SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2003 Chevrolet C4500

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
5Owner complaints

Model-year median: 2.5

1Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
5
20033
20042
20056
2006
Compare all C4500 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Engine And Engine Cooling
3Electrical System
2Fuel System, Gasoline
1Suspension
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 3 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine And Engine Cooling. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports0 injury reports

Engine And Engine Cooling complaints

3 reports
Clear category filter
57,000 miles · Feb 22, 2006
Engine And Engine Cooling

DT*: THE CONTACT STATED WHEN DRIVING AT ANY SPEED, THE VEHICLE STALLED INTERMITTENTLY. WHEN THE IGNITION WAS TURNED OFF, THE VEHICLE WOULD RESTART WITHOUT A PROBLEM. THE DEALERSHIP REPLACED THE FUEL PUMP AND EXCHANGE PUMP, ALTHOUGH THIS HELPED THE STALLING, IT DID NOT CORRECT THE PROBLEM. THE STALLING PROGRESSIVELY GOT WORSE…

Read full complaint

DT*: THE CONTACT STATED WHEN DRIVING AT ANY SPEED, THE VEHICLE STALLED INTERMITTENTLY. WHEN THE IGNITION WAS TURNED OFF, THE VEHICLE WOULD RESTART WITHOUT A PROBLEM. THE DEALERSHIP REPLACED THE FUEL PUMP AND EXCHANGE PUMP, ALTHOUGH THIS HELPED THE STALLING, IT DID NOT CORRECT THE PROBLEM. THE STALLING PROGRESSIVELY GOT WORSE. THE DEALERSHIP IS UNABLE TO DETERMINE A PROBLEM.

NHTSA ODI #10150940

Mileage unknown · Sep 8, 2004
Electrical SystemEngine And Engine Cooling

WHILE DRIVING 60 MPH VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND HAD IT TOWED TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE TEMPERATURE SENSOR NEEDED TO BE REPLACED, AND REPLACED IT. HOWEVER, THE PROBLEM RECURRED, AND VEHICLE WAS TAKEN BACK TO THE DEALER . MECHANIC REPLACED THE COMPUTER SENSO…

Read full complaint

WHILE DRIVING 60 MPH VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND HAD IT TOWED TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE TEMPERATURE SENSOR NEEDED TO BE REPLACED, AND REPLACED IT. HOWEVER, THE PROBLEM RECURRED, AND VEHICLE WAS TAKEN BACK TO THE DEALER . MECHANIC REPLACED THE COMPUTER SENSOR, AND THE PROBLEM RECURRED AGAIN. *AK

NHTSA ODI #10091633

38,000 miles · Nov 28, 2003
Engine And Engine CoolingSuspensionCrash

CONSUMER COMPLAINED ABOUT AN ENGINE PROBLEM. IT DID NOT MAINTAIN THE THROTTLE. ENGINE WENT INTO NEUTRAL WITHOUT A CAUSE. ALSO, A SUSPENSION PROBLEM DUE TO BOLTS PLACED IN UPSIDE DOWN POSITION WHICH CAUSED VEHICLE TO FLIP. WIRES AND PLASTIC BOLT HOLDERS MELTED.*AK

NHTSA ODI #10048790

Official recalls

1

02V202000 · Suspension:rear

Jul 26, 2002

CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH 11,000 LB. REAR AXLE HAVE A CONDITION WHERE THE REAR AXLE ANCHOR PLATE MAY FRACTURE. AS THE ANCHOR PLATE FRACTURES, THERE IS AN AUDIBLE "BANG." IF THIS INDICATION OF A CONDITION REQUIRING THE DRIVER'S ATTENTION WENT UNNOTICED OR WAS IGNORED, AND UNDER CERTAIN REBOUND, BRAKING, OR CORNERING MANEUVERS, THE REAR AXLE WOULD BE FREE TO MOVE FORE AND AFT AND PROVIDE UNEXPECTED STEERING INPUTS TO THE VEHICLE.

Consequence & remedy

Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD RESULT.

Remedy: DEALERS WILL INSTALL A NEW REAR AXLE ANCHOR PLATE AND SPACER. OWNER NOTIFICATION BEGAN AUGUST 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.