IllustrationHD surround camera system is faulty. Upon placing vehicle in drive mode, front view image disappears and is replaced by a pink colored screen. This fault occurs intermittently, and is an important safety issue.
2020 Chevrolet Bolt Ev
Owner reports · Recalls · Investigations
More warning signs than most Bolt Ev years
Owner complaints for the 2020 Chevrolet Bolt Ev are substantially higher than the model-year median of 77.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bolt Ev years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 22 of 174 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 94 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports4 fire reports0 injury reports
What owners actually said
174 reportsMy backup camera started working intermittently for about a year and now has just stopped working completely. Searching online, this is a very widespread issue with Bolt EV and EUV owners, happening as early as immediately after the car was purchased.
The rear/front camera sometimes stop working or froze and have to turn off the car, to reset, usually happens when it rains
Pulls to the right when accelerating too much. Even after alignment.
The cameras for the 360° view, front to sides and back, keep going out. It's been a repair now five times and it still came back. The dealership is running out of ideas of what to do to fix this. I think it's just a known issue that they can't seem to fix. The main issue is the front camera goes out completely and then on mine, …
Read full complaint
The cameras for the 360° view, front to sides and back, keep going out. It's been a repair now five times and it still came back. The dealership is running out of ideas of what to do to fix this. I think it's just a known issue that they can't seem to fix. The main issue is the front camera goes out completely and then on mine, the left side camera goes out and is just black where the front camera will be green and not functioning. I think the module that processes data isn't properly made to handle the amount of video inputs coming in and it bugs out. It seems that it's worse when the temperature swing is too much. Currently it's the temperature of hot above 90° the car gets very warm obviously.
The reverse camera (and all cameras) is no longer working. This is a required safety feature and thousands of Bolt owners have reported this on Chevy forums and Reddit groups.
The steering wheel does not return to the center on its own and keep stuck in which direction it is turned. The steering wheel also produces types of clunking noises when the car is standing or at a slow speed, and if you move the steering wheel left and right, it gives clunk clang clank clunk noise. it is very much a safety iss…
Read full complaint
The steering wheel does not return to the center on its own and keep stuck in which direction it is turned. The steering wheel also produces types of clunking noises when the car is standing or at a slow speed, and if you move the steering wheel left and right, it gives clunk clang clank clunk noise. it is very much a safety issue and can create a big accident. I have not taken it to the dealer, but will make an appointment to see what the dealer says. It’s been like this for over a month but now it’s getting a little louder
The contact owns a 2020 Chevrolet Bolt EV. The contact stated while driving approximately 4 MPH and exiting the driveway, the check engine warning light and the check gear shifter warning light was illuminated. The contact stated that the vehicle stalled. The contact was unable to restart the vehicle. The contact had the vehicle…
Read full complaint
The contact owns a 2020 Chevrolet Bolt EV. The contact stated while driving approximately 4 MPH and exiting the driveway, the check engine warning light and the check gear shifter warning light was illuminated. The contact stated that the vehicle stalled. The contact was unable to restart the vehicle. The contact had the vehicle towed to a local dealer, where it was diagnosed, and the dealer was unable to duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact was able to drive the vehicle to the same dealer who diagnosed the vehicle and determined that the negative 12V battery cable had short circuited and needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure. The failure mileage was approximately 25,000.
See attached document for complaint
I narrowly escaped a home and vehicle fire when my vehicle charging port received extensive damage from a Mustart SAE J1772 Level 2 EVSE Portable Electric Vehicle Charger. The charging plug overheated and experienced meltdown. The Mustart unit became so hot that my vehicle charging port charred and fused to the Mustart charging …
Read full complaint
I narrowly escaped a home and vehicle fire when my vehicle charging port received extensive damage from a Mustart SAE J1772 Level 2 EVSE Portable Electric Vehicle Charger. The charging plug overheated and experienced meltdown. The Mustart unit became so hot that my vehicle charging port charred and fused to the Mustart charging plug. The charging head became very brittle, cracked exposing seals, and leaked oil down the vehicle charging port. Even though the charging head is now melted and broken, the charger does not register a fault, and still shows a green light if plugged into the wall. My first warning of a problem was the smell of burning plastic, oil leaking and what looked like smoke coming from the charging head. I immediately unplugged the charger from the wall, but could not remove the charging head from the vehicle charging port because it was fused to the car. I tried to shift the vehicle out of Park and into neutral to move the vehicle away from my home, but the vehicle would not shift with the plug still attached. Even though unplugged from the wall, the Bolt kept beeping, indicating an issue with the charger/port. Fearing a physical short in the charging circuitry of the vehicle, the burning smell and potential for fire, I forcefully removed the charger from the vehicle by pulling on the charging handle with full human stregnth until separated. The plastic parts of both the charger and charging port were burnt and broken. My Chevy Bolt was repaired by a licensed technician at the dealer, who blamed me for the charging fault and damages. GM alleged the damage I caused to the charging unit during removal was pre-existing, causing a loose connection and short circuit. GM refused to repair the damaged charging port under warranty, claiming user error and abuse. I sent a request for refund and reimbursement of damages to Mustart on 8/05/2024 and will update this complaint after their official response.
Official recalls
824V812000 · Electrical System:propulsion System:traction Battery; Electrical System:propulsion System:traction Battery Thermal:management:software
Oct 31, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery Thermal:management:software
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.
Electrical System:propulsion System:traction Battery
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.
24V481000 · Electrical System:propulsion System:traction Battery
Jun 27, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles that were previously remedied under recall number 21V-650. The advanced diagnostic software may have been incorrectly installed and fail to detect defective battery modules, possibly resulting in a battery fire.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall the advanced diagnostic software, free of charge. Owner notification letters were mailed on August 1, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's numbers for this recall are N242443000 and N242443002.
23V845000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 14, 2023
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
22V930000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 15, 2022
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
21V650000 · Electrical System:propulsion System:traction Battery
Aug 20, 2021
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Defective battery modules will be replaced by GM, free of charge. Owner notification letters were mailed on October 1, 2021 and June 23, 2023. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. This recall is an expansion of NHTSA recall 21V-560. GM's number for this recall is N212345940.
20V811000 · Seat Belts; Seat Belts:critical Fasteners
Dec 23, 2020
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.
Consequence & remedy
Consequence: If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
Additional source detail variants (2)
Seat Belts:critical Fasteners
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.
Consequence: If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
Seat Belts
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.
Consequence: If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
20V808000 · Service Brakes, Hydraulic:foundation Components:disc:caliper
Dec 22, 2020
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV vehicles. These vehicles may have an improperly cast front left brake caliper that can fracture during a high-pressure braking event.
Consequence & remedy
Consequence: If a brake caliper fractures and brake fluid is lost, the vehicle may experience reduced brake performance, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the casting lot number on the front left brake caliper and replace it if necessary, free of charge. The recall began January 29, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202321400.
20V184000 · Latches/locks/linkages:doors:latch
Mar 26, 2020
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Bolt EV vehicles. The door-handle cable inside the rear doors may be too long, allowing contact with the window when it is opened, possibly damaging the cable. A damaged cable may cause the rear door to open unintentionally when the rear window is opened. Additionally, it may cause the rear inside door handle to not work.
Consequence & remedy
Consequence: If the rear door opens while driving, or the door handle fails to open the rear door, there is an increased risk of injury to the rear passengers.
Remedy: GM will notify owners, and dealers will replace the rear inside door-handle cables, free of charge. The recall began April 17, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is A202298320.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE20016 · Electric Vehicle Battery Fires
Opened Oct 9, 2020 · Closed Feb 7, 2022
Status: closed (inferred from source dates) · Electrical System:propulsion System; Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Additional source detail variants (6)
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800