IllustrationBOTH FRONT SEATS THE RECLINER ASSEMBLY HAS BROKEN OFF IN SPRING OF 2006. CURRENTLY NOT REPAIRED. NOW IN FEBRUARY OF 2008 THE HEATER CORE HAS GONE BAD FOR THE SECOND TIME. FIRST REPLACED IN SUMMER 2005 AND CURRENTLY ABOUT TO BE REPLACED AGAIN. *TR
2000 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2000 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
6325–50K
8550–75K
4175–100K
51100–150K
15150K+
270 reports with mileage · 319 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports7 fire reports25 injury reports
Seats complaints
49 reportsON BOTH FRONT SEATS,THE HANDLES TO ADJUST THE UPRIGHT POSITION HAVE BROKEN COMPLETELY OFF OF THE SEATS.
THE HANDLE THAT ALLOWS YOU TO RECLINE THE SEAT BROKE OFF FLUSHED WITH THE SEAT, THIS HAPPENED TO BOTH THE DRIVER AND PASSENGER SEATS IN JUNE 2005. THE HOOD WILL NOT POP UP WHEN THE LEVER WAS PULLED UNTIL ONE BANGED ON THE GRILL OR THE HOOD IN CERTAIN SPOTS, WHICH JUST STARTED IN MARCH OF 2007. THE GAS MILEAGE DROPPED FRO…
Read full complaint
THE HANDLE THAT ALLOWS YOU TO RECLINE THE SEAT BROKE OFF FLUSHED WITH THE SEAT, THIS HAPPENED TO BOTH THE DRIVER AND PASSENGER SEATS IN JUNE 2005. THE HOOD WILL NOT POP UP WHEN THE LEVER WAS PULLED UNTIL ONE BANGED ON THE GRILL OR THE HOOD IN CERTAIN SPOTS, WHICH JUST STARTED IN MARCH OF 2007. THE GAS MILEAGE DROPPED FROM 20 MPG TO 16 MPG WITHIN 6 MONTHS. THE BACK GLASS STUCK AND WAS HARD TO OPEN, STARTED IN 2006. WHEN TURNING ON THE AIR CONDITIONER (A/C ) THE CAR HAD NO POWER, I HAVE TO TURN IT OFF WHEN ACCELERATING ON THE INTERSTATE OR ON HILLS. IF THE CRUISE CONTROL WAS SET IT KICKED OFF WHEN THE A/C WAS ON. WHEN I NEEDED TO STOP QUICKLY THE BRAKES FAILED, AND FELT A GRINDING SENSATION THROUGH THE PEDAL, BUT THE MECHANIC CHANGED THE BRAKES AND CHECKED THE ROTORS, BUT HASN'T FOUND ANY PROBLEM. SUSPECTED A DEFECT SOMEWHERE IN THE BRAKE SYSTEM\ AS OF 2005. THE FAN KICKED ON ALL THE TIME, EVEN WHEN THE ENGINE WAS COLD, AND IN WINTER WHEN FIRST STARTING. ONE MECHANIC TOLD ME THAT IN MANY BLAZERS THE CATALYTIC CONVERTER BROKE OFF IN THE MUFFLER, WHICH HAD TO BE REPLACED. HAD BEEN TOLD THIS HAPPENED SO MUCH THAT MOST PEOPLE LEFT THEM OFF. TOO MANY OTHER PROBLEMS TO MENTIONED. ALSO, THE HORN WORKED ONLY WHEN IT WANTED TO, PROBLEM IN THE STEERING WHEEL. *AK
FUEL GAUGE NOT WORKING WHEN 1/2 TANK FUEL LEVEL. SEAT LEVER LETS SEAT SLIDE ALL THEY WAY BACK WHILE DRIVING. *TR
I HAVE BAD SEAT ACCESSORIES, IF I HADN'T UNPLUGGED THE CIRCUIT UNDER THE SEAT,THE SEAT WOULD MOVE ME BACK AND FORTH WHILE I WAS DRIVING. I SEE THERE ARE MANY COMPLAINTS ON THIS SUBJECT. ALSO THE FUEL GAUGE PROBLEM IS VERY INCONVENIENT TO SAY THE LEAST. *NM
OWNS A 2000 CHEVROLET BLAZER ZR2 WITH 68000 MILES. THE HEATER BLOWS COLD AIR ONLY. THE ALTERNATOR HAS BEEN REPLACED AT LEAST TWICE. I REPLACED IT ONCE, AND PREVIOUS OWNER REPLACED IT ONCE . BATTERY HAS BEEN REPLACED AT LEAST TWICE. ALL BALL JOINTS REPLACED AT LEAST ONCE TO MY KNOWLEDGE. FUEL GAUGE BROKE BEFORE 50000 …
Read full complaint
OWNS A 2000 CHEVROLET BLAZER ZR2 WITH 68000 MILES. THE HEATER BLOWS COLD AIR ONLY. THE ALTERNATOR HAS BEEN REPLACED AT LEAST TWICE. I REPLACED IT ONCE, AND PREVIOUS OWNER REPLACED IT ONCE . BATTERY HAS BEEN REPLACED AT LEAST TWICE. ALL BALL JOINTS REPLACED AT LEAST ONCE TO MY KNOWLEDGE. FUEL GAUGE BROKE BEFORE 50000 MILES. SEAT HANDLE ON PASSENGER'S SIDE BROKEN BEFORE 50000 MILES. TAILGATE WON'T OPEN. PASSENGER SIDE WINDSHIELD WIPER ONLY MOVES HALF THE TIME. THAT IS ALL THAT I CAN RECALL RIGHT NOW.*AK
THE DRIVER'S SEAT BACK ADJUSTMENT LEVER BROKE OFF AT THE ROD CONNECTING IT. , NO ADJUSTING COULD BE DONE. THE PART WAS REPAIRED, AND A NEW HANDLE HAD TO BE ORDERED, BECAUSE CHEVROLET DECIDEDR ROD, MADE OUT OF A HEAVIER METAL, WHICH WOULDN'T FIT THE OLD LEVER. THE RESULTING CHARGES WERE $76.35 FOR THE RECLINER, $8.37 FOR THE HA…
Read full complaint
THE DRIVER'S SEAT BACK ADJUSTMENT LEVER BROKE OFF AT THE ROD CONNECTING IT. , NO ADJUSTING COULD BE DONE. THE PART WAS REPAIRED, AND A NEW HANDLE HAD TO BE ORDERED, BECAUSE CHEVROLET DECIDEDR ROD, MADE OUT OF A HEAVIER METAL, WHICH WOULDN'T FIT THE OLD LEVER. THE RESULTING CHARGES WERE $76.35 FOR THE RECLINER, $8.37 FOR THE HANDLE, AND $86.40 FOR LABOR. THERE ARE JUST OVER 59,000 MI. ON THIS 2000 BLAZER.*AK
I HAVE MULTIPLE COMPLAINTS, THE GAS GAUGE ON MY VEHICLE STOP WORKING AND I RAN OUT OF GAS IN THE MIDDLE OF THE STREET WHEN I REALIZED PROBLEM 2 THE REAR BRAKE LIGHTS AND HAZARD LIGHTS DO NOT WORK. THE OTHER PROBLEM IS THE VEHICLE STALLS, AND WHEN IT FINALLY TAKE OFF, THE CAR JERKS AND THE DRIVER SEAT MOVES/SLIDES BACK FROM THE H…
Read full complaint
I HAVE MULTIPLE COMPLAINTS, THE GAS GAUGE ON MY VEHICLE STOP WORKING AND I RAN OUT OF GAS IN THE MIDDLE OF THE STREET WHEN I REALIZED PROBLEM 2 THE REAR BRAKE LIGHTS AND HAZARD LIGHTS DO NOT WORK. THE OTHER PROBLEM IS THE VEHICLE STALLS, AND WHEN IT FINALLY TAKE OFF, THE CAR JERKS AND THE DRIVER SEAT MOVES/SLIDES BACK FROM THE HINGES WHICH CAUSED ME TO NOT BE ABLE TO REACH MY BREAKS AND RUN INTO A CURB. ALSO THE DRIVER SIDE DOOR STICKS AND IS DIFFICULT TO OPEN. LASTLY THE WHEEL BARING AND BALL JOINTS HAVE GONE BAD TWICE AND THE CAR HAS LESS THEN 75000 MILES ON IT. I CALLED GM CUSTOMER SERVICE DEPARTMENT AND EXPLAINED ALL OF MY CONCERNS AND WAS TOLD THEY WE NOT AWARE OF ANY NATIONWIDE PROBLEM AND THERE WAS NOTHING THEY COULD DO EXCEPT FIX THE HAZARD LIGHT MALFUNCTION. I RESEARCHED ON THE NET AND FOUND MANY MANY PEOPLE COMPLAINING OF THE SAME CONCERNS I HAVE. *JB
