2003 Chevrolet Blazer

TL*THE CONTACT OWNS A 2003 CHEVROLET BLAZER. THE CONTACT STATED THE VEHICLE EXPERIENCED AN ONGOING FAILURE IN WHICH THE FUEL GAUGE CONSTANTLY DISPLAYED AN IMPROPER READING. THE CONTACT ALSO STATED DUE TO THE FAILURE THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS IN WHICH THE FAILURE WAS NEVER DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 60,000. THE VIN WAS UNAVAILABLE.

MY 2003 CHEVY BLAZER HAS HAD A FAULTY FUEL GAUGE SINCE THE VEHICLE WAS PURCHASED. IT WAS TAKEN INTO MORAN CHEVROLET IN CLINTON TOWNSHIP MI ONCE FOR WARRANTY REPAIRS BUT THE PROBLEM WAS NEVER FIXED. SERVICE REP INFORMED ME THAT IT WAS CAUSED BY A BAD VEHICLE GROUND. PROBLEM STILL PERSISTS TO THIS DAY. THE ONLY WAY I CAN AVOID RUNNING OUT OF GAS IS TO RESET THE TRIP ODOMETER EVERY TIME I FILL-UP. *TR

SINCE PURCHASE OF VEHICLE IN 10/2006, WE HAD HESITATION AND STALLING PROBLEMS. WITH A 2003 CHEVY BLAZER. WE HAD SEVERAL FULL TUNE-UPS, CATALYTIC CONVERTER REPLACEMENT (UPON THE ADVICE OF A DEALERSHIP), FUEL RELAY REPLACEMENT, FUEL FILTER REPLACEMENT ON TWO OCCASIONS, AND THE REMOVAL OF TWO (2) FACTORY RAGS THAT HAD BEEN LEFT IN THE FUEL TANK DURING THE MANUFACTURING OF THE VEHICLE. FINALLY THE REPLACEMENT OF THE FUEL PUMP IN JULY 2008 -- TOTAL COST OVER $3,000. CONSTANT HESITATION WITH THE VEHICLE, AND AT LEAST A FEW DOZEN STALLING EPISODES WITH A COUPLE OF THEM HAPPENING ON THE GARDEN STATE PARKWAY IN NEW JERSEY DURING BUSINESS TRIPS. UPON PURCHASE OF REPLACEMENT FUEL PUMP, WE FOUND A PRODUCT BULLETIN IN THE BOX STATING "NEW IMPROVED CONNECTOR AND PIGTAIL FOR GM FUEL PUMP MODELS". IT WENT ON TO EXPLAIN THAT MANY GM VEHICLES FROM 1988 TO 2005 HAVE ELECTRICAL CONNECTORS ON THE FUEL PUMP MODULE THAT MAY BECOME LOOSE OVER TIME DUE TO VIBRATION, LEADING TO FAULTY, HIGH-RESISTANCE CONNECTIONS. THE SYMPTOMS -- BURNED OR MELTED CONNECTORS AND PINS -- LEAD TO A VOLTAGE DROP SITUATION WHERE LOW OR NO VOLTAGE CAN CAUSE THE MODULE TO STOP PUMPING. THE SOLUTION WAS THAT THE OEM DESIGN CONNECTOR WAS REPLACED. WE WROTE GO GM ASKING FOR REIMBURSEMENT FOR AT LEAST THE FUEL PUMP AND INSTALLATION AND STATED THAT WE BELIEVE THAT OTHER OWNERS OF THESE VEHICLES SHOULD BE IMMEDIATELY MADE AWARE OF THE SITUATION (WITH MORE THAN A PRODUCT BULLETIN ON THE INSIDE OF THE NEW FUEL PUMP BOX) AS THE STALLING PROBLEM COULD HAVE AND COULD VERY WELL RESULT IN AN ACCIDENT WITH OR WITHOUT INJURIES/DEATH WHEN THE VEHICLES JUST STALL WITHOUT WARNING WHENEVER AND WHERE EVER IT FEELS LIKE IT. GM RESPONDED TO MY LETTER THAT THEY WOULD BE TAKING NO ACTION -- NO REIMBURSEMENT TO ME AND NO NOTIFICATION TO ANY OTHER OWNERS OF THE PROBLEM. I TOLD THEM THIS WAS NOT ACCEPTABLE AND THAT I WOULD PURSUE THE MATTER AS FAR AS I COULD TO SAVE INJURIES AND POSSIBLY LIVES. *TR

2003 CHEVY BLAZER FUEL PUMP MODULE. CONSUMER FEELS THAT OWNERS OF AFFECTED VEHICLES SHOULD BE AWARE OF THIS BULLETIN. *NJ THE CONSUMER STATED THERE HAD BEEN A HESITATION AND STALLING PROBLEM WITH THE VEHICLE SINCE IT WAS PURCHASED. THE CONSUMER STATED SHE WAS NOT TOLD THERE WAS AN ELECTRICAL CONNECTOR PROBLEM ON THE FUEL PUMP. THE FUEL PUMP WAS REPLACED AND THE HESITATION AND STALLING HAS BEEN RESOLVED. *JB

I HAVE A 02 BLAZER AND I BELIEVE THE FUEL GAUGE IS NOT WORKING PROPERLY. AFTER I HAVE GONE ONLY ABOUT 40 MILES ON A FULL TANK OF GAS THE GAUGE SHOWS ? FULL. CAN THAT BE CORRECT? IN THE OWNER?S MANUAL IT STATES THAT I AM TO HAVE AN 18-GALLON FUEL TANK. WITH AN AVERAGE OF 20 MPG ON THE HIGHWAY IT SHOULD GO TO ? TANK AT ABOUT 90 MILES.