NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
29 reportsClear category filter65,000 miles · Nov 19, 2025
Electrical System
The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while driving at various speeds, the vehicle lost automotive power, and the digital screen failed to display as intended. The Battery warning light was occasionally illuminated during rainy weather. The local dealer was contacted. The vehicle was not diagnosed or…
Read full complaint
The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while driving at various speeds, the vehicle lost automotive power, and the digital screen failed to display as intended. The Battery warning light was occasionally illuminated during rainy weather. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.
NHTSA ODI #11700254
Mileage unknown · Feb 3, 2024
Electrical SystemService BrakesVehicle Speed Control
I was driving 72 mph, and went to accelerate to 75 mph to set my cruise control. As soon as I stepped on the accelerator pedal, my 2022 Chevy Bolt EUV jerked violently and immediately applied braking to car to take it from 72 mph to about 30 mph within 1 second. Had someone been behind me I would have been rear ended. I was a…
Read full complaint
I was driving 72 mph, and went to accelerate to 75 mph to set my cruise control. As soon as I stepped on the accelerator pedal, my 2022 Chevy Bolt EUV jerked violently and immediately applied braking to car to take it from 72 mph to about 30 mph within 1 second. Had someone been behind me I would have been rear ended. I was able to pull over to the shoulder of the road, and put my car into park. I was unable to turn off the vehicle or shift into any gears (reverse, neutral, drive). The car displayed a warning on dash "power drive train malfunction pull over safely". There was no warning for the sudden deceleration and is a serious safety risk and concern.
NHTSA ODI #11569705
Mileage unknown · Dec 27, 2023
Electrical SystemForward Collision AvoidanceService Brakes
About 1 month ago I picked up my daughter from school. Just as we exited the parking lot, there was nothing in front and the brakes came on and the car turned off and would not restart for a few minutes. The same day, we were on the way home I was traveling about 35mph. All of a sudden the brakes came on again. This time there …
Read full complaint
About 1 month ago I picked up my daughter from school. Just as we exited the parking lot, there was nothing in front and the brakes came on and the car turned off and would not restart for a few minutes. The same day, we were on the way home I was traveling about 35mph. All of a sudden the brakes came on again. This time there was nothing in front but many cars behind, so I floored the accelerator the car tires screeched. I was less than a mile from home and made it without incident. The dealership is unable to reproduce or review the logs because the vehicle stopped logging everything since December 4th. The car is in my driveway and I don't trust it can safely be driven. The dealership is not helpful by telling me to just monitor the situation and bring it in if it happens again. I am seeing on the internet that there are many people experiencing this exact problem.
NHTSA ODI #11562166
200 miles · Oct 24, 2023
Electrical System
The contact owns a 2022 Chevrolet Bolt EV. The contact stated while attempting to charge the vehicle, the charging system failed to charge the vehicle adequately. The contact stated that shortly after beginning to charge the vehicle, the vehicle overheated after 30 minutes, and the charging light turned from blue to red. The con…
Read full complaint
The contact owns a 2022 Chevrolet Bolt EV. The contact stated while attempting to charge the vehicle, the charging system failed to charge the vehicle adequately. The contact stated that shortly after beginning to charge the vehicle, the vehicle overheated after 30 minutes, and the charging light turned from blue to red. The contact then had to disconnect the charger. The vehicle was taken to the dealer who was unable to determine the cause of the failure with the charging unit. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 200.
NHTSA ODI #11551557
Mileage unknown · Sep 20, 2023
Air BagsElectrical System
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 23V567000 (Air Bags, Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was ma…
Read full complaint
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 23V567000 (Air Bags, Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11545631
Mileage unknown · Sep 9, 2023
Electrical SystemPower TrainService Brakes
While waiting to make a left turn, the car lurched forward about a foot and went into park.It would not shift into any gear. A warning briefly showed up on drivers display which said DO NOT SHIFT UNTIL ???? RESETS. I turned car off but it immediately came back on automatically, and for twenty minutes I was in the intersection bl…
Read full complaint
While waiting to make a left turn, the car lurched forward about a foot and went into park.It would not shift into any gear. A warning briefly showed up on drivers display which said DO NOT SHIFT UNTIL ???? RESETS. I turned car off but it immediately came back on automatically, and for twenty minutes I was in the intersection blocking traffic (police called to protect me from traffic). On drivers display a car symbol with exclamation point through the car was showing. After twenty minutes I turned it off again and it stayed off until I turned it on. The display of car with exclamation point was still showing. I could then shift into another gear and drive home less than a mile. When I checked car later car with exclamation point display was gone. Everything seemed. I was driving in one pedal mode.
NHTSA ODI #11543576
Mileage unknown · Sep 2, 2023
Electrical SystemPower Train
Complete transmission failure shortly after seeing "Service Transmission" message in 2022 Chevy Bolt EV Drivers Information Center. When message first appeared selected option to dismiss message and continued to drive as normal. After turning vehicle off and then back on the message appeared again and all attempts to change ge…
Read full complaint
Complete transmission failure shortly after seeing "Service Transmission" message in 2022 Chevy Bolt EV Drivers Information Center. When message first appeared selected option to dismiss message and continued to drive as normal. After turning vehicle off and then back on the message appeared again and all attempts to change gear into neutral, reverse, or drive resulting in all doors unlocking and the vehicle shifting back into park. Was unable to put car in neutral and move vehicle off road therefore blocking traffic until a tow truck arrived 90 minutes later.
NHTSA ODI #11542304
Mileage unknown · Jun 27, 2023
Electrical System
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repa…
Read full complaint
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11529205
Mileage unknown · Apr 13, 2023
Electrical SystemSeat BeltsStructure
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) and 22V930000 (Structure, Seat Belts) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a rea…
Read full complaint
The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) and 22V930000 (Structure, Seat Belts) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11516832
6,612 miles · Mar 23, 2023
Electrical SystemEnginePower Train
The contact owns a 2022 Chevrolet Bolt EV. The contact stated while pulling out of a parking lot, the vehicle stalled, failed to shift into gear and would not turn off. A towing agent disconnected the battery and the vehicle turned off. The vehicle was then towed to the dealer where it was diagnosed that the service disconnect f…
Read full complaint
The contact owns a 2022 Chevrolet Bolt EV. The contact stated while pulling out of a parking lot, the vehicle stalled, failed to shift into gear and would not turn off. A towing agent disconnected the battery and the vehicle turned off. The vehicle was then towed to the dealer where it was diagnosed that the service disconnect fuse had blown. The vehicle was repaired; however, the failure reoccurred while driving. The vehicle was towed to the dealer where the engine control module (ECM) was replaced, however, the failure reoccurred upon starting the vehicle. The vehicle was towed to the dealer. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened; however, the manufacturer had not followed up or returned the contact's calls. The failure mileage was approximately 6,612.
NHTSA ODI #11513502
Official recalls
7Oct 31, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery Thermal:management:software
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.
Electrical System:propulsion System:traction Battery
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.
Jun 27, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles that were previously remedied under recall number 21V-650. The advanced diagnostic software may have been incorrectly installed and fail to detect defective battery modules, possibly resulting in a battery fire.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall the advanced diagnostic software, free of charge. Owner notification letters were mailed on August 1, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's numbers for this recall are N242443000 and N242443002.
Dec 14, 2023
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Aug 10, 2023
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
Consequence & remedy
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.
Dec 15, 2022
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Aug 20, 2021
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Defective battery modules will be replaced by GM, free of charge. Owner notification letters were mailed on October 1, 2021 and June 23, 2023. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. This recall is an expansion of NHTSA recall 21V-560. GM's number for this recall is N212345940.
Jul 8, 2021
General Motors, LLC. (GM) is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles. One of the two fasteners that secure the driver's frontal air bag to the steering wheel may be missing or improperly tightened.
Consequence & remedy
Consequence: An improperly installed air bag may not deploy properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace as necessary, the driver-side air bag fasteners. If the fasteners cannot be tightened properly, the air bag assembly will be replaced. All repairs will be performed free of charge. Owner notification letters were mailed on July 29, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212340860.
Additional source detail variants (2)
Air Bags:critical Fasteners
General Motors, LLC. (GM) is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles. One of the two fasteners that secure the driver's frontal air bag to the steering wheel may be missing or improperly tightened.
Consequence: An improperly installed air bag may not deploy properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace as necessary, the driver-side air bag fasteners. If the fasteners cannot be tightened properly, the air bag assembly will be replaced. All repairs will be performed free of charge. Owner notification letters were mailed on July 29, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212340860.
Air Bags:frontal
General Motors, LLC. (GM) is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles. One of the two fasteners that secure the driver's frontal air bag to the steering wheel may be missing or improperly tightened.
Consequence: An improperly installed air bag may not deploy properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace as necessary, the driver-side air bag fasteners. If the fasteners cannot be tightened properly, the air bag assembly will be replaced. All repairs will be performed free of charge. Owner notification letters were mailed on July 29, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212340860.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration