NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
41 reportsClear category filter47,000 miles · Apr 11, 2017
Steering
ELECTRIC POWER STEERING FAILED WHILE DRIVING ON THE HIGHWAY, WARNING DISPLAY APPEARED IN DASH AT TIME POWER STEERING WENT OUT: SERVICE POWER STEERING, DRIVE WITH CARE". CAR WAS VERY DIFFICULT TO MANEUVER ESPECIALLY AT OFF RAMP AND STREET ROADS. GM WILL NOT COVER THIS ISSUE IF OUTSIDE 36K MILES. NUMEROUS OTHER DRIVERS OF THIS M…
Read full complaint
ELECTRIC POWER STEERING FAILED WHILE DRIVING ON THE HIGHWAY, WARNING DISPLAY APPEARED IN DASH AT TIME POWER STEERING WENT OUT: SERVICE POWER STEERING, DRIVE WITH CARE". CAR WAS VERY DIFFICULT TO MANEUVER ESPECIALLY AT OFF RAMP AND STREET ROADS. GM WILL NOT COVER THIS ISSUE IF OUTSIDE 36K MILES. NUMEROUS OTHER DRIVERS OF THIS MODEL APPEAR TO BE HAVING FAILURES WHILE DRIVING: HTTP://WWW.SSFORUMS.COM/FORUM/WARRANTY-SERVICE-ISSUES/25833-POWER-STEERING-FAILURE-70.HTML". OTHER GM MODELS USING THE SAME STEERING RACK ARE CURRENTLY UNDER RECALL, NOT CHEVY SS.
NHTSA ODI #10971902
21,358 miles · Apr 5, 2017
Steering
IN THE MIDDLE OF DRIVING, IN MOTION CAN BE GOING STRAIGHT OR TURNING, AND MY POWER STEERING CUTS OUT, HAS HAPPENED 3 TIMES. I TURN CAR OFF AND BACK ON AND IT'S OK UNTIL NEXT TIME IT CUTS OUT. HAVE SERVICE APPT ON 4/6/17 BUT HAVE READ THIS HAS HAPPENED TO OTHERS.
NHTSA ODI #10970645
25,821 miles · Feb 21, 2017
Steering
POWER STEERING FAILED WHILE MAKING A RIGHT HAND TURN. VEHICLE BECAME VERY DIFFICULT TO STEER AND WOULD HAVE CAUSED AN ACCIDENT HAD THERE BEEN ONCOMING TRAFFIC. VEHICLE HAD 25,821 MILES AT THE TIME OF THE INCIDENT.
NHTSA ODI #10956052
22,019 miles · Feb 14, 2017
Steering
I WAS DRIVING TO WORK WHEN ALL OF A SUDDEN THE POWER STEERING FAILED COMPLETELY I COULD BARELY EFFECT THE CAR'S DIRECTION AT ALL. BARELY MISSED ANOTHER CAR WITH A LADY AND TWO KIDS. I WAS ABLE TO CREEP INTO A SERVICE CENTER WHERE THEY INSPECTED THE CAR. WHEN THEY RESTARTED THE CAR THE STEERING WORKED FINE. THEY SAID DEFINITELY A…
Read full complaint
I WAS DRIVING TO WORK WHEN ALL OF A SUDDEN THE POWER STEERING FAILED COMPLETELY I COULD BARELY EFFECT THE CAR'S DIRECTION AT ALL. BARELY MISSED ANOTHER CAR WITH A LADY AND TWO KIDS. I WAS ABLE TO CREEP INTO A SERVICE CENTER WHERE THEY INSPECTED THE CAR. WHEN THEY RESTARTED THE CAR THE STEERING WORKED FINE. THEY SAID DEFINITELY A CONTROLLER OR ELECTRONIC PART. I AM AFRAID TO DRIVE THE CAR FOR FEAR OF CAUSING AN ACCIDENT. I CONTACTED THE DEALER BUT HE DIDN'T SEEM THAT CONCERNED. I WILL CONTACT AGAIN. I HAVE READ ABOUT THIS ON THE INTERNET THIS AM BUT IT DOESN'T SEEM LIKE THE GOV'T. TO CONCERNED I GUESS WERE ARE GOING TO HAVE TO KILL SOMEONE FIRST.
NHTSA ODI #10954442
30,000 miles · Feb 1, 2017
Steering
STEERING GOES OUT. UPON RESTART TRAVELED OVER 500 MILES UNTIL SERVICE. ONCE SERVICE WAS DONE AT CHEVROLET, WEEKS LATER SAME PROBLEM UPON RESTART DROVE FOR LESS THAN 5 MILES AND SAME ISSUE. NOW RACK AND PINION HAS BEEN REPLACED. FIRST TIME ON STARTING SAW NOTICE IN SCREEN. 2ND AND 3RD HAPPENED WHILE CAR WAS DRIVING. *TR
NHTSA ODI #10948931
25,000 miles · Nov 9, 2016
SteeringCrash
TL* THE CONTACT OWNS A 2014 CHEVROLET SS. THE CONTACT STATED THAT THE POWER STEERING FAILED AND CAUSED A CRASH. THE CONTACT'S VEHICLE STRUCK THE BUMPER OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE DEALER DIAGNOSED THAT THE STEERING WHEEL ASSEMBLY NEEDED TO BE RE…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SS. THE CONTACT STATED THAT THE POWER STEERING FAILED AND CAUSED A CRASH. THE CONTACT'S VEHICLE STRUCK THE BUMPER OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE DEALER DIAGNOSED THAT THE STEERING WHEEL ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000.
NHTSA ODI #10925243
30,330 miles · Oct 7, 2016
Steering
POWER STEERING FAILURE WHILE DRIVING ON INTERSTATE IN STRAIGHT LINE WITH MESSAGE "SERVICE POWER STEERING, DRIVE CAREFULLY". AFTER CAR WAS STOPPED AND PARKED FOR 8 HOURS, UPON STARTING AGAIN, MESSAGE AND PROBLEM HAD DISAPPEARED. DEALER SERVICE UNABLE TO FIND PROBLEM. INDICATED NO GM BULLETINS.
NHTSA ODI #10914443
19,400 miles · Sep 28, 2016
Steering
RANDOM FAILURE OF POWER STEERING SYSTEM. WHILE DRIVING, THE CAR WILL CHIME AND THE MESSAGE "SERVICE POWER STEERING, DRIVE WITH CARE" IS DISPLAYED. AT THIS POINT THE CAR LOSES ALL POWER STEERING FUNCTION AND IS EXTREMELY DIFFICULT TO STEER. THIS HAS HAPPENED ON BOTH CITY STREETS AND MAJOR HIGHWAYS. THIS IS AN EXTREMELY DANGER…
Read full complaint
RANDOM FAILURE OF POWER STEERING SYSTEM. WHILE DRIVING, THE CAR WILL CHIME AND THE MESSAGE "SERVICE POWER STEERING, DRIVE WITH CARE" IS DISPLAYED. AT THIS POINT THE CAR LOSES ALL POWER STEERING FUNCTION AND IS EXTREMELY DIFFICULT TO STEER. THIS HAS HAPPENED ON BOTH CITY STREETS AND MAJOR HIGHWAYS. THIS IS AN EXTREMELY DANGEROUS SYSTEM FAILURE.
