NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
84 reportsClear category filterMileage unknown · Dec 3, 2005
Fuel System, OtherPower Train
I HAVE A 2000 BLAZER WITH 58,000 MILES AND THE FUEL GAUGE DOES NOT WORK PROPERLY. I HAVE HEARD DEALERS AND MECHANICS SAY THAT IT IS COMMON PROBLEM WITH CHEVROLET. I WOULD LIKE TO KNOW IF THEY PLAN TO ADDRESS THE ISSUE. ALSO, MY LOCKING REAR DIFFERENTIAL DOES NOT WORK. MY BROTHER HAD IT REPLACED TWICE UNDER WARRANTY ON HIS 20…
Read full complaint
I HAVE A 2000 BLAZER WITH 58,000 MILES AND THE FUEL GAUGE DOES NOT WORK PROPERLY. I HAVE HEARD DEALERS AND MECHANICS SAY THAT IT IS COMMON PROBLEM WITH CHEVROLET. I WOULD LIKE TO KNOW IF THEY PLAN TO ADDRESS THE ISSUE. ALSO, MY LOCKING REAR DIFFERENTIAL DOES NOT WORK. MY BROTHER HAD IT REPLACED TWICE UNDER WARRANTY ON HIS 2004 Z71.*JB
NHTSA ODI #10144359
38,000 miles · Sep 22, 2005
Power Train
BEGAN WITH LOUD UNDERCARRIAGE NOISE WHEN SHIFTING INTO SECOND. NOW TRUCK WILL NO LONGER SHIFT INTO 2ND OR REVERSE. ONLY 39,000 ORIGINAL MILES ON THIS ONE OWNER TRUCK. NOT AN ELECTRICAL OR FLUID PROBLEM. *NM
NHTSA ODI #10137375
70,000 miles · Jul 28, 2005
Power Train
ON THE WAY BACK FROM A WEEKEND CAMPING TRIP WE STOPPED FOR LUNCH. WHEN WE RETURNED TO THE VEHICLE TO LEAVE THERE WAS A GRINDING NOISE AND THEN A WHIRLING NOISE AND THE REVERSE GEAR WENT OUT ON THE TRANSMISSION. WHEN WE GOT HOME AND I CALLED AROUND I FOUND THAT THIS WAS A COMMON PROBLEM WITH THIS VEHICLE. *NM
NHTSA ODI #10130385
74,250 miles · Jul 21, 2005
Power Train
1. CHEVY BLAZER - SHIFTS HARD FROM 1ST TO 2ND 2. REVERSE QUIT WORKING 3. NOT REPAIRED YET, NEEDS NEW TRANSMISSION
NHTSA ODI #10129539
58,000 miles · Jun 21, 2005
Electrical SystemPower Train
I PURCHASED MY 2000 BLAZER LS 2DR 4X4 WITH 58000 MILES. AT SPEEDS AROUND 65-70, IT VIBRATES PRETTY HARSHLY. I HAVE BRAND NEW TIRES, BREAKS, AND MY U-JOINTS AND BEARINGS HAVE BEEN INSPECTED AND FOUND TO BE FINE. STILL HAVE VIBRATION. I HAVE NOTICED VIA THE INTERNET THAT THIS IS A KNOWN PROBLEM WITH BLAZER'S AND IT IS JUST A D…
Read full complaint
I PURCHASED MY 2000 BLAZER LS 2DR 4X4 WITH 58000 MILES. AT SPEEDS AROUND 65-70, IT VIBRATES PRETTY HARSHLY. I HAVE BRAND NEW TIRES, BREAKS, AND MY U-JOINTS AND BEARINGS HAVE BEEN INSPECTED AND FOUND TO BE FINE. STILL HAVE VIBRATION. I HAVE NOTICED VIA THE INTERNET THAT THIS IS A KNOWN PROBLEM WITH BLAZER'S AND IT IS JUST A DEFECT IN THE WAY THE DRIVETRAIN WAS BUILT. I FEEL THAT THIS PROBLEM SHOULD BE INVESTIGATED AND REPAIRED BY GM. ALSO AT 58000 MILES I HAD TO REPLACE THE ALTERNATER. I SPOKE WITH THE PERSON WHO I BOUGHT THE VEHICLE FROM AND THEY SAID THAT THEY HAD REPLACED IT ONCE ALSO, THEREFORE THIS WOULD BE THE 3RD ALTERNATER IN UNDER 60000 MILES.
NHTSA ODI #10126116
72,000 miles · May 14, 2005
Electrical SystemEngine And Engine CoolingFuel System, Other
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN …
Read full complaint
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN NOT BE FIXED; CALLED CHEVROLET AND WAS TOLD TO TAKE IT BACK TO DEALER AND PAY THEM TO REEVALUATE THE PROBLEM; ) SAFTY ISSUES: BALL JOINTS NEED TO BE REPLACED;GAS GAUGE SENDING UNIT DOESN'T WORK;;DIFFERENTIAL IS LEAKING AND PLUG CONNECTED TO THIS NEEDS TO BE DRILLED OUT AND RETHREADED TO FIND OUT HOW BAD THE LEAK IS; WINDSHIELD WIPER ON DRIVER'S SIDE LOOSE AND FLIPS OFF TO THE LEFT OF THE WINDSHIELD IN HEAVY RAIN AND SNOW; ELECTRICAL HARNASS NEEDS TO BE REPLACED; ENGINE INSOLATION PEALING OFF UNDER HOOD; ENGINE LIGHT ON CONTINUALLY; CAR STALLS INTERMITANTLY(FIRST TIME IT HAPPENED, WAS TOLD THE ENGINE HAD OVERHEATED); AT EVERY START UP, ENGINE STAYS IN NUETRAL (HAS NO EXCELLERATOR POWER)THEN CATCHES AFTER ABOUT THREE MINUTES); WORK DONE: THERMOSTAT HOSES REPLACED;DISTRIBUTOR REPLACED;SPARK PLUG WIRES AND SPARK PLUGS REPLACED; SEPENTINE BELT REPLACED; PART BETWEEN THE AXLE AND THE U JOINTS NEEDED TO BE REPLACED; OIL LEAK FIXED;FUEL INJECTOR REPLACED; I HAVE NO IDEA WHAT WILL GO WRONG WHEN; IT'S LIKE PLAYING RUSSIAN RULLETT WHILE DRIVING; HAVE RENTED VEHICLE TWICE; