NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
54 reportsClear category filterMileage unknown · Sep 14, 2004
Service Brakes, HydraulicCrash
GOING ABOUT 30 MPH TO ENTER FREEWAY ON ONRAMP, I PUT ON MY BRAKES AS TRAFFIC WAS SLOWING. TRAFFIC THEN SLOWED QUICKLY AND I PUSHED BRAKES DOWN HARDER AND PEDAL WENT TO THE FLOOR AND CAR DIDNT STOP CAUSING ME TO HIT THE BACK FOR THE CAR IN FRONT OF ME. I CONTACTED THE DEALERSHIP AND WAS TOLD THAT WAS A PROBLEM WITH ABS BRAKES …
Read full complaint
GOING ABOUT 30 MPH TO ENTER FREEWAY ON ONRAMP, I PUT ON MY BRAKES AS TRAFFIC WAS SLOWING. TRAFFIC THEN SLOWED QUICKLY AND I PUSHED BRAKES DOWN HARDER AND PEDAL WENT TO THE FLOOR AND CAR DIDNT STOP CAUSING ME TO HIT THE BACK FOR THE CAR IN FRONT OF ME. I CONTACTED THE DEALERSHIP AND WAS TOLD THAT WAS A PROBLEM WITH ABS BRAKES AT SLOWER STOPPING SPEEDS AND THAT NOTHING COULD BE DONE TO CORRECT IT AND THAT NOTHING WOULD SHOW ON THE COMPUTER. I CALLED A BRAKE SHOP AND WAS BASICLY TOLD THE SAME THING. THAT ABS BRAKES AT SLOW SPEEDS ARE A PROBLEM, THEY COULD PUT IT ON A MACHINE TO CHECK CODES BUT WERE 99.9% SURE AS USUAL IT WOULD SHOW NOTHING.
NHTSA ODI #10090974
70,000 miles · Apr 20, 2004
Engine And Engine CoolingService Brakes, HydraulicSteering
WHILE DRIVING AT HIGHWAY SPEED THE VEHICLE STALLED WITHOUT WARNING AND COASTED TO THE SIDE OF THE ROAD. THE CAUSE HAS NOT BEEN DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM IN ADDITION, CONSUMER EXPERIENCED VIBRATING WHEN STOPPING. DEALER PERFORMED FRONT AND REAR BRAKE SERVICE BY REPLACING WORN OUT PAD…
Read full complaint
WHILE DRIVING AT HIGHWAY SPEED THE VEHICLE STALLED WITHOUT WARNING AND COASTED TO THE SIDE OF THE ROAD. THE CAUSE HAS NOT BEEN DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM IN ADDITION, CONSUMER EXPERIENCED VIBRATING WHEN STOPPING. DEALER PERFORMED FRONT AND REAR BRAKE SERVICE BY REPLACING WORN OUT PADS AND ROTORS. DEALER ALSO MADE REPAIRS ON LOWER BALL JOINTS, PITMAN AND IDLER ARM ASSEMBLY. *LA
NHTSA ODI #10064837
Mileage unknown · Apr 9, 2004
Electrical SystemExterior LightingService Brakes, Hydraulic
CONSUMER FEEL THERE IS A SERIOUS DEFECT WITH THE COMPUTER SYSTEM THAT DELIVERS ERROR CODES ON HIS 2000 CHEVROLET BLAZER. (NAR) *PH PROBLEMS AS FOLLOWS WARNING LIGHTS FLASHING ON, DEFECTIVE ALTERNATOR, BATTERY, AND REPLACED BRAKE PADS. *CB
NHTSA ODI #10066956
40,000 miles · Jan 15, 2004
EquipmentFuel System, GasolineService Brakes, Hydraulic
1. SECUNDAIRY AIRPUMP 2. MULTIFUNCTION SWITCH (INITIAL RECALL NEVER REC'D, ONLY REIMBURSED FOR $218)
NHTSA ODI #10069329
55,000 miles · Jan 15, 2004
Power TrainService Brakes, Hydraulic
WITHIN 2 MONTHS OF PURCHASE, THE BRAKES WENT OUT, THE ROTORS WERE PEELING LIKE HUNGRY MAN BISCUITS, REPLACEMENT OF ALL 4 ROTORS AND SHOES WERE DONE, ABS STILL NOT WORKING. LOCAL CHEVY DEALER UNSURE OF PROBLEM. CHECK ENGINE LIGHT CONTINUES ON, CHEVY DEALER DOES NOT KNOW WHY. NOW AT 7 1/2 MONTHS OF OWNERSHIP, TORQUE CONVERTER IS &…
Read full complaint
WITHIN 2 MONTHS OF PURCHASE, THE BRAKES WENT OUT, THE ROTORS WERE PEELING LIKE HUNGRY MAN BISCUITS, REPLACEMENT OF ALL 4 ROTORS AND SHOES WERE DONE, ABS STILL NOT WORKING. LOCAL CHEVY DEALER UNSURE OF PROBLEM. CHECK ENGINE LIGHT CONTINUES ON, CHEVY DEALER DOES NOT KNOW WHY. NOW AT 7 1/2 MONTHS OF OWNERSHIP, TORQUE CONVERTER IS "COMING APART" ACCORDING TO AAMCO. IT HAS A TERRIBLE WHIN AND WE ARE HAVING IT LOOKED AT BY A LOCAL TRANSMISION SHOP TODAY (8/26/03). I FEEL THAT THE DEALERSHIP THAT SOLD ME THIS SUV, I AM THE SECOND OWNER, SHOULD HAVE NOTICED SOME OF THIS HAPPENING OR STARTING TO HAPPEN AT THE TIME OF PURCHASE.
NHTSA ODI #10069012
34,000 miles · Dec 3, 2003
Service Brakes, Hydraulic
REAR BRAKES WERE MAKING A LIGHT GRINDING NOISE. UPON INSPECTION OF THE BRAKES BY THE MECHANIC, THEY NOTICED THAT THE REAR BRAKES/ FRONT BRAKE ROTORS, AND PADS WORE OUT PREMATURELY. *AK
NHTSA ODI #10049941
34,695 miles · Oct 8, 2003
Electrical SystemFuel System, GasolineLatches/locks/linkages
THE FUEL PUMP,LINE AND TANK ARE FAULTY AT 35000 MILES. I BOUGHT IT AS A USED CAR FROM SANTA ANA HYUNDAI WHO AGREED TO FIX THE FUEL PUMP BUT DID NOT. THE TRANSMISSION IS NOT CHANGING GEARS PROPERLY, IT WOULD NOT START WHEN I TURNED IT OFF TO GET GAS ON 9-26-03, THE LEFT FRONT END IS POPPING WITH A LOUD NOISE,THE BRAKES ARE NOT …
Read full complaint
THE FUEL PUMP,LINE AND TANK ARE FAULTY AT 35000 MILES. I BOUGHT IT AS A USED CAR FROM SANTA ANA HYUNDAI WHO AGREED TO FIX THE FUEL PUMP BUT DID NOT. THE TRANSMISSION IS NOT CHANGING GEARS PROPERLY, IT WOULD NOT START WHEN I TURNED IT OFF TO GET GAS ON 9-26-03, THE LEFT FRONT END IS POPPING WITH A LOUD NOISE,THE BRAKES ARE NOT ANTILOCK BRAKES,IT FEELS AS IF I AM HITTING METAL WHEN I STOP HARD,THE PANEL LIGHTS WOULD FLICKER, LIGHTS ON DASH BOARD WHEN FLASH WHEN I HAD SEATBELT ON. I HAD A CHEVROLET DEALERSHIP FIX THE MINOR THINGS. THE BATTERY CABLE WAS LOOSE AND THEY OILED THE JOINTS TO STOP THE SQUEAK. THE DEALER REFUSED TO FIX THE FUEL PUMP WHICH IS UNSAFE AND DEMAND I PAY HIM MONEY THAT IS ALREADY ABOVE THE PRICE OF THIS CAR. I AM PAYING $14,000 PLUS FOR A 2000 CHEVROLET BLAZER WITH A FAULTY FUEL PUMP.THE DOOR ENTRY WILL NOT PROPERLY TAKE IN THE KEY TO OPEN THE DOOR.THE GAUGE METERS WERE DANCING BACK AND FORTH AND NOT PROPERLY READING THE FUEL.IT WAS A RENTAL CAR BEFORE I BOUGHT IT SO I HAD NO REAL HISTORY OF RECALLS OR MECHANICAL REPORTS. *LA
NHTSA ODI #10041489
Mileage unknown · Sep 5, 2003
Engine And Engine CoolingService Brakes, HydraulicSuspension
THE SUSPENSION ON THE VEHICLE...THE CONTROL ARM UPPER AND LOWER BALL JOINTS AND THE SENSORS FOR THE BAS BRAKES ALL WENT AT ONCE...ALSO THE GASOLINE SENSORS IN THE VEHICLE..THE GAS AMOUNT NEVER REGISTERS AND THE NEEDLE FLIPS BACK AND FORTH AND I HAVE RESEARCHED SIMILIAR REPORTS ON THE NET AND HAVE FOUND THAT ALL THESE ISSUES ARE …
Read full complaint
THE SUSPENSION ON THE VEHICLE...THE CONTROL ARM UPPER AND LOWER BALL JOINTS AND THE SENSORS FOR THE BAS BRAKES ALL WENT AT ONCE...ALSO THE GASOLINE SENSORS IN THE VEHICLE..THE GAS AMOUNT NEVER REGISTERS AND THE NEEDLE FLIPS BACK AND FORTH AND I HAVE RESEARCHED SIMILIAR REPORTS ON THE NET AND HAVE FOUND THAT ALL THESE ISSUES ARE A MAJOR FREQUENTLY OCCURING PROBLEM WITH THE VEHICLES... I OWN A 2000 CHEVY BLAZER...I FEEL THAT THE MANUFACTURER OF THIS VEHICLE SHOULD BE FIXING THIS PROBLEMS...I HAVE ALREADY PAID FOR THE BALL JOINTS AND UPPER/LOWER ARM AND SENSOR TO BE FIXED AT A MASSIVE COST TO ME OF OVER 1000.00 THE VEHICLE IS CONSTANTLY HAVING TO HAVE REPAIRS DONE SOME OF WHICH ARE DUE TO NORMAL WEAR AND TEAR BUT FOR ALL KINDS OF SENSORS TO BE GOING A TRUCK IS RIDICULOUS..I AM ALSO AS OF A WEEK AGO EXPERIENCING PROBLEMS WITH THE DOOR LOCKS...THE FUSE FOR THAT EQUIPMENT BLOWS ON A REGUALR BASIS..I HAVE PAID FOR VEHICLE DIAGNOSTICS THROUGHT THE PORTSMOUTH NH CHEVY DEALER AND THEY HAVE FOUND ALL KINDS OF OTHER MAJOR PROBLEMS WITH THIS VEHICLE..THE COST OF THE VEHICLE WAS 18000 AND BY NEXT YEAR I WILL PROBABLY HAVE SPENT $6-7000 TRYING TO FIX THIS VEHICLE. *AK
NHTSA ODI #10037292
83,805 miles · Aug 22, 2003
Electrical SystemPower TrainSeats
WHILE DRIVING 25 MPH THE TRANSMISSION FAILED. THE DEALER WAS NOTIFIED ABOUT 7 MONTHS AGO BUT THEY COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK THE DEALER WAS NOTIFIED OF THE SHRUDDERING AND SLIPPAGE OF THE TRANSMISSION AT 23863. THE FRONT DIFFERENTIAL PINION SEAL LEAKED, THE CHECK LIGHT WAS REPLACED DUE TO THE MALFUNCT…
Read full complaint
WHILE DRIVING 25 MPH THE TRANSMISSION FAILED. THE DEALER WAS NOTIFIED ABOUT 7 MONTHS AGO BUT THEY COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK THE DEALER WAS NOTIFIED OF THE SHRUDDERING AND SLIPPAGE OF THE TRANSMISSION AT 23863. THE FRONT DIFFERENTIAL PINION SEAL LEAKED, THE CHECK LIGHT WAS REPLACED DUE TO THE MALFUNCTIONING SWITCH, THE BRAKE LIGHT HAD BECOME INOPERATIVE DUE TO AN OPEN CIRCUIT, THE HEATING SEAT WAS INOPERATIVE, THERE WAS A RATTLE IN RIGHT FRONT SUSPENSION, THE TRANSMISSION HAD NO REVERSE, AND THERE WAS HARD SHIFTING INTO THE FORWARD GEARS. *SCC
NHTSA ODI #10022306
Mileage unknown · Aug 7, 2003
Service Brakes, Hydraulic
ON TWO SEPARATE OCCASIONS THE BRAKE FLEX LINES FAILED. THE FIRST TIME THE RIGHT BRAKE FLEX LINED FAILED. THE SECOND TIME THE BRAKE FLEX LINES FAILED ON BOTH FRONT CALIPERS. THE CONSUMER CONTACTED THE MANUFACTURER AND WAS TOLD THAT THERE WERE NO PROBLEM OR DEFECTS REPORTED THEREFORE NO RECALL OR WARRANTY WAS ISSUED. *PH *NLM
NHTSA ODI #10033588
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration