SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2004 Chevrolet Classic

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
40Owner complaints

Model-year median: 44.5

1Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
40
200449
2005
Compare all Classic years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
28Engine
4Equipment
2Exterior Lighting
2Service Brakes, Electric
2
All reported categories
Vehicle Speed Control
2Engine And Engine Cooling
1Equipment Adaptive/mobility
1Fuel/propulsion System
1Power Train
1Service Brakes
1Steering
1Suspension
1Unknown Or Other
1Visibility
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

31 reports with mileage · 9 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Equipment. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports1 fire reports1 injury reports

Fuel/propulsion System complaints

1 reports
Clear category filter
Mileage unknown · Apr 18, 2017
Fuel/propulsion System

MY FUEL LEVEL GAUGE IS MALFUNCTIONING. EVEN THOUGH I HAVE HAD THE ENTIRE FUEL PUMP ASSEMBLY REPLACED AND THE IN DASH GAUGES CHECKED, IT WILL NOT REGISTER PAST 1/4 TANK. AFTER DRIVING APPROXIMATELY 150 MILES THE GAUGE WILL SUDDENLY DROP, THE LOW FUEL LIGHT WILL COME ON. AFTER TURNING THE CAR OFF AND ON, IT WILL AGAIN READ 1/4 TAN…

Read full complaint

MY FUEL LEVEL GAUGE IS MALFUNCTIONING. EVEN THOUGH I HAVE HAD THE ENTIRE FUEL PUMP ASSEMBLY REPLACED AND THE IN DASH GAUGES CHECKED, IT WILL NOT REGISTER PAST 1/4 TANK. AFTER DRIVING APPROXIMATELY 150 MILES THE GAUGE WILL SUDDENLY DROP, THE LOW FUEL LIGHT WILL COME ON. AFTER TURNING THE CAR OFF AND ON, IT WILL AGAIN READ 1/4 TANK EVEN WHEN FULL. THE VEHICLE IS ALMOST ALWAYS IN MOTION WHEN THIS OCCURS.

NHTSA ODI #10979149

Official recalls

1

04V301000 · Fuel System, Gasoline:storage

Jun 30, 2004

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A FUEL TANK THAT DOES NOT MEET SPECIFICATION. A WELD ON THESE FUEL TANKS MAY BE INSUFFICIENT, RESULTING IN A FUEL LEAK.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL TANK, AND REPLACE IT, IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.