NHTSA ODI #10910138
59,000 miles · Sep 11, 2016
Electrical SystemSteering
IT STARTED A MONTH AGO ON MY WAY TO AN INTERVIEW I WAS ON THE I 35 HERE IN DALLAS AND THE I WAS DRIVING NORMALLY GOING MPH 60 AND I GET A MESSAGE IN THE DIC TO SERVICE THE POWER STEERING AND I LOST COMPLETE CONTROL OF THE POWER STEERING. AFTER DOING SOME RESEARCH ONLINE THERE SEEMS TO BE A RECALL WITH NUMEROUS SS OWNERS THAT HA…
Read full complaint
IT STARTED A MONTH AGO ON MY WAY TO AN INTERVIEW I WAS ON THE I 35 HERE IN DALLAS AND THE I WAS DRIVING NORMALLY GOING MPH 60 AND I GET A MESSAGE IN THE DIC TO SERVICE THE POWER STEERING AND I LOST COMPLETE CONTROL OF THE POWER STEERING. AFTER DOING SOME RESEARCH ONLINE THERE SEEMS TO BE A RECALL WITH NUMEROUS SS OWNERS THAT HAVE THE ISSUES. THE THREAD CAN BE FOUND HERE HTTP://WWW.SSFORUMS.COM/FORUM/WARRANTY-SERVICE-ISSUES/25833-POWER-STEERING-FAILURE.HTML . THERE IS A RECALL TO JUST DEGREASE THE CONNECTORS BUT THAT DOESN'T SEEM TO WORK AND PEOPLE ARE REPLACING THE STEERING GEARS WHICH HAVE A RECALL ON ANOTHER VEHICLE WHICH IS THE CAPRICE PPV.
NHTSA ODI #10905599
16,031 miles · Sep 7, 2016
Steering
ON APRIL15, 2015 I TOOK MY 2014 CHEVROLET SS, MILEAGE 6316, TO THE DEALER IN RESPONSE TO FACTORY RECALL 14804. AT THAT TIME THEY APPLIED A DIELECTETIC LUBE TO THE STEERING RACK CONNECTOR AS PER THE RECALL INSTRUCTIONS. THIS WAS TO PREVENT A SUDDEN LOSS OF POWER STEERING WHILE OPERATING THE VEHICLE. THIS CONDIDTION HAD NOT EVER O…
Read full complaint
ON APRIL15, 2015 I TOOK MY 2014 CHEVROLET SS, MILEAGE 6316, TO THE DEALER IN RESPONSE TO FACTORY RECALL 14804. AT THAT TIME THEY APPLIED A DIELECTETIC LUBE TO THE STEERING RACK CONNECTOR AS PER THE RECALL INSTRUCTIONS. THIS WAS TO PREVENT A SUDDEN LOSS OF POWER STEERING WHILE OPERATING THE VEHICLE. THIS CONDIDTION HAD NOT EVER OCCURED AT THAT TIME. ONE YEAR LATER IN APRIL 2016 THE CAR STARTED EXPERIENCING SUDDEN LOSS OF POWER STEERING AT RANDOM TIMES. THE VEHICLE DRIVERS INFORMATION CENTER STATED "SERVICE POWER STEERING, DRIVE WITH CARE". ALL POWER STEERING ASSIST WAS GONE AND STOPPING AND RESTARTING THE MOTOR WAS THE ONLY WAY TO RESTORE IT, MAYBE FOR A FEW MINUTES, MAYBE FOR THE REST OF THE DAY. THE CAR WAS THEN PARKED IN OUR GARAGE UNTIL MID AUGUST 2016. THE CAR CONTINUED THE SUDDEN LOSS OF POWER STEERING AND I TOOK THE CAR TO THE DEALER ON 9-1-2016. MILEAGE 16031. TOOK A PICTURE OF THE D.I.C. SCREEN AS EVIDENCE OF THE STEERING LOSS. DEALER STATED NO CODES WERE SET AND PERFORMED THE LUBE PROCEDURE UNDER RECALL 14804 AGAIN. I WAS TOLD TO BRING CAR BACK WITH POWER STEERING MALFUNCTIONING. MY CONCERN IS THE LOSS OF POWER STEERING DRAMATICALLY INCREASES THE EFFORT NEEDED TO STEER THE FURTHER THE WHEEL IS TURNED. IF IT WERE TO FAIL ON A CLOVERLEAF INTERSTATE ONRAMP THE EFFORT TO STEER WOULD BE VERY HIGH, COUPLED WITH THE HIGHER SPEEDS, A RECIPE FOR DISASTER. I WOULD LIKE TO HAVE THE STEERING RACK REPLACED. FIRST RECALL REPAIR PROCEDURE DIDN'T FIX THE VEHICLE, SECOND IDENTICAL REPAIR PROCEDURE SURELY WILL NOT. CONCERNS ABOUT THIS CONDITION EXIST IN NHTSA DOCUMENT ID# 10057679.
NHTSA ODI #10904409
Official recalls
9Oct 15, 2020
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV) that were previously repaired under NHTSA recall number 16V-518. The repair may not have been performed properly. The driver's seat belt tensioner cable may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: If the tensioner cable separates, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will inspect the vehicles to determine whether the new seat trim was installed and replace the trim as necessary. Dealers will also inspect and replace the pretensioner cable assembly, as necessary. Repairs will be performed free of charge. The recall began November 17, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202312100
Nov 7, 2019
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS vehicles that previously received an inspect-only remedy under recall 17V-382. Corrosion of the connector between the electric power steering module and the torque sensor connector may cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A greater steering effort would be needed to control the vehicle if power steering is lost, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the steering gear assembly, free of charge. The recall began December 27, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GM customer service at 1-586-596-1733. GM's number for this recall is N192265980.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Jun 15, 2017
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS vehicles. Corrosion of the connector between the electric power steering module and the torque sensor connector may cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A greater steering effort would be needed to control the vehicle if power steering is lost, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the steering gear assembly, replacing it as necessary, free of charge. The recall began August 2, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17248.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Jul 8, 2016
General Motors LLC (GM) is recalling certain model year 2014-2016 Chevrolet Caprice Police Pursuit vehicles manufactured May 14, 2013 through June 14, 2016, and Chevrolet SS vehicles manufactured May 15, 2013 through April 27, 2016. The driver's seat belt tensioner cable may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: If the tensioner cable separates, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will inspect the tensioner cable assembly, replacing any cable that is damaged. For vehicles that do not require a tensioner assembly replacement, a cable guide will be installed. All vehicles will receive new seat trim with a redesigned opening for the cable routing. These repairs will be performed free of charge. The recall began on November 3, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 31340.
Oct 9, 2015
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Caprice vehicles manufactured August 14, 2013, to February 3, 2014, and Chevrolet SS vehicles manufactured August 15, 2013, to February 16, 2014. The affected vehicles received replacement seat base assemblies during repair service, but during the work, the seat position target bracket may not have been transferred from the old seat to the new one. Without the seat position target bracket, the air bag may deploy at a higher intensity than necessary.
Consequence & remedy
Consequence: An air bag that deploys at a higher than intended level increases the risk of injury during a crash.
Remedy: GM will notify owners, and dealers will inspect the vehicles and, if necessary, install a seat frame equipped with a target bracket, free of charge. The recall began on December 28, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15567.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Buick Encore and Cadillac ATS; 2014 Cadillac CTS, ELR, Chevrolet Caprice and SS vehicles; and 2014-2015 Chevrolet Silverado and GMC Sierra Trucks. Due to an incomplete weld on the seat hook bracket assembly, the front seats in the affected vehicles may not stay secured in place during a high load condition such as a crash.
Consequence & remedy
Consequence: A seat that does not stay secured increases the risk of occupant injury in a vehicle crash.
Remedy: GM will notify owners, and dealers will inspect the seat hook bracket assembly weld and replace the lower seat track, as necessary, free of charge. The recall began on August 15, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14340.
Jun 27, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Chevrolet Caprice vehicles manufactured June 7, 2013, to May 29, 2014, and 2014 Chevrolet SS vehicles manufactured September 13, 2013, to March 4, 2014. In the affected vehicles, the windshield wiper motor gear teeth may strip causing the windshield wipers to become inoperative.
Consequence & remedy
Consequence: Inoperative wipers will not clear rain or snow, reducing the driver's visibility, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the wiper module assembly and replace any affected ones, free of charge. The recall began on August 22, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14295.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration