IllustrationDRIVING AT 50MPH FRONT LEFT TIRE SEPARATED LUCKILY I WAS ABLE TO CONTROL VEHICLE. A SPARE WAS PUT ON-SOME MINOR DAMAGE TO TRUCK UNDERCARRIAGE. *TR
1991 Chevrolet C1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Chevrolet C1500 do not stand out strongly from the model-year median of 41.
About this comparison →How this year compares
Owner complaints by model year
Compare all C1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 39 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports1 injury reports
What owners actually said
39 reportsTL* THE CONTACT OWNS A 1991 CHEVROLET C1500. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE FRAME WAS PERFORATED DUE TO RUST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
I WAS DRIVING ON FREEWAY 65 MILES AN HOUR. THIS IS THE FIRST TIME IT HAPPENED IN 2011. MY TRUCK FELT LIKE SOMEONE LASSOED MY BUMPER. I WAS OUT OF CONTROL BUT NO ONE GOT HURT . THANK GOD! WHEN I WAS ABLE TO GET OUT AND CHECK MY TIRE, IT STILL HAD AIR IN IT BUT THE TREAD HAD SEPARATED AND WRAPPED AROUND MY REAR AXLE. TREAD WAS ST…
Read full complaint
I WAS DRIVING ON FREEWAY 65 MILES AN HOUR. THIS IS THE FIRST TIME IT HAPPENED IN 2011. MY TRUCK FELT LIKE SOMEONE LASSOED MY BUMPER. I WAS OUT OF CONTROL BUT NO ONE GOT HURT . THANK GOD! WHEN I WAS ABLE TO GET OUT AND CHECK MY TIRE, IT STILL HAD AIR IN IT BUT THE TREAD HAD SEPARATED AND WRAPPED AROUND MY REAR AXLE. TREAD WAS STILL ATTACHED TO TIRE ALSO. THE CHEVY 1990 TRUCK HAD ALMOST ROLLED. I NEVER SEEN ANYTHING LIKE IT BEFORE! I HAVE GREAT PICTURES OF THIS ! 2ND TIME I WAS ON HIGHWAY DOING 65 AND TREAD SEPARATED AGAIN. THIS IS 2013. THIS TIME TREAD DAMAGED MY REAR FENDER. I HAVE PICTURES OF THIS ALSO. TIRE STILL HAD AIR IN IT. TOTAL TREAD SEPARATION! BIG O TIRE PATHMAX 31X10 50R15LT. BIG O ISN'T BIG O ANY MORE SO I WENT TO ANOTHER BIG O AND THEY WOULD NOT REPLACE MY TIRE UNDER MY LIFETIME WARRANTY BECAUSE IT WASN'T THERE SHOP! WHAT IS THIS??!! *TR
UNEVEN FRONT BRAKE APPLICATION. MEDIUM BRAKE PRESSURE ENERGIZED RIGHT FRONT ONLY CAUSING SEVERE RIGHT STEER. HEAVY BRAKE PRESSURE ENERGIZED BOTH FRONT BRAKES ONLY TO LEAVE LEFT FRONT BRAKE LOCKED. PROBLEM OCCURRED GRADUALLY AND PROGRESSIVELY WORSENED TO DANGER LEVEL, ESPECIALLY ON WET OR LOOSE SURFACES. INSPECTION DETERMIN…
Read full complaint
UNEVEN FRONT BRAKE APPLICATION. MEDIUM BRAKE PRESSURE ENERGIZED RIGHT FRONT ONLY CAUSING SEVERE RIGHT STEER. HEAVY BRAKE PRESSURE ENERGIZED BOTH FRONT BRAKES ONLY TO LEAVE LEFT FRONT BRAKE LOCKED. PROBLEM OCCURRED GRADUALLY AND PROGRESSIVELY WORSENED TO DANGER LEVEL, ESPECIALLY ON WET OR LOOSE SURFACES. INSPECTION DETERMINED THE LEFT FRONT BRAKE HOSE SUPPORT CLAMP HAD BEEN OVER COMPRESSED IN MANUFACTURING CAUSING GRADUAL COMPRESSION OF THE INNER HYDRAULIC LINE TO THE POINT OF VIRTUAL CLOSURE. THE ONLY FLOW POSSIBLE WAS AT ELEVATED PRESSURE AND ALSO PREVENTING RETURN FLOW CAUSING SEVERE AND EXTENDED CALIPER CLAMPING PRESSURE. FAILED PART IS AVAILABLE FOR INSPECTION. *TR
INSTRUMENT PANEL DOES NOT WORK. WHEN THE TRUCK GETS HOT, THE EMERGENCY LIGHT COMES ON ,AND THE WHOLE INSTRUMENT PANEL CONTROL DOES NOT OPERATE PROPERLY. WHEN THIS HAPPENS, AND WHEN TRYING TO TURN THE PANEL ON AND OFF NOTHING COMES OFF. CONSUMER CANNOT READ THE AMOUNT OF FUEL IN TANK OR HOW FAST VEHICLE IS TRAVELING. *AK
WHILE PULLING INTO HIGHWAY DRIVESHAFT HAS BROKEN IN HALF. DEALER AND MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
MULTIPLE FAILURES. ANY IMPACT ON THE MODULE RESTARTS WINDSHIELD WIPERS.*AK
VEHICLE DIDN'T COME EQUIPPED WITH HEAD RESTS AND CONSUMER WOULD LIKE THEM TO BE ADDED TO THE VEHICLE, CONSUMER IS CONCERNED BECAUSE THE SEATS WOULD NOT PREVENT WHIPLASH OR DECAPITATION. *SLC
PE00 020 ; CONSUMER WAS TRAVELING ABOUT 35MPH ON SIDE STREET AND FELT STEERING WHEEL VIBRATING BACK AND FORTH. WHEN HE GOT HOME HE NOTICED THAT LEFT FRONT TIRE TREAD SEPARATED FROM THE RIM. FIRESTONE WILDERNESS#AT, P23575R15, #DOT VDH1. THERE WERE NO INJURIES.HE ALSO CONTACTED FIRESTONE.*AK THE TIRE TREAD SEPARATED FROM TH…
Read full complaint
PE00 020 ; CONSUMER WAS TRAVELING ABOUT 35MPH ON SIDE STREET AND FELT STEERING WHEEL VIBRATING BACK AND FORTH. WHEN HE GOT HOME HE NOTICED THAT LEFT FRONT TIRE TREAD SEPARATED FROM THE RIM. FIRESTONE WILDERNESS#AT, P23575R15, #DOT VDH1. THERE WERE NO INJURIES.HE ALSO CONTACTED FIRESTONE.*AK THE TIRE TREAD SEPARATED FROM THE CASING AND THE SIDE WALL. THERE WAS CRACKING TOO AT THE TREAD. THE CUSTOMER HAD EXPERIENCED THIS PROBLEM WITH FIRESTONE. *YH
IN MARCH, 2000, THE LEFT FRONT TIRE BEGAN TO BULDGE AND SHOW SIGNS OF TREAD SEPARATION, UPON HAVING IT INSPECTED, IT WAS DETERMINED THAT THE TIRE WAS IN FACT SEPARATING. THE TIRE WAS REPLACED AT THAT TIME. AND NOW THE RIGHT REAR TIRE IS SHOWING SIGNS OF SEPARATION AND IN CONTACTING THE FIRESTONE COMPANY ON THIS, I WAS TOLD THE T…
Read full complaint
IN MARCH, 2000, THE LEFT FRONT TIRE BEGAN TO BULDGE AND SHOW SIGNS OF TREAD SEPARATION, UPON HAVING IT INSPECTED, IT WAS DETERMINED THAT THE TIRE WAS IN FACT SEPARATING. THE TIRE WAS REPLACED AT THAT TIME. AND NOW THE RIGHT REAR TIRE IS SHOWING SIGNS OF SEPARATION AND IN CONTACTING THE FIRESTONE COMPANY ON THIS, I WAS TOLD THE TIRES ARE NOT PART OF THE RECALL AND IF I THINK THEY ARE UNSAFE THEN MAYBE I SHOULD THINK OF REPLACING THEM. UPON TELLING THEM THAT THIS IS THE SECOND TIRE THAT HAS SEPARATED I DO NOT UNDERSTAND WHY THEY WILL NOT REPLACE THESE TIRES. MY TRUCK IS PARKED BECAUSE I AM AFRAID FOR MY SAFTEY AS WELL AS OTHERS. PLEASE LET ME KNOW WHAT I CAN DO TO GET THESE REPLACED. THEY ARE UNSAFE AND JUST BECAUSE THEY WERE NOT MANUFACTED IN THE DECATUR PLANT DOES NOT MEAN THEY ARE NOT FAULTY.( DOT NUMBER: VN TIRE SIZE: P235/75R15 )
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.