NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
412 reportsClear category filter90,000 miles · Aug 1, 2011
Electrical SystemSteering
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 30 MPH THE ELECTRONIC DOOR LOCKS BEGAN TO OPEN AND CLOSE ERRATICALLY. THE STEERING WHEEL BECAME STIFF MAKING IT DIFFICULT TO CONTROL THE VEHICLE. THE CONTACT STATED THE POWER STEERING FAILED AND THE STEERING WHEEL NEEDED EXCESSIVE EFFORT TO TURN THE STEERI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 30 MPH THE ELECTRONIC DOOR LOCKS BEGAN TO OPEN AND CLOSE ERRATICALLY. THE STEERING WHEEL BECAME STIFF MAKING IT DIFFICULT TO CONTROL THE VEHICLE. THE CONTACT STATED THE POWER STEERING FAILED AND THE STEERING WHEEL NEEDED EXCESSIVE EFFORT TO TURN THE STEERING WHEEL WHILE DRIVING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE. THERE WERE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL BUT THE CONTACT WAS UNAWARE OF WHICH ONES ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 10V073000 (STEERING:ELECTRIC POWER ASSIST SYSTEM) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED TO VERIFY IF THE VIN WAS INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10416441
80,000 miles · Jun 27, 2011
Electrical SystemElectronic Stability Control (esc)Power Train
I OWN A 2006 CHEVROLET COBALT LS SEDAN. THIS CAR EVERY YEAR LIKE CLOCK WORK HAS TO EITHER HAVE A NEW TRANSMISSION PUT INTO IT, OR HAS SHIFTING PROBLEMS. THE CAR WILL BE FINE FOR ABOUT A YEAR AND THEN IT STRUGGLES TO SHIFT GEARS AND IT WILL BE SUBTLE. THEN IT SLOWLY STARTS TO FEEL LIKE THE TRANSMISSION IS " SLIPPING" WHEN U REVER…
Read full complaint
I OWN A 2006 CHEVROLET COBALT LS SEDAN. THIS CAR EVERY YEAR LIKE CLOCK WORK HAS TO EITHER HAVE A NEW TRANSMISSION PUT INTO IT, OR HAS SHIFTING PROBLEMS. THE CAR WILL BE FINE FOR ABOUT A YEAR AND THEN IT STRUGGLES TO SHIFT GEARS AND IT WILL BE SUBTLE. THEN IT SLOWLY STARTS TO FEEL LIKE THE TRANSMISSION IS " SLIPPING" WHEN U REVERSE AND THEN PUT IT BACK INTO DRIVE IT SLIDES BACK BEFORE IT BEGINS TO MOVE FORWARD AGAIN. THIS CAR IS ONLY 5 YEARS OLD BUT HAS HAD 3 TRANSMISSIONS IN IT'S LIFE TIME, AND IT'S STARTING TO FEEL LIKE IT'S GOING FOR ITS 4TH. *TR
NHTSA ODI #10409142
70,796 miles · Jun 27, 2011
Electrical System
CAR WOULD NO START ON FIRST ATTEMPT--STEREO AND ALL ELECTRICAL COMPONENTS IN CAR TURN ON, BUT CAR DOES NOT START AT ALL.GOT BACK INTO CAR ABOUT 10 MINUTES LATER, TRIED AGAIN--STARTED RIGHT UP. WHILE DRIVING, ALL GAUGES WOULD DROP ALL THE WAY TO ZERO AND ALL ELECTRICAL INSIDE CAR GOES DEAD. UPON PARKING, CAR WOULD NOT IMMEDIATELY…
Read full complaint
CAR WOULD NO START ON FIRST ATTEMPT--STEREO AND ALL ELECTRICAL COMPONENTS IN CAR TURN ON, BUT CAR DOES NOT START AT ALL.GOT BACK INTO CAR ABOUT 10 MINUTES LATER, TRIED AGAIN--STARTED RIGHT UP. WHILE DRIVING, ALL GAUGES WOULD DROP ALL THE WAY TO ZERO AND ALL ELECTRICAL INSIDE CAR GOES DEAD. UPON PARKING, CAR WOULD NOT IMMEDIATELY RESTART. GOT ELECTRICAL TEST AT AUTO PARTS STORE, TOLD IT WAS READING BAD BATTERY--SO I REPLACED BATTERY AT THAT TIME. *TR
NHTSA ODI #10408988
65,000 miles · Jun 27, 2011
Electrical System
I WAS DRIVING TO A DIFFERENT STATE, AND ABOUT 3 HOURS INTO THE DRIVE, I STOPPED FOR GAS. AFTER SHUTTING THE CAR OFF, I WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. I WAS ABLE TO RELEASE THE KEY BY REACHING UNDER THE STEERING COLUMN AND PRESSING THE MANUAL RELEASE BUTTON. EVEN AFTER HAVING RECALL WORK ON ANOTHER ITEM AT A GM D…
