← New search

2006 Chevrolet Cobalt

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

1,950 reports with mileage · 380 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

164 crash reports14 fire reports81 injury reports

Latches/locks/linkages complaints

38 reports
Clear category filter
77,093 miles · Oct 20, 2012
Latches/locks/linkagesStructure

I ARRIVED AT WORK YESTERDAY ONLY TO FIND I COULDN'T EXIT MY CAR THROUGH THE DRIVER'S DOOR. I MANUALLY TRIED UNLOCKING IT, BUT IT STILL DID NOT OPEN. I PROCEEDED TO CLIMB OUT OF THE PASSENGER SEAT. THAT DOOR WOULD NOT CLOSE ALL THE WAY. I THOUGHT THE SEAT BELT WAS STUCK IN THE DOOR. IT TURNS OUT THE LATCH DIDN'T ALLOW ENOUGH SPAC…

Read full complaint

I ARRIVED AT WORK YESTERDAY ONLY TO FIND I COULDN'T EXIT MY CAR THROUGH THE DRIVER'S DOOR. I MANUALLY TRIED UNLOCKING IT, BUT IT STILL DID NOT OPEN. I PROCEEDED TO CLIMB OUT OF THE PASSENGER SEAT. THAT DOOR WOULD NOT CLOSE ALL THE WAY. I THOUGHT THE SEAT BELT WAS STUCK IN THE DOOR. IT TURNS OUT THE LATCH DIDN'T ALLOW ENOUGH SPACE TO CATCH THE DOOR. AFTER 5 MINUTES OF PUSHING THE LATCH AND TRYING TO GET THE DOOR CLOSED, IT FINALLY WAS ABLE TO CLOSE. I JUST PURCHASED THIS CAR (USED) 2 WEEKS AGO. MY FIRST CAR!! I WISH I HAD BOUGHT A HONDA! TODAY I WAS GOING TO RUN ERRANDS ON MY DAY OFF. THIS TIME THE PASSENGER DOOR WOULDN'T LATCH. I HAVE NO WAY OF SECURING THE DOOR CLOSED SINCE IT IS A 2 DOOR VEHICLE. THE CAR IS SITTING IN MY PARKING LOT, UNABLE TO BE DRIVEN DUE TO THE SAFETY FEATURE (OR LACK THERE OF!) OF THE PASSENGER DOOR POTENTIALLY FLYING OPEN ON ME WHILE I'M DRIVING. HAVE SEEN MANY COMPLAINTS ON THIS VEHICLE. LOOKS/RIDES NICE BUT NOT WORTH THE MONEY OR HEADACHE. STILL HAVEN'T DISCOVERED A RECALL REGARDING THIS ISSUE. MIGHT BE TRADING THIS IN ON A NEW CAR, DIFFERENT MODEL/MAKE! *TR

NHTSA ODI #10481247

65,000 miles · Jun 29, 2012
Latches/locks/linkages

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT ALL FOUR DOORS HAD BECOME INOPERABLE. THE LATCHES WERE NOT SECURE ENOUGH TO KEEP THE DOORS CLOSED AND THEY WOULD OPEN WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT EACH DOOR WOULD COST $185 AT THE EXPENSE OF THE CONTACT. THE VEHICLE WAS NO…

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT ALL FOUR DOORS HAD BECOME INOPERABLE. THE LATCHES WERE NOT SECURE ENOUGH TO KEEP THE DOORS CLOSED AND THEY WOULD OPEN WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT EACH DOOR WOULD COST $185 AT THE EXPENSE OF THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND A COMPLAINT WAS FILED. THEY OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 65,000. UPDATED 8/6/12 *CN THE CONSUMER STATED THE VEHICLE WAS TAKEN TO A SECOND DEALER AND WAS INFORMED THE VEHICLE COULD NOT BE DIAGNOSED BECAUSE IT WAS NOT ELECTRIC. THE CONSUMER'S CONCERNED IF THE VEHICLE WAS REPAIRED IF IT WOULD FAIL AGAIN IN A FEW YEARS. UPDATED 08/14/2012 *JS

NHTSA ODI #10463519

60,000 miles · May 1, 2012
Electrical SystemLatches/locks/linkages

I HAVE A 2006 COBALT. PERIODICALLY I CAN'T OPEN THE DRIVER DOOR FROM INSIDE AND I HAVE TO ROLL DOWN THE WINDOW TO PULL HANDLE FROM OUTSIDE TO GET OUT. AND THEN FUSS WITH THE LATCH MECHANISM SOMETIMES TO GET THE DOOR TO SHUT. AND RIGHT NOW MY LOCKS ARE GOING UP AND DOWN BY THEMSELVES WHILE I DRIVE AND WHEN I'M PARKED.. I LOCK MY…

Read full complaint

I HAVE A 2006 COBALT. PERIODICALLY I CAN'T OPEN THE DRIVER DOOR FROM INSIDE AND I HAVE TO ROLL DOWN THE WINDOW TO PULL HANDLE FROM OUTSIDE TO GET OUT. AND THEN FUSS WITH THE LATCH MECHANISM SOMETIMES TO GET THE DOOR TO SHUT. AND RIGHT NOW MY LOCKS ARE GOING UP AND DOWN BY THEMSELVES WHILE I DRIVE AND WHEN I'M PARKED.. I LOCK MY DOORS AND I COME OUT TO MY CAR AND THEY ARE UNLOCKED. AND I CAN'T DISENGAGE MY ALARM...SOO EVERY TIME I OPEN THE DOOR I HAVE TO JUMP IN AND TURN ON THE IGNITION. I CALLED THE LOCAL CHEVY DEALER AND OF COURSE THEY HAVEN'T HEARD ANY COMPLAINTS LIKE THIS. ALTHOUGH, I'VE READ MANY COMPLAINTS LIKE THIS.. THEY TELL ME IF I WANT TO BRING IT IN, I HAVE TO PAY FOR THEM TO DIAGNOSE IT! I'M STILL MAKING PAYMENTS ON THIS CAR! *JS

NHTSA ODI #10456993

Mileage unknown · Jan 19, 2012
Latches/locks/linkages

MY 2006 CHEVROLET COBALT LT HAS STARTED HAVING PROBLEMS WITH THE DRIVER DOOR SINCE 2 DAYS AGO. I HAD ARRIVED AT MY DESTINATION AND WENT TO OPEN MY DRIVER DOOR TO EXIT AND I COULDN'T. THE DRIVER DOOR WOULD NOT OPEN AT ALL. I TRIED LOCKING AND UNLOCKING THE DOOR TO SEE IF IT WOULD OPEN AND NOTHING CHANGED. I WAS LOCKED IN MY CAR F…

Read full complaint

MY 2006 CHEVROLET COBALT LT HAS STARTED HAVING PROBLEMS WITH THE DRIVER DOOR SINCE 2 DAYS AGO. I HAD ARRIVED AT MY DESTINATION AND WENT TO OPEN MY DRIVER DOOR TO EXIT AND I COULDN'T. THE DRIVER DOOR WOULD NOT OPEN AT ALL. I TRIED LOCKING AND UNLOCKING THE DOOR TO SEE IF IT WOULD OPEN AND NOTHING CHANGED. I WAS LOCKED IN MY CAR FOR TEN MINUETS TRYING TO GET OUT UNTIL I FINALLY HAD TO CRAWL OUT THE PASSENGER SIDE OF THE CAR. WHEN TRYING TO GET BACK INTO THE CAR, THE SAME THING WAS HAPPENING TO WHERE I COULDN'T GET IN AND HAD TO ENTER FROM THE PASSENGER SIDE OF THE CAR. RIGHT NOW MY DOOR IS WORKING NORMAL BUT AN HOUR AGO I COULDN'T GET IN AGAIN. THIS IS A HUGE SAFETY RISK BECAUSE IF SOMEONE NEEDS TO EXIT THEIR CAR QUICKLY AND THIS IS HAPPENING, THERE IS NOTHING THAT THEY CAN DO TO GET OUT. I AM NOT THE ONLY COBALT OWNER WITH THIS ISSUE AND HAVE READ MANY COMPLAINTS OF THIS ISSUE ONLINE. THIS ISSUE NEEDS RESOLVED BEFORE ANYONE GETS HURT FROM BEING TRAPPED INSIDE THE CAR WITHOUT A WAY TO ESCAPE. *TT

NHTSA ODI #10444539

40,000 miles · Dec 19, 2011
Electrical SystemLatches/locks/linkagesSuspension

MY 2006 CHEVY COBALT HAD WHEEL BEARING ISSUES STARTING AT 40,000 MILES. AT 50,000 MILES MY FRONT END SUSPENSION (LOWER CONTROL ARM AND BUSHINGS), STRUTS, AND DOORS LOCKS STARTED ACTING UP. MY DOOR LOCKS WILL JAM AND I WILL BE TRAPPED IN MY CAR UNTIL THEY (DOOR LOCKS) DECIDE TO WORK AGAIN. FORTUNATELY FOR ME USUALLY ONLY ONE STOP…

Read full complaint

MY 2006 CHEVY COBALT HAD WHEEL BEARING ISSUES STARTING AT 40,000 MILES. AT 50,000 MILES MY FRONT END SUSPENSION (LOWER CONTROL ARM AND BUSHINGS), STRUTS, AND DOORS LOCKS STARTED ACTING UP. MY DOOR LOCKS WILL JAM AND I WILL BE TRAPPED IN MY CAR UNTIL THEY (DOOR LOCKS) DECIDE TO WORK AGAIN. FORTUNATELY FOR ME USUALLY ONLY ONE STOPS WORKING AT A TIME. THE DEALER SAYS THAT IT JUST NEEDS GREASING; I HAVE TRIED EVERY GREASE UNDER THE SUN AND NONE HAS FIXED THE PROBLEM. THIS IS A SERIOUS SAFETY ISSUE AND THIS CAR SHOULD HAVE A RECALL TO AT LEAST FIX THE DOORS!!!.THE DEALER WANTS TO CHARGE OVER $1,000 PER DOOR FOR REPAIRS. I HAVE HEARD OF SOME PEOPLES DOORS NEVER OPENING AGAIN AND THE DOOR HAVING TO BE CUT OFF TO BE REPAIRED. IF SOMETHING WERE TO HAPPEN YOU NEED TO BE ABLE TO QUICKLY AND SAFELY GET OUT OF THE CAR. PLEASE PLEASE PLEASE RECALL THIS DOOR ISSUE ON THE COBALT! *TR

NHTSA ODI #10440418

128,000 miles · Dec 8, 2011
Latches/locks/linkages

IT DRIVER SIDE DOOR LATCH BEGAN MALFUNCTIONING AND EITHER WOULD NOT LET MY DOOR SHUT OR ONCE IT WAS SHUT IT WOULD NOT LET ME OUT. THE LOCKS STILL WORK BUT THE DOOR CONTINUOUSLY GETS STUCK SHUT OR WON'T SHUT AT ALL. *TR

NHTSA ODI #10439023

120,000 miles · Oct 19, 2011
Electrical SystemLatches/locks/linkages

I NOTICED ISSUES STARTING SHORTLY AFTER WE BOUGHT THE VEHICLE IN 08 WITH THE DOOR LOCKS ERRATICALLY LOCKING AND UNLOCKING THEMSELVES. MY HUSBAND FIXED THE ISSUE BY DISCONNECTING THE ELECTRIC LOCKS. THEN IN JANUARY OF 2011 THE CAR COMPLETELY STALLED WHILE TURNING. WE STARTED IT UP AND GOT IT HOME. WE WENT THROUGH ALL KINDS OF THI…

Read full complaint

I NOTICED ISSUES STARTING SHORTLY AFTER WE BOUGHT THE VEHICLE IN 08 WITH THE DOOR LOCKS ERRATICALLY LOCKING AND UNLOCKING THEMSELVES. MY HUSBAND FIXED THE ISSUE BY DISCONNECTING THE ELECTRIC LOCKS. THEN IN JANUARY OF 2011 THE CAR COMPLETELY STALLED WHILE TURNING. WE STARTED IT UP AND GOT IT HOME. WE WENT THROUGH ALL KINDS OF THINGS FIGURING OUT WHAT WAS WRONG. WE CHANGED THE CATALYTIC CONVERTER, SPARK PLUGS, AND MANIFOLD GASKET.IT WAS RUNNING FINE FOR A WHILE BUT STILL AT IDLE IT FELT LIKE IT WAS GOING TO STALL. THEN ONE DAY IT WOULDN'T START AT ALL AND THE KEY GOT STUCK IN THE IGNITION. WE JUMPED THE VEHICLE AND THE KEY CAME OUT. THEN WE GOT THE CODES READ AT AUTO ZONE AND FOUND WE NEEDED A IGNITION COIL. SO WE REPLACED THAT. RAN GOOD BUT THE STALLING FEELING AT IDLE WAS STILL PRESENT. THEN THE KEY GOT STUCK IN THE IGNITION AGAIN AND THE SHIFTER BUTTON WAS PUSHED IN AND THE SHIFTER WOULD MOVE WITHOUT USING THE BRAKE.I FOUND PEOPLE HAVE HAD ALL THESE ISSUES ONLINE AND FOUND THE RELEASE SWITCH. I USED THIS SWITCH AND THE SHIFTER IS BACK TO NORMAL. WE HAVE A LIMITED INCOME AND WE CANT AFFORD ALL OF THESE ISSUES, BUT IT SEEMS THAT THEY ARE ALL VERY COMMON WITH THESE CARS. *TR

NHTSA ODI #10430753

50,000 miles · May 22, 2011
Latches/locks/linkages

DRIVER SIDE DOOR WILL NOT OPEN FROM THE INSIDE OR OUT. THE DOOR LOCK WILL GO UP AND DOWN BUT WILL NOT OPEN. *TR

NHTSA ODI #10402342

78,000 miles · Apr 4, 2011
Latches/locks/linkagesInjury

I HAVE HAD CONSTANT ISSUES WITH THE LOCK MECHANISM ON MY DOOR. A COUPLE OF TIMES WHEN OPENING MY REAR PASSENGER DOOR IT DOES NOT CLOSE. I'VE BEEN ABLE TO FIND A WAY TO GET THE LATCH TO GO BACK TO IT'S ORIGINAL POSITION AND THEN CLOSE AND LOCK THE DOOR. ON 04/02/11 HOWEVER, WHILE DRIVING, THE BACK DOOR OPENED UP ON ITSELF. SOME …

Read full complaint

I HAVE HAD CONSTANT ISSUES WITH THE LOCK MECHANISM ON MY DOOR. A COUPLE OF TIMES WHEN OPENING MY REAR PASSENGER DOOR IT DOES NOT CLOSE. I'VE BEEN ABLE TO FIND A WAY TO GET THE LATCH TO GO BACK TO IT'S ORIGINAL POSITION AND THEN CLOSE AND LOCK THE DOOR. ON 04/02/11 HOWEVER, WHILE DRIVING, THE BACK DOOR OPENED UP ON ITSELF. SOME THINGS FELL OUT OF THE CAR AND WERE SLIGHTLY DAMAGED AND MY FRIEND RIDING IN THE BACK INJURED THEMSELVES WHEN THE DOOR OPENED ON ITS OWN AND SLAMMED AGAINST THEM. WE CLOSED IT AGAIN WITH SUCCESS AND THEN MY FRIEND MOVED TO THE FRONT OF THE CAR AND WE TOOK ANY ITEMS OUT OF THE BACK SEAT AREA. AGAIN THE CAR DOOR OPENED ON ITS OWN HOWEVER, THIS TIME, THE DOOR WILL NOT CLOSE. I HAVE NEVER BEEN IN AN ACCIDENT, THE MECHANISM THAT KEEPS THE DOOR CLOSED AND LOCKED JUST SEEMS TO BE FAULTY. I'VE LOOKED ONLINE AND IT SEEMS MANY PEOPLE HAVE HAD THIS ISSUE. I DON'T UNDERSTAND WHY THIS HAS NOT BEEN RECALLED. NOW I'M FORCED TO FIND RIDES UNTIL I HAVE THE MONEY TO REPAIR AN IMPORTANT SAFETY ISSUE ON MY CAR THAT SHOULD HAVE NEVER BEEN AN ISSUE. I FOUND THAT MANY OF THE PARTS ON MY CAR USED FOR "SAFETY" ARE MADE OF PLASTIC. THIS INFURIATES ME. LUCKILY MY FRIEND IS ONLY SORE AND MY PERSONAL ITEMS DAMAGED WERE MORE OF PERSONAL VALUE THAN ACTUAL FINANCIAL VALUE BUT THIS IS STILL NOT ACCEPTABLE. I JUST KEEP THINKING IF THIS HAPPENS TO SOMEONE WHILE ON THE HIGHWAY THIS COULD BE FATAL AND CHEVY WILL HAVE DEATHS ON THEIR HANDS BECAUSE THEY HAVE SACRIFICED QUALITY FOR COST EFFECTIVENESS. *TR

NHTSA ODI #10394235

60,000 miles · Mar 3, 2011
Latches/locks/linkages

DOOR LATCH FAILURE. *TR

NHTSA ODI #10386278

Official recalls

5

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

10V073000 · Steering:electric Power Assist System

Mar 3, 2010

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.

Consequence & remedy

Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

07V014000 · Structure

Jan 18, 2007

CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'

Consequence & remedy

Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.

Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE10005 · Electric Power Steering Failure

Opened Jan 27, 2010 · Closed Jul 19, 2010

Status: closed (inferred from source dates) · Steering:electric Power Assist System

In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.