IllustrationON NOVEMBER 2, 2009 THERE WAS A STRONG FUEL SMELL, I BROUGHT THE VEHICLE TO MY REPAIR SHOP AND THEY DROPPED THE TANK AND FOUND THAT THE FUEL PUMP PORT WAS LEAKING, PUMP WAS REPLACED AND THE OLD PUMP IS AVAILBLE
2006 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1540–25K
42125–50K
55750–75K
34575–100K
331100–150K
142150K+
1,950 reports with mileage · 380 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
164 crash reports14 fire reports81 injury reports
Fuel System, Gasoline complaints
215 reportsYESTERDAY 03/20/10 ON SATURDAY NIGHT AT 11:30PM TO 11:40 PM MY VEHICLE COBALT AT CLOSE TO 40 KM/HR SPEED STOP WORKING. LIKE IGNITION OFF. ALL GAUGES GOES TO OFF CONDITION LIKE VEHICLE IS MOVING WITHOUT ENGINE RUNNING.OUTSIDE TEMP.-1DEGREE C. I PLACED EMERGENCY LIGHTS ON AND PUT IN PARKING MODE THEN I RESTART MY CAR AGAIN AND I…
Read full complaint
YESTERDAY 03/20/10 ON SATURDAY NIGHT AT 11:30PM TO 11:40 PM MY VEHICLE COBALT AT CLOSE TO 40 KM/HR SPEED STOP WORKING. LIKE IGNITION OFF. ALL GAUGES GOES TO OFF CONDITION LIKE VEHICLE IS MOVING WITHOUT ENGINE RUNNING.OUTSIDE TEMP.-1DEGREE C. I PLACED EMERGENCY LIGHTS ON AND PUT IN PARKING MODE THEN I RESTART MY CAR AGAIN AND IT STARTS. THIS IS HAPPENED SECOND TIME. I TOOK TO DEALER LAST MONTH BUT THERE WAS NO CODE. I COMPLAINED TO GM EARLIER ALSO. THEY TOLD ME TAKE TO DEALER WHEN IT HAPPEN AND IN RUNNING CONDITION. BUT ON SATURDAY AT 11:30 PM ON NIGHT WHICH DEALER SERVICE STATION IS OPEN? I HAVE 4 TIMES EARLIER SUDDEN ACCELERATION PROBLEM IN THE SAME VEHICLE ALSO. PL DO SOMETHING BEFORE IT MET WITH ACCIDENT. *TR
I HAVE A 2006 COBALT. THE FUEL PUMP STARTED TO LEAK GAS. I WAS WONDERING WHY THIS WAS NOT PART OF THE RECALL FOR THIS PROBLEM THAT HAS BEEN IN EFFECT FOR OTHER STATES. I LIVE IN MISSOURI. *TR
CAR DEVELOPED ODOR OF FUEL. CAR BEGAN TO LEAK FUEL ABOUT ONE MONTH AFTER ODOR APPEARED, FUEL LEAK WAS MINIMAL AT FIRST, PROGRESSED TO LARGE PUDDLE OF FUEL AND FREQUENCY BECAME CONSISTENT WITH A FUEL LEAK. TOOK CAR TO PERSONAL MECHANIC AND WAS DIAGNOSED FUEL PUMP HOUSING WAS CRACKED IN HALF. MECHANIC REPLACED WHOLE FUEL PUMP …
Read full complaint
CAR DEVELOPED ODOR OF FUEL. CAR BEGAN TO LEAK FUEL ABOUT ONE MONTH AFTER ODOR APPEARED, FUEL LEAK WAS MINIMAL AT FIRST, PROGRESSED TO LARGE PUDDLE OF FUEL AND FREQUENCY BECAME CONSISTENT WITH A FUEL LEAK. TOOK CAR TO PERSONAL MECHANIC AND WAS DIAGNOSED FUEL PUMP HOUSING WAS CRACKED IN HALF. MECHANIC REPLACED WHOLE FUEL PUMP ASSEMBLY--COST $ 553.58,MILEAGE AT 88583-- RECEIVED RECALL ON FUEL ASSEMBLY THREE MONTHS LATER--CURRENT MILEAGE 98,347. *TR
06 CHEVY COBALT TAKEN TO DEALER FOR FUEL SMELL. DEALER REPLACED FUEL PUMP PER RECALL IN ARIZONA. COBALT TAKEN BACK TO DEALER FOR FUEL SMELL, DEALER PRESSURIZED GAS TANK AND FOUND FITTING ON TOP OF TANK SPRAYING FUEL. FIRE HAZARD. REPLACEMENT FUEL TANK FOR THIS COBALT IS BACKORDERED IT COULD TAKE WEEKS OR MONTHS TO GET ONE. I BEL…
Read full complaint
06 CHEVY COBALT TAKEN TO DEALER FOR FUEL SMELL. DEALER REPLACED FUEL PUMP PER RECALL IN ARIZONA. COBALT TAKEN BACK TO DEALER FOR FUEL SMELL, DEALER PRESSURIZED GAS TANK AND FOUND FITTING ON TOP OF TANK SPRAYING FUEL. FIRE HAZARD. REPLACEMENT FUEL TANK FOR THIS COBALT IS BACKORDERED IT COULD TAKE WEEKS OR MONTHS TO GET ONE. I BELIEVE THE FUEL PUMP IS NOT THE PROBLEM, IT IS THE TANK. IF NOT WHY DOES THERE SEEM TO BE A PROBLEM GETTING A NEW TANK. *TR
2006 COBALT I HAVE EXPERIENCED THIS PROBLEM A COUPLE OF TIMES BUT IT DID NOT CONCERN ME UNTIL KNOW THAT I LOOK AT THE RECALLS. WHEN DRIVING MY CAR AT FREEWAY SPEEDS I GET A GASOLINE LIKE SMELL. THIS HAS HAPPENED FOR A COUPLE OF YEARS. I TOOK IT TO A DEALER ABOUT 2 WEEKS AGO AND THEY CHECKED IT OUT AND TOLD ME THAT THE RECALL DID…
Read full complaint
2006 COBALT I HAVE EXPERIENCED THIS PROBLEM A COUPLE OF TIMES BUT IT DID NOT CONCERN ME UNTIL KNOW THAT I LOOK AT THE RECALLS. WHEN DRIVING MY CAR AT FREEWAY SPEEDS I GET A GASOLINE LIKE SMELL. THIS HAS HAPPENED FOR A COUPLE OF YEARS. I TOOK IT TO A DEALER ABOUT 2 WEEKS AGO AND THEY CHECKED IT OUT AND TOLD ME THAT THE RECALL DID NOT PERTAIN TO ME, BUT I HAVE LOOKED AT THE VIN NUMBERS AND THEY MATCH BUT I HAVE NOT RECEIVED A RECALL LETTER. *TR
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT SMELLED A STRONG ODOR OF FUEL OUTSIDE THE VEHICLE. IN ADDITION, AN EXCESSIVE AMOUNT OF FUEL LEAKAGE WAS ON THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 09V419000 (FUEL SYSTEM, GASOLINE DELIV…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT SMELLED A STRONG ODOR OF FUEL OUTSIDE THE VEHICLE. IN ADDITION, AN EXCESSIVE AMOUNT OF FUEL LEAKAGE WAS ON THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 09V419000 (FUEL SYSTEM, GASOLINE DELIVERY, FUEL PUMP). THE CONTACT EXPERIENCED THE IDENTICAL FAILURES AS MENTION IN THE RECALL; HOWEVER, THE VIN WAS EXCLUDED FROM THE RECALL DEFECT. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED. THE FAILURE MILEAGE WAS 116,000.
2006 CHEVROLET COBALT-POWER STEERING FAILURE. I HAVE NO POWER STEERING IN THIS CAR NOW. THE ELECTRICAL UNIT THAT POWERS THE POWER STEERING HAS GONE OUT-FAILED. I TOOK THE CAR TO A CHEVY DEALERSHIP AND WAS TOLD IT WOULD COST AT THE VERY LEAST $800.00 TO FIX. I CANNOT AFFORD TO HAVE THIS REPAIRED. MY SON USES THIS CAR DAILY (NO…
Read full complaint
2006 CHEVROLET COBALT-POWER STEERING FAILURE. I HAVE NO POWER STEERING IN THIS CAR NOW. THE ELECTRICAL UNIT THAT POWERS THE POWER STEERING HAS GONE OUT-FAILED. I TOOK THE CAR TO A CHEVY DEALERSHIP AND WAS TOLD IT WOULD COST AT THE VERY LEAST $800.00 TO FIX. I CANNOT AFFORD TO HAVE THIS REPAIRED. MY SON USES THIS CAR DAILY (NOW WITH NO POWER STEERING) TO AND FROM WORK AND TO SCHOOL. HIS COMMUTE IS 1 HOUR ON THE INTERSTATE ONE WAY. MY SON FOLLOWS A WEBSITE FOR COBALT OWNERS AND TELLS ME THAT ALMOST ALL OF THE EMAILS ON THE WEBSITE ARE REGARDING THE FAILURE OF THE ELECTRICAL UNIT FOR THE POWER STEERING. WE HAVE ALSO HAD TO REPLACE THE FUEL TANK AND FUEL INJECTORS ON THIS CAR. WILL THERE BE ANY RECALL FOR THE CHEVY COBALT? THERE SHOULD BE!!!L *CN
MY DAUGHTER'S 06 CHEVY COBALT LS STEERING LOSS POWER AND SHE BARLEY GOT HER CAR OUT OF TRAFFIC, SHE THEN WAITED TEN MINUTES AND STARTED THE CAR AGAIN AND WAS ABLE TO DRIVE 4 MORE MILES BEFORE IT HAPPENED AGAIN. THIS HAS CONTINUED TO HAPPEN SO I HAD TO GET IT FIXED BEFORE SOMEONE GOT HURT, THIS HAS COST ME SOME VERY EXPENSIVE …
Read full complaint
MY DAUGHTER'S 06 CHEVY COBALT LS STEERING LOSS POWER AND SHE BARLEY GOT HER CAR OUT OF TRAFFIC, SHE THEN WAITED TEN MINUTES AND STARTED THE CAR AGAIN AND WAS ABLE TO DRIVE 4 MORE MILES BEFORE IT HAPPENED AGAIN. THIS HAS CONTINUED TO HAPPEN SO I HAD TO GET IT FIXED BEFORE SOMEONE GOT HURT, THIS HAS COST ME SOME VERY EXPENSIVE CAR REPAIRS, SOME THING NEEDS TO BE DONE ABOUT THIS I'VE BEENTOLD BY THE REPAIR SHOP THAT IT COULD HAPPEN AGAIN SINCE THE PART THEY REPLACED IS THE SAME PART THEY ORDERED, WHICH IS FAULTY, I LIVE IN FEAR EVERYTIME MY CHILD GETS IN THAT CAR TO GO ANYWHERE, AND SHE NEEDS A CAR TO GET TO COLLEGE. AS I SAID BEFORE PLEASE DON'T WAIT FOR A TRAGEDY THAT COULD BE PREVENTED. THANK YOU *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THE FUEL LINE IS CRACKED AND THE RETURN VALVE LINE IS SPILLING FUEL ON THE GROUND. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS REPAIRED COSTING $800. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 84,000.
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.