Read full complaint
I WAS DRIVING TO A DIFFERENT STATE, AND ABOUT 3 HOURS INTO THE DRIVE, I STOPPED FOR GAS. AFTER SHUTTING THE CAR OFF, I WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. I WAS ABLE TO RELEASE THE KEY BY REACHING UNDER THE STEERING COLUMN AND PRESSING THE MANUAL RELEASE BUTTON. EVEN AFTER HAVING RECALL WORK ON ANOTHER ITEM AT A GM DEALER, THEY DIDN'T OFFER ANY SORT OF SOLUTION ON HOW TO GET THIS FIXED. I STILL HAVE TO PRESS THE MANUAL RELEASE TO GET THE KEY OUT. CONTACTED GM CUSTOMER SERVICE THROUGH EMAIL AND THEY OFFERED NO REMEDY AND CLAIMED NO RESPONSIBILITY. *TR
NHTSA ODI #10408987
93,000 miles · Jun 2, 2011
Electrical System
TL*THE CONTACT OWNS A 2006 CHEVROLET COLBALT LT. THE CONTACT STATED THAT WITHIN A WEEK AFTER HE PURCHASED THE VEHICLE THE ELECTRICAL SYSTEM COMPLETELY FAILED. THE VEHICLE WAS REPAIRED BY THE SALES CENTER, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 93,000 AND THE CURRENT MILEAGE IS 105,0…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COLBALT LT. THE CONTACT STATED THAT WITHIN A WEEK AFTER HE PURCHASED THE VEHICLE THE ELECTRICAL SYSTEM COMPLETELY FAILED. THE VEHICLE WAS REPAIRED BY THE SALES CENTER, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 93,000 AND THE CURRENT MILEAGE IS 105,000. UPDATED 07.20.11
NHTSA ODI #10404187
98,461 miles · May 11, 2011
Electrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION. THE FAILURE DRAINED THE BATTERY UNTIL THE VEHICLE SHUT DOWN COMPLETELY. THE CONTACT HAD THE VEHICLE TOWED TO A DEALER WHERE HE WAS ADVISED THAT THE STEERING COLUMN WOULD NEED A NEW KEY CYLINDER. THE DEALER STATED THAT I…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION. THE FAILURE DRAINED THE BATTERY UNTIL THE VEHICLE SHUT DOWN COMPLETELY. THE CONTACT HAD THE VEHICLE TOWED TO A DEALER WHERE HE WAS ADVISED THAT THE STEERING COLUMN WOULD NEED A NEW KEY CYLINDER. THE DEALER STATED THAT IF THE KEY CYLINDER WAS NOT REPLACED, THEN THE VEHICLE WOULD CONTINUE TO SHUT DOWN IN THE FUTURE. THE CONTACT BELIEVED THAT THE FAILURE WAS A KNOWN SAFETY ISSUE WITH THE YEAR MAKE AND MODEL DUE TO THE NUMEROUS REPORTS FOUND VIA THE INTERNET. THE FAILURE MILEAGE WAS 98,461.
NHTSA ODI #10400042
98,000 miles · Apr 16, 2011
Electrical System
SECOND 2006 CHEVY COBALT OWNED. THE FIRST HAD AN ELECTRICAL ISSUE AND BURNED TO THE GROUND WITHIN A MONTH OF PURCHASING IT. THE AIR HAD GONE OUT ON IT AND WE HAD RETURNED IT TO DEALER WHERE IT WAS SERVICED. WITHIN A WEEK IT CAUGHT FIRE IN TRAFFIC. WE ASSUMED THE DEALER DID SOMETHING INCORRECT WHEN RECONNECTING THE BATTERY CABLES…
Read full complaint
SECOND 2006 CHEVY COBALT OWNED. THE FIRST HAD AN ELECTRICAL ISSUE AND BURNED TO THE GROUND WITHIN A MONTH OF PURCHASING IT. THE AIR HAD GONE OUT ON IT AND WE HAD RETURNED IT TO DEALER WHERE IT WAS SERVICED. WITHIN A WEEK IT CAUGHT FIRE IN TRAFFIC. WE ASSUMED THE DEALER DID SOMETHING INCORRECT WHEN RECONNECTING THE BATTERY CABLES. PARTLY BECAUSE THE FIRE HAD STARTED IN TRUNK WHERE BATTERY WAS. WE THOUGHT IT WAS HUMAN ERROR SO WE PURCHASED ANOTHER 2006 COBALT. IT STARTED DYING IN TRAFFIC AT INTERSECTIONS WHEN STOPPED OR WHEN YOU ALLOW IT TO IDLE. TOOK IT TO SEVERAL AUTO STORES AND HAD PUT ON MACHINE. ANSWER WAS RAPID MISFIRE. BOUGHT NEW SPARKPLUGS AND WIRES. REPLACED THOSE TO NO AVAIL, TRIED GAS TREATMENTS