IllustrationCOUPLE WEEK AFTER BOUGHT, COMPLETE BRAKE FAILURE. COST 11OO TO FIX.FEB. 26 LOOK OUT DOOR IN MORNING AND AIR BAGS EXPLODED AND CAUSE ALL ELECTRIC SYSTEM TO GO OUT. BRAKE WAS ON STREET, AIR BAG WAS IN DRIVEWAY AT HOME.
2004 Chevrolet Blazer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Chevrolet Blazer do not stand out strongly from the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
625–50K
650–75K
375–100K
5100–150K
2150K+
39 reports with mileage · 11 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports0 fire reports4 injury reports
Service Brakes complaints
4 reportsBRAKE LINE CORRODED THROUGH AND LOST REAR BRAKES DURING STOP--DEALER UNABLE TO REPAIR PROPERLY---PART NO LONGER AVAILABLE THRU GEN MOTORS--WENT OUT DURING STOP ON HIGHWAY --NO DAMAGE TO VEHICLE OR PEOPLE--GROSELY LONGER DISTANCE TO STOP SAFELY.
AFTER REPLACING BRAKE PADS ON VEHICLE I WAS PUMPING BRAKES TO BLEED OUT AIR IN THE LINES AND THE PEDAL WENT TO THE FLOOR. UPON INSPECTION THE BRAKE LINE RUPTURED DUE TO EXCESSIVE CORROSION. REQUIRED 100% REPLACEMENT OF ALL BRAKE LINES. *TR
BRAKE PEDAL WENT TO FLOOR VERY SLOWLY. REPAIRED BRAKES WITH ALL NEW COMPONENTS; ROTORS, PADS, CALIPERS, NEW BRAKE FLUID. BLED BRAKES AND PEDAL IS STILL VERY SPONGY AND PEDAL WILL STILL GO DOWN TO FLOOR AFTER STOPPING. CAR WILL NOT MOVE IF YOU HOLD THE PEDAL DOWN. FOUND SEVERAL COMPLAINTS ON LINE ABOUT SPONGY BRAKES ON CHEVROLET …
Read full complaint
BRAKE PEDAL WENT TO FLOOR VERY SLOWLY. REPAIRED BRAKES WITH ALL NEW COMPONENTS; ROTORS, PADS, CALIPERS, NEW BRAKE FLUID. BLED BRAKES AND PEDAL IS STILL VERY SPONGY AND PEDAL WILL STILL GO DOWN TO FLOOR AFTER STOPPING. CAR WILL NOT MOVE IF YOU HOLD THE PEDAL DOWN. FOUND SEVERAL COMPLAINTS ON LINE ABOUT SPONGY BRAKES ON CHEVROLET CARS.IS THERE A PROBLEM THAT I CAN NOT FIND FOR THESE CARS? *TR
Official recalls
104V132000 · Equipment:other:labels
Mar 18, 2004
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: SOME OF THESE VEHICLES INCLUDE INCORRECT STATEMENTS ON ONE OF THE AIR BAG WARNING LABELS.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JUNE 4, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.