IllustrationCAR WILL NOT START THE COMPUTER STATES THAT "POWER STEERING" I TOOK THIS TO THE DEALER AND THEY SAID THAT THE PROBLEM WAS THE FUSE BOX I REPLACED IT AND THERE IS STILL A PROBLEM I WILL TAKE TO DEALER TO CHECK NEXT PROBLEM. *TR
2006 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1540–25K
42125–50K
55750–75K
34575–100K
331100–150K
142150K+
1,950 reports with mileage · 380 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
164 crash reports14 fire reports81 injury reports
Electrical System complaints
412 reportsI HAVE A 2006 COBALT. PERIODICALLY I CAN'T OPEN THE DRIVER DOOR FROM INSIDE AND I HAVE TO ROLL DOWN THE WINDOW TO PULL HANDLE FROM OUTSIDE TO GET OUT. AND THEN FUSS WITH THE LATCH MECHANISM SOMETIMES TO GET THE DOOR TO SHUT. AND RIGHT NOW MY LOCKS ARE GOING UP AND DOWN BY THEMSELVES WHILE I DRIVE AND WHEN I'M PARKED.. I LOCK MY…
Read full complaint
I HAVE A 2006 COBALT. PERIODICALLY I CAN'T OPEN THE DRIVER DOOR FROM INSIDE AND I HAVE TO ROLL DOWN THE WINDOW TO PULL HANDLE FROM OUTSIDE TO GET OUT. AND THEN FUSS WITH THE LATCH MECHANISM SOMETIMES TO GET THE DOOR TO SHUT. AND RIGHT NOW MY LOCKS ARE GOING UP AND DOWN BY THEMSELVES WHILE I DRIVE AND WHEN I'M PARKED.. I LOCK MY DOORS AND I COME OUT TO MY CAR AND THEY ARE UNLOCKED. AND I CAN'T DISENGAGE MY ALARM...SOO EVERY TIME I OPEN THE DOOR I HAVE TO JUMP IN AND TURN ON THE IGNITION. I CALLED THE LOCAL CHEVY DEALER AND OF COURSE THEY HAVEN'T HEARD ANY COMPLAINTS LIKE THIS. ALTHOUGH, I'VE READ MANY COMPLAINTS LIKE THIS.. THEY TELL ME IF I WANT TO BRING IT IN, I HAVE TO PAY FOR THEM TO DIAGNOSE IT! I'M STILL MAKING PAYMENTS ON THIS CAR! *JS
TL* THE CONTACT OWNS 2006 CHEVROLET COBALT. THE CONTACT STATED THAT SHE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. SHE WAS ABLE TO REMOVE THE KEY BY ENGAGING THE RELEASE BUTTON LOCATED UNDER THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT DIAGNOSED. THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS, NONE…
Read full complaint
TL* THE CONTACT OWNS 2006 CHEVROLET COBALT. THE CONTACT STATED THAT SHE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. SHE WAS ABLE TO REMOVE THE KEY BY ENGAGING THE RELEASE BUTTON LOCATED UNDER THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT DIAGNOSED. THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS, NONE OF WHOM COULD PROVIDE A CAUSE OR REMEDY FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 108,000.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE POWER STEERING, TIRE TRACTION AND CHECK ENGINE WARNING LIGHTS WERE ILLUMINATED. THE AUTOMATIC DOOR LOCKS WOULD LOCK AND UNLOCK THE DOORS INDEPENDENTLY AND WITHOUT WARNING, AND THE SPEEDOMETER WOULD BECOME INOPERATIVE. THE CONTACT WOULD HAVE TO SHUT THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE POWER STEERING, TIRE TRACTION AND CHECK ENGINE WARNING LIGHTS WERE ILLUMINATED. THE AUTOMATIC DOOR LOCKS WOULD LOCK AND UNLOCK THE DOORS INDEPENDENTLY AND WITHOUT WARNING, AND THE SPEEDOMETER WOULD BECOME INOPERATIVE. THE CONTACT WOULD HAVE TO SHUT THE VEHICLE OFF AND RESTART FOR THE VEHICLE TO PERFORM AS NORMAL. THE DEALER REPAIRED VARIOUS COMPONENTS UNKNOWN TO THE CONTACT ON SEVERAL OCCASIONS HOWEVER, THE FAILURE WOULD RECUR. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING. WHEN THE FAILURE OCCURRED, THE KEY WOULD REMAIN STUCK IN THE IGNITION. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS DRIVEN OVER A POTHOLE OR BUMP. IN ADDITION, THE CONTACT STATED THAT THE ALL OF …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING. WHEN THE FAILURE OCCURRED, THE KEY WOULD REMAIN STUCK IN THE IGNITION. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS DRIVEN OVER A POTHOLE OR BUMP. IN ADDITION, THE CONTACT STATED THAT THE ALL OF THE ELECTRONICS WOULD CONTINUE FUNCTIONING WHEN THE VEHICLE STALLED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 80,000. UPDATED 04/10/12*LJ THE CONSUMER STATED HE WAS UNABLE TO REMOVED THE KEY FROM THE IGNITION. 04/16/12
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE PARKED, THE CONTACT WAS UNABLE TO RELEASE THE KEY FROM THE IGTION SWITCH AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO ADVISED THE CONTACT TO HAVE THE VEHICLE INSPECTED BY A DEALER. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE PARKED, THE CONTACT WAS UNABLE TO RELEASE THE KEY FROM THE IGTION SWITCH AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO ADVISED THE CONTACT TO HAVE THE VEHICLE INSPECTED BY A DEALER. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT COULD NOT REMOVE THE KEY FROM THE IGNITION. IN ORDER TO SUCCESSFULLY REMOVE THE KEY FROM THE IGNITION, THE CONTACT HAD TO PULL THE EMERGENCY RELEASE ON THE STEERING WHEEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE APP…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT COULD NOT REMOVE THE KEY FROM THE IGNITION. IN ORDER TO SUCCESSFULLY REMOVE THE KEY FROM THE IGNITION, THE CONTACT HAD TO PULL THE EMERGENCY RELEASE ON THE STEERING WHEEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.
AS I WAS COMING TO STOP AT A RED LIGHT, I HEARD A DING AND "POWER STEERING" FLASHED ON MY DASHBOARD. MY CAR THEN STARTED TO JERK, AND CONTINUED WHEN I SPED UP. THIS HAS HAPPENED SEVERAL TIMES AFTER THE FIRST INCIDENT. *TR
MY 2006 CHEVY COBALT HAD WHEEL BEARING ISSUES STARTING AT 40,000 MILES. AT 50,000 MILES MY FRONT END SUSPENSION (LOWER CONTROL ARM AND BUSHINGS), STRUTS, AND DOORS LOCKS STARTED ACTING UP. MY DOOR LOCKS WILL JAM AND I WILL BE TRAPPED IN MY CAR UNTIL THEY (DOOR LOCKS) DECIDE TO WORK AGAIN. FORTUNATELY FOR ME USUALLY ONLY ONE STOP…
Read full complaint
MY 2006 CHEVY COBALT HAD WHEEL BEARING ISSUES STARTING AT 40,000 MILES. AT 50,000 MILES MY FRONT END SUSPENSION (LOWER CONTROL ARM AND BUSHINGS), STRUTS, AND DOORS LOCKS STARTED ACTING UP. MY DOOR LOCKS WILL JAM AND I WILL BE TRAPPED IN MY CAR UNTIL THEY (DOOR LOCKS) DECIDE TO WORK AGAIN. FORTUNATELY FOR ME USUALLY ONLY ONE STOPS WORKING AT A TIME. THE DEALER SAYS THAT IT JUST NEEDS GREASING; I HAVE TRIED EVERY GREASE UNDER THE SUN AND NONE HAS FIXED THE PROBLEM. THIS IS A SERIOUS SAFETY ISSUE AND THIS CAR SHOULD HAVE A RECALL TO AT LEAST FIX THE DOORS!!!.THE DEALER WANTS TO CHARGE OVER $1,000 PER DOOR FOR REPAIRS. I HAVE HEARD OF SOME PEOPLES DOORS NEVER OPENING AGAIN AND THE DOOR HAVING TO BE CUT OFF TO BE REPAIRED. IF SOMETHING WERE TO HAPPEN YOU NEED TO BE ABLE TO QUICKLY AND SAFELY GET OUT OF THE CAR. PLEASE PLEASE PLEASE RECALL THIS DOOR ISSUE ON THE COBALT! *TR
DOOR WILL NOT SHUT, THAN DOOR WILL NOT OPEN, THAN DOOR OPENED WHILE DRIVING DOWN STREET. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.