FOR THE SHUTTERING ENGINE, TO NO AVAIL. TOOK IT TO MECHANICS TWICE. THEY REPLACED THE COOLING SENSOR. STILL CUTTING OUT AND WOULDN'T IDLE PROPERLY. TOOK BACK TO MECHANIC. HE COULDN'T FIND ANYTHING. NOTICED ONE HEADLIGHT OFF WHEN WE PICKED IT UP. TOOK IT HOME TO INVESTIGATE AND HEADLIGHT BACK ON. WE BELIEVE ITS A SHORT SOMEWHERE IN SYSTEM. DOESN'T DIE WHEN LIGHTS ARE OFF. APPROXIMATELY 98,000 MILES. HAD A MINOR ISSUE WITH A GAS LEAK. TOOK IT TO LOCAL DEALER AND WAS ADDRESSED IMMEDIATELY. NO OTHER MAJOR ISSUES. *TR
NHTSA ODI #10396097
Mileage unknown · Mar 7, 2011
Electrical SystemSteering
TL* THE CONTACT OWNS 2006 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER RECEIVING REPAIRS UNDER NHTSA CAMPAIGN: 10V073000 (STEERING: ELECTRIC POWER ASSIST), THE VEHICLE BEGAN STALLING SPORADICALLY AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE DEALER ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY THE WIRING HARNESS …
Read full complaint
TL* THE CONTACT OWNS 2006 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER RECEIVING REPAIRS UNDER NHTSA CAMPAIGN: 10V073000 (STEERING: ELECTRIC POWER ASSIST), THE VEHICLE BEGAN STALLING SPORADICALLY AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE DEALER ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY THE WIRING HARNESS UNDER THE DASHBOARD WHICH HE DISCOVERED WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER TWICE YET THE DEALER WAS UNABLE TO PINPOINT THE FAILURE AND COULD ONLY SUGGEST THAT IT WAS THE WIRING HARNESS, WHICH WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 68,000. UPDATED 04/15/11*LJ THE CONSUMER STATED THE DEALER KEPT THE VEHICLE FOR A WEEK TO CORRECT THE PROBLEM. THE VEHICLE IS CURRENTLY OPERATING IN A NORMAL MANNER. UPDATED 11/04/11
NHTSA ODI #10386735
52,329 miles · Mar 6, 2011
Electrical System
2006 CHEVY COBALT SS/SC HAS BEEN SERVICED MORE THAN 10 TIMES IN 5 MONTHS FOR SENSORS FAILING AND ELECTRICAL ISSUES THAT ARE STILL OCCURRING. MAJOR PROBLEM OCCURRING IS CAR SHUTTING ITSELF OFF IN TRAFFIC AND AT IDLE. *TR
NHTSA ODI #10386610
66,000 miles · Feb 5, 2011
Electrical SystemEquipment
I BOUGHT MY 2006 COBALT BRAND NEW AND IT NOW HAS 66,000 MILES ON IT. AT ABOUT 15,000 MILES THE KEY LOCKED IN THE IGNITION AND SHIFTING GEARS BECAME ALMOST IMPOSSIBLE (AUTOMATIC TRANSMISSION). IT WAS UNDER WARRANTY SO I TOOK IT TO THE DEALER AND THEY REPLACED THE SHIFTER ASSEMBLY. NOW TODAY (2/3/11) I WASN'T HAVING ANY PROBLEM…
Read full complaint
I BOUGHT MY 2006 COBALT BRAND NEW AND IT NOW HAS 66,000 MILES ON IT. AT ABOUT 15,000 MILES THE KEY LOCKED IN THE IGNITION AND SHIFTING GEARS BECAME ALMOST IMPOSSIBLE (AUTOMATIC TRANSMISSION). IT WAS UNDER WARRANTY SO I TOOK IT TO THE DEALER AND THEY REPLACED THE SHIFTER ASSEMBLY. NOW TODAY (2/3/11) I WASN'T HAVING ANY PROBLEMS WITH MY CAR UNTIL I STARTED IT AND COULDN'T PRESS THE SHIFTER BUTTON IN TO PUT IT OUT OF PARK. IT STAYED STUCK IN PARK. WHEN I TRIED TO TAKE THE KEY OUT, IT STAYED STUCK IN ACC. I WAS ABLE TO MANUALLY TAKE IT OUT BY PRESSING THE "PLUNGER" UNDER THE STEERING WHEEL. CALLED THE DEALER AND HAD TO TOW MY CAR THERE. AGAIN, MY SHIFTER ASSEMBLY HAS TO BE REPLACED WITH A TOTAL COST (AFTER TOWING, DIAGNOSTICS, LABOR, AND PARTS) OF $450 OUT-OF-POCKET. DUE TO A CHEAP PLASTIC PIECE IN THE GEAR SHIFT. RIDICULOUS. *TR
NHTSA ODI #10380803
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration