← New search

2006 Chevrolet Cobalt

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

1,950 reports with mileage · 380 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

164 crash reports14 fire reports81 injury reports

Fuel System, Gasoline complaints

215 reports
Clear category filter
Mileage unknown · Jul 25, 2025
EngineFuel System, Gasoline

The contact’s wife owns a 2006 Chevrolet Cobalt. The contact stated there was an abnormal fuel odor inside the cabin of the vehicle. While exiting the vehicle, the contact became aware that there was an oil leak underneath the rear end of the vehicle, and the fuel odor was more evident. There were no warning lights illuminated. …

Read full complaint

The contact’s wife owns a 2006 Chevrolet Cobalt. The contact stated there was an abnormal fuel odor inside the cabin of the vehicle. While exiting the vehicle, the contact became aware that there was an oil leak underneath the rear end of the vehicle, and the fuel odor was more evident. There were no warning lights illuminated. The vehicle was jerking while accelerating and while driving from being stationary. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ODI #11676098

59,410 miles · May 1, 2023
Fuel System, Gasoline

The contact owns a 2006 Chevrolet Cobalt. The contact became aware that fuel had been puddling underneath the vehicle. The contact had previously noticed an abnormal gasoline odor inside the cabin of the vehicle. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or indep…

Read full complaint

The contact owns a 2006 Chevrolet Cobalt. The contact became aware that fuel had been puddling underneath the vehicle. The contact had previously noticed an abnormal gasoline odor inside the cabin of the vehicle. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had been informed of the failure. The contact researched online and determined that the failure was related to NHTSA Campaign Number: 09V419000 (Fuel System, Gasoline). The failure mileage was approximately 59,410.

NHTSA ODI #11519846

69,817 miles · Apr 5, 2022
Fuel System, Gasoline

The contact owns a 2006 Chevrolet Cobalt. The contact stated while standing outside the vehicle a fuel odor was detected. The contact also stated that while driving, there was a fuel odor detected inside the vehicle. The vehicle was not taken to the dealer or independent mechanic to be diagnosed or repaired. The dealer was conta…

Read full complaint

The contact owns a 2006 Chevrolet Cobalt. The contact stated while standing outside the vehicle a fuel odor was detected. The contact also stated that while driving, there was a fuel odor detected inside the vehicle. The vehicle was not taken to the dealer or independent mechanic to be diagnosed or repaired. The dealer was contacted and the contact was awaiting an appointment. The contact was also informed that the VIN was not under recall. The manufacturer was contacted and made aware of the issue. The manufacturer informed the contact of a fuel pump module replacement coverage under Manufacturer Communication Number: 09275. Future Chevrolet (4811 Madison Ave, Sacramento, CA 95841) was contacted and the contact was still awaiting a callback. The contact related the failure to NHTSA Campaign Number: 09V419000 (Fuel System, Gasoline) however, the VIN was not included. The approximate failure mileage was 69,817.

NHTSA ODI #11459710

126,000 miles · Jun 14, 2021
Fuel System, GasolineStructure

The contact owns a 2006 Chevrolet Cobalt. The contact stated that after turning off the vehicle, there was an abnormal fuel odor coming from the vehicle. Upon inspection, the contact discovered severe corrosion on the rear driver’s side undercarriage of the vehicle. Due to the rust, the fuel lines started leaking. The local deal…

Read full complaint

The contact owns a 2006 Chevrolet Cobalt. The contact stated that after turning off the vehicle, there was an abnormal fuel odor coming from the vehicle. Upon inspection, the contact discovered severe corrosion on the rear driver’s side undercarriage of the vehicle. Due to the rust, the fuel lines started leaking. The local dealer was contacted and informed the contact that the Vin was not under recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 126,000.

NHTSA ODI #11420860

94,000 miles · Mar 26, 2021
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, HE STARTED TO SMELL A FUEL ODOR. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. A DEALER WAS NOT CONTACTED. …

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, HE STARTED TO SMELL A FUEL ODOR. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.

NHTSA ODI #11405035

68,369 miles · Nov 9, 2020
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED IN THE GARAGE, THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE THE GARAGE. THE CONTACT MOVED THE VEHICLE OUT OF THE GARAGE AND THE FUEL ODOR WAS STILL PRESENT. THE CONTACT NOTICED EVIDENCE OF THE FUEL LEAK ON THE GROUND. THE VEHICLE …

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED IN THE GARAGE, THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE THE GARAGE. THE CONTACT MOVED THE VEHICLE OUT OF THE GARAGE AND THE FUEL ODOR WAS STILL PRESENT. THE CONTACT NOTICED EVIDENCE OF THE FUEL LEAK ON THE GROUND. THE VEHICLE WAS TAKEN TO ELKINS CHEVROLET (401 Route 73 SOUTH, MARLTON, NJ 08053, (856) 983-9200) TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE FUEL LINES WERE RUSTED AND LEAKING NEAR THE WHEEL WELL. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68369. *BF

NHTSA ODI #11373829

121,633 miles · Oct 28, 2020
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT MULTIPLE ATTEMPTS WERE NEEDED TO START THE VEHICLE WITHOUT WARNING. ADDITIONALLY, THERE WAS A STRONG GASOLINE ODOR THROUGHOUT THE VEHICLE. THE CONTACT SPOKE WITH BOB VALENTI CHEVROLET (72 JERRY BROWNE RD #3050, MYSTIC, CT 06355, (860) 536-4931) AND INQUIRED AB…

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT MULTIPLE ATTEMPTS WERE NEEDED TO START THE VEHICLE WITHOUT WARNING. ADDITIONALLY, THERE WAS A STRONG GASOLINE ODOR THROUGHOUT THE VEHICLE. THE CONTACT SPOKE WITH BOB VALENTI CHEVROLET (72 JERRY BROWNE RD #3050, MYSTIC, CT 06355, (860) 536-4931) AND INQUIRED ABOUT NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 121,633.

NHTSA ODI #11366839

105,000 miles · Jul 7, 2020
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE APPROACHING THE VEHICLE, HE BECAME AWARE OF A FUEL LEAK UNDER THE DRIVER'S SIDE TIRE. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND DRIVEN TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACT…

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE APPROACHING THE VEHICLE, HE BECAME AWARE OF A FUEL LEAK UNDER THE DRIVER'S SIDE TIRE. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND DRIVEN TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.

NHTSA ODI #11338003

28,000 miles · Aug 8, 2019
EngineFuel System, Gasoline

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR EMERGING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STA…

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR EMERGING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE SHOULD HAVE BEEN REPAIRED BY THE DEALER. THE MANUFACTURER DECLINED REIMBURSEMENT OF THE REPAIR FEES. THE FAILURE MILEAGE WAS 28,000. *BF*JB

NHTSA ODI #11242472

118,000 miles · Sep 2, 2018
Fuel System, GasolineFuel/propulsion System

VEHICLE KEEPS STALLING AND SHUTTING DOWN WHEN TURNING OR A SPEED BUMP. WAS INFORMED IT WAS THE FUEL PUMP. *TR

NHTSA ODI #11124063

Official recalls

5

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

10V073000 · Steering:electric Power Assist System

Mar 3, 2010

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.

Consequence & remedy

Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

07V014000 · Structure

Jan 18, 2007

CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'

Consequence & remedy

Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.

Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE10005 · Electric Power Steering Failure

Opened Jan 27, 2010 · Closed Jul 19, 2010

Status: closed (inferred from source dates) · Steering:electric Power Assist System

In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.