I HAVE HAD NUMEROUS PROBLEMS WITH MY 2000 CHEVY BLAZER LS 4X4. UNDER WARRANTY THE DEALER REPLACED THE OIL LINES BY THE OIL FILTER, WHOLE SEAT MECHANISM, DRIVER SIDE WINDOW MOTOR, REAR SHOCK. THEY ALSO FIXED MY HOOD RATTLE AFTER 5 VISITS TO THE DEALER AND I TOLD THEM WHAT WAS WRONG THE FIRST TIME IT WENT IN. SINCE THEN AT 40…
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH MY 2000 CHEVY BLAZER LS 4X4. UNDER WARRANTY THE DEALER REPLACED THE OIL LINES BY THE OIL FILTER, WHOLE SEAT MECHANISM, DRIVER SIDE WINDOW MOTOR, REAR SHOCK. THEY ALSO FIXED MY HOOD RATTLE AFTER 5 VISITS TO THE DEALER AND I TOLD THEM WHAT WAS WRONG THE FIRST TIME IT WENT IN. SINCE THEN AT 40,000 MILES THE DRIVER SIDE WHEEL BEARING WENT OUT AND HAD IT REPLACED AND AT THE SAME TIME HAD THE FUEL PUMP REPLACED SINCE THAT WENT OUT ALSO. AT 50,000 MILES THE SAME ONE WENT OUT AGAIN AND HAD IT REPLACED. NOW AT 68,000 MILES THE PASSENGER SIDE WHEEL BEARING IS BAD. ALSO ON MY FIRST WHEEL BEARING REPLACEMENT, THEY TOLD ME THE BALL JOINTS WERE VERY LOOSE AND SHOULD THINK ABOUT REPLACING THOSE ALSO. THESE THINGS SHOULD NEVER BE GOING WRONG WITH SUCH LOW MILES. FROM WHAT I AM READING ON THE WEB AND HEARING FROM THE DEALERS, THIS IS A VERY FREQUENT PROBLEM THAT CHEVY WILL NOT RECALL AND TAKE RESPONSIBILITY. I SURE AM HAPPY THAT I HAVEN'T HAD A WHEEL FALL OFF AND KILL SOMEONE YET. *JB
CONSUMER WAS INSIDE THE PARKED VEHICLE, ADJUSTED THE DRIVER'S SIDE SEAT AND SEAT LEVER SHEARED OFF. DRIVER 'S SEAT FAILED TO MOVE BACK AND FORTH ON ITS OWN. CONSUMER CONTACTED TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC REPAIRED THE PART. BUT THIS PROBLEM RECURRED, AND HAD NOT BEEN RESOLVED. CONSUMER CONTACTED …
Read full complaint
CONSUMER WAS INSIDE THE PARKED VEHICLE, ADJUSTED THE DRIVER'S SIDE SEAT AND SEAT LEVER SHEARED OFF. DRIVER 'S SEAT FAILED TO MOVE BACK AND FORTH ON ITS OWN. CONSUMER CONTACTED TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC REPAIRED THE PART. BUT THIS PROBLEM RECURRED, AND HAD NOT BEEN RESOLVED. CONSUMER CONTACTED THE DEALER, WHO INFORMED CONSUMER THAT THE WARRANTY EXPIRED. CONSUMER WAS RESPONSIBLE FOR PAYMENT FOR PARTS AND LABOR. *AK WHILE ADJUSTING THE SEAT THE LATCH THAT GOES UP/DOWN BROKE THE SECOND TIME. CONSUMER PAID $100.00 DEDUCTIBLE TO GET IT REPAIRED. WARRANTY EXPIRED. *AK
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.