROBLEM WITH THE POWER STEERING. I WAS DRIVING OUT OF MY DRIVEWAY AND THE POWER STEERING LIGHT CAME ON. THE CAR IMMEDIATELY STOPPED WORKING AFTE…
Read full complaint
I OWN A 2006 CHEVROLET COBALT LS. WHEN I PURCHASED IT IN JANUARY 2008 IT HAD APPROXIMATELY 62,000 KMS. IN THE LAST YEAR I HAVE DRIVEN IT FOR APPROX. 9000 KM. IN JULY 2008 I HAD MY FIRST PROBLEM WITH THE POWER STEERING. I WAS DRIVING OUT OF MY DRIVEWAY AND THE POWER STEERING LIGHT CAME ON. THE CAR IMMEDIATELY STOPPED WORKING AFTER SHAKING FOR 2-3 SECONDS. I RE-STARTED THE ENGINE AND THE CAR MOVED BUT THE BRAKES WERE SHAKY AND IT SEEMED AS IF I WAS OUT OF GEAR. I TOOK THE CAR TO THE DEALER 2-3 DAYS LATER AND THEY REPLACED MY WHOLE STEERING COLUMN WITH A COST OF CLOSE TO $1000 AT THE TIME AS MY CAR WAS OUT OF WARRANTY. THE PROBLEM WENT AWAY FOR A FEW MONTHS BUT UNFORTUNATELY LAST NIGHT IT BEGAN AGAIN (DECEMBER 21). THE POWER STEERING LIGHT CAME ON AND THE VEHICLE STARTED SHAKING WHILE I WAS DRIVING AT 40 KM/H. I DID NOT LOSE CONTROL BUT IT MADE MY DRIVE REALLY DIFFICULT AS I WAS DRIVING ON ICY ROADS. SAME AS IN THE SUMMER THE BRAKES WERE SHAKY AND THE ENGINE WAS OUT OF GEAR AND ACCELERATING WAS HARD TO CONTROL. AFTER STOPPING AT A GAS STATION AND RE-STARTING THE ENGINE THE CAR WORKED FINE. I AM TAKING THE CAR TO THE DEALERSHIP AGAIN, BUT I CANNOT BELIEVE HOW GM DOES NOT RECALL THIS CAR AS HUNDREDS OF PEOPLE REPORT THE SAME PROBLEM. IT'S REALLY DANGEROUS TO HAVE THE POWER STEERING GO OFF RANDOMLY. AND I DON'T EVEN KNOW WHAT THIS IS GOING TO COST NOW.. I HAVE SPENT OVER $1500 IN REPAIRS FOR THIS FAULTY CAR JUST IN THE LAST 6 MONTHS! *TR
NHTSA ODI #10252530
3,040 miles · Dec 22, 2008
Engine And Engine CoolingService Brakes, HydraulicSteeringCrash
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE HAD ISSUES WITH THE ENGINE SURGING. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THERE WAS A DIRTY INJECTOR, IN WHICH THEY REPLACED. IN JANUARY OF 2007, THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPROGRAMMED THE COMPUTER FOR THE SUR…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE HAD ISSUES WITH THE ENGINE SURGING. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THERE WAS A DIRTY INJECTOR, IN WHICH THEY REPLACED. IN JANUARY OF 2007, THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPROGRAMMED THE COMPUTER FOR THE SURGING ISSUE. IN MARCH OF 2008, THE VEHICLE WAS RETURNED TO THE DEALER FOR A RECALL ON THE INJECTORS. IN ADDITION TO THE SURGING, THE VEHICLE WOULD ALSO SHAKE VIOLENTLY WHEN COMING TO A STOP. THE BRAKES AND STEERING WOULD NOT FUNCTION CORRECTLY. THE VEHICLE WAS TAKEN TO THE DEALER IN OCTOBER OF 2008 AND THE POWERTRAIN CONTROL MODULE WAS REPLACED. IN NOVEMBER OF 2008, THE CONTACT TOOK THE VEHICLE TO THE DEALER AGAIN IN REGARDS TO THE VIOLENT SHAKING. THE DEALER COULD NOT DUPLICATE THE FAILURE AND ADVISED THE CONTACT TO CALL A TOW TRUCK IN THE EVENT OF A CRASH BECAUSE THEY COULD NOT ASSIST. IN NOVEMBER OF 2008, THE VEHICLE BEGAN SHAKING VIOLENTLY AND CRASHED INTO THE PRECEDING VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO ANOTHER DEALER, BUT THEY COULD NOT DUPLICATE THE FAILURE AS WELL. A COMPLAINT WAS FILED WITH THE MANUFACTURER AND THE CONTACT IS AWAITING THEIR RESPONSE. SHE WAS ADVISED TO NOT OPERATE THE VEHICLE. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 17,250 AND FAILURE MILEAGE WAS APPROXIMATELY 3,040.
NHTSA ODI #10252523
Mileage unknown · Dec 16, 2008
Steering
WE PURCHASED THIS CAR FOR OUR TEENAGE DAUGHTER BASED ON THE REPUTATION OF CHEVROLET. DRIVING DOWN THE ROAD THE POWERSTEERING GOES OUT WITHOUT WARNING. IT CAN BE RESTARTED WHICH WILL RESET THE POWERSTEERING FOR A SHORT PERIOD OF TIME HOWEVER, THIS IS UNSAFE. IN MID TURN OR MANEUVER THIS IS LIKELY TO HAPPEN WHICH IS LIKELY TO C…
Read full complaint
WE PURCHASED THIS CAR FOR OUR TEENAGE DAUGHTER BASED ON THE REPUTATION OF CHEVROLET. DRIVING DOWN THE ROAD THE POWERSTEERING GOES OUT WITHOUT WARNING. IT CAN BE RESTARTED WHICH WILL RESET THE POWERSTEERING FOR A SHORT PERIOD OF TIME HOWEVER, THIS IS UNSAFE. IN MID TURN OR MANEUVER THIS IS LIKELY TO HAPPEN WHICH IS LIKELY TO CAUSE A CRASH. I HAVE RESEARCHED AND IT DOES NOT SEEM TO BE A RANDOM ISSUE BUT MANY PEOPLE WITH THIS SAME MODEL OF CAR ARE HAVING THIS SAME ISSUE. CHEVROLET NEEDS TO TAKE CARE OF THIS PROBLEM! *TR
NHTSA ODI #10251958
49,625 miles · Dec 2, 2008
Steering
I HAVE A 2006 CHEVY COBALT. THE POWER STEERING WILL GO OUT WHILE DRIVING DOWN THE ROAD. I CAN RESTART MY CAR AND IT WILL WORK AGAIN FOR A PERIOD OF TIME. THE CAR IS PAST ITS WARRANTY STAGE AND HAS 49625 MILES ON IT. I BOUGHT THE CAR FROM A CHEVY DEALERSHIP WITH 7000 MILES ON IT. THIS IS DEFINITELY A SAFETY ISSUE AS WHO KNOWS…
Read full complaint
I HAVE A 2006 CHEVY COBALT. THE POWER STEERING WILL GO OUT WHILE DRIVING DOWN THE ROAD. I CAN RESTART MY CAR AND IT WILL WORK AGAIN FOR A PERIOD OF TIME. THE CAR IS PAST ITS WARRANTY STAGE AND HAS 49625 MILES ON IT. I BOUGHT THE CAR FROM A CHEVY DEALERSHIP WITH 7000 MILES ON IT. THIS IS DEFINITELY A SAFETY ISSUE AS WHO KNOWS WHAT MAY HAPPEN IF THE POWER STEERING GOES OUT WHILE CHANGING LANES OR MAKING A RAPID TURN. I HAVE RESEARCHED ON THE INTERNET AND FOUND ALOT OF PEOPLE HAVING THE SAME THING HAPPEN AS WELL TO THE COBALT THEY HAVE. SURELY THIS HAS TO BE A MALFUNCTION WITHIN THE CAR AND I BELIEVE SHOULD BE ADDRESSED AND FIXED. I CONTACTED THE DEALERSHIP AND CHEVORLET ASSISTANTS AND I WAS INFORMED TO TAKE THE CAR IN TO HAVE THE PROBLEM DIAGNOSED, WHICH I AM SCHEDULED TO DO SO; HOWEVER THIS IS COSTING ME MONEY. I REALIZE THAT CAR BREAK DOWN AND SOMETIMES THERE ARE COSTS INVOLVED BUT I DO NOT THINK THIS IS JUST A PROBLEM THAT ONE INDIVIDUAL CAR IS HAVING; THIS IS AN RECURRING PROBLEM THAT IS HAPPENING IN COBALTS WITH THE ELECTRICALLY STEERING EPS. IT IS NOT SAFE, IT SHOULD NOT BE HAPPENING IN A NEWER MODEL OF CAR. WHAT HAPPENED TO THE INTEGRITY OF CHEVORLETS? PLEASE ADVISE OR HELP IN THIS MATTER BEFORE SOMEONE DOES HAVE A FATAL ACCIDENT OR DIE BEHIND THIS PROBLEM. *TR
NHTSA ODI #10250529
37,000 miles · Nov 17, 2008
Steering
POWER STEERING (ELECTRIC) HAS GONE OUT ON CAR ALONG WITH 20,000 OTHER PEOPLES CHEVY NEEDS TO FIX MY CAR AND THIS PROBLEM. *TR
NHTSA ODI #10248995
56,000 miles · Oct 24, 2008
Steering
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING 30 MPH, THE ELECTRIC POWER STEERING INDICATOR WAS FLASHING, WHICH INDICATED THAT THE POWER STEERING WAS NOT WORKING. THE FAILURE MADE STEERING DIFFICULT. THE LACK OF POWER STEERING ALMOST CAUSED NUMEROUS CRASHES. THE CURRENT MILEAGE WAS 60,440 AND FAILURE MILEAGE WAS…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING 30 MPH, THE ELECTRIC POWER STEERING INDICATOR WAS FLASHING, WHICH INDICATED THAT THE POWER STEERING WAS NOT WORKING. THE FAILURE MADE STEERING DIFFICULT. THE LACK OF POWER STEERING ALMOST CAUSED NUMEROUS CRASHES. THE CURRENT MILEAGE WAS 60,440 AND FAILURE MILEAGE WAS 56,000.
NHTSA ODI #10246653
48,000 miles · Oct 3, 2008
EquipmentSteering
I WAS DRIVING ON A STRAIGHT ROAD WHEN ALL THE SUDDEN ON MY 06 COBALT THE POWER STEERING WENT OUT AND THE DASHBOARD SAYS POWER STEERING. IT WOULD NOT WORK AND HAD TO MANUALLY TURN IT. THIS IS A DANGER FOR MANY REASONS. THERE IS OVER 5000 COMPLAINTS ON THE INTERNET AND THIS NEEDS TO BE TAKEN SERIOUSLY!! *TR
NHTSA ODI #10244296
52,225 miles · Sep 30, 2008
Steering
I WAS DRIVING MY 2006 CHEVY COBALT WHEN THE POWER STEERING WENT OUT AND I RECEIVED A POWER STEERING ERROR MESSAGE. I TOOK IT TO A GM CERTIFIED DEALER TO BE DIAGNOSED AND MY STEERING COLUMN CONTROL MOTOR HAD SHORTED OUT CAUSING ME TO LOSE MY POWER STEERING. THIS PART BEING AN ELECTRIC MOTOR IS NOT COVERED UNDER WARRANTY AND THE…
Read full complaint
I WAS DRIVING MY 2006 CHEVY COBALT WHEN THE POWER STEERING WENT OUT AND I RECEIVED A POWER STEERING ERROR MESSAGE. I TOOK IT TO A GM CERTIFIED DEALER TO BE DIAGNOSED AND MY STEERING COLUMN CONTROL MOTOR HAD SHORTED OUT CAUSING ME TO LOSE MY POWER STEERING. THIS PART BEING AN ELECTRIC MOTOR IS NOT COVERED UNDER WARRANTY AND THE ELECTRIC CIRCUIT FAILED UNDER ITS OWN ACCORD. MY POWER STEERING HAS NOT SHOW ANY OTHER PROBLEMS BEFORE THIS INCIDENT AND REGULAR MAINTENANCE HAS BEEN PERFORMED. I WAS ABLE TO GET STOPPED SAFELY BUT THE LOSS OF MY POWER STEERING AT A HIGH SPEED COULD HAVE RESULTED IN A SEVERE ACCIDENT OR HARM TO OTHERS. THE ENTIRE MOTOR MUST BE REPLACED FOR A COST OF $850 FOR THIS SHORT NOT TO OCCUR AGAIN. *TR
NHTSA ODI #10244056
37,000 miles · Sep 29, 2008
Steering
IN MY SONS 2006 CHEVY COBALT, AT ANY GIVING TIME THE POWER STEERING LIGHT COMES ON THE DASH AND HE LOSES STEERING ON THE VEHICLE, ONCE YOU CYCLE THE IGNITION IT WORKS FOR A LITTLE WHILE THEN HAPPENS AGAIN. I HAVE READ SEVERAL COMPLAINTS ABOUT THIS AND IT'S COSTLY TO REPAIR OVER $2000.00. I KNOW GM KNOWS ABOUT THIS SO WHY AREN'T …
Read full complaint
IN MY SONS 2006 CHEVY COBALT, AT ANY GIVING TIME THE POWER STEERING LIGHT COMES ON THE DASH AND HE LOSES STEERING ON THE VEHICLE, ONCE YOU CYCLE THE IGNITION IT WORKS FOR A LITTLE WHILE THEN HAPPENS AGAIN. I HAVE READ SEVERAL COMPLAINTS ABOUT THIS AND IT'S COSTLY TO REPAIR OVER $2000.00. I KNOW GM KNOWS ABOUT THIS SO WHY AREN'T THEY DOING SOMETHING ABOUT THIS MECHANICAL ISSUE THAT IS GOING TO KILL SOMEONE!! I BELIEVE A RECALL SHOULD BE DONE BECAUSE OF THE UNSAFE ISSUE WHILE DRIVING OR TURNING A VEHICLE AND LOSE CONTROL. THIS PROBLEMS HAPPENS AT LEAST 3-4 TIMES A DAY AND SON JUST DOESN'T HAVE THE MONEY TO REPAIR. HE JUST JOINED THE ARMY IN SEPT. 4, 2008 AND IS GOING TO NEED HIS CAR IN VA. FOR HIS TRAINING. COULD YOU PLEASE PROVIDE A PUSH TO GM ON THIS ISSUE.. PLEASE!! THANK YOU.. *TR
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
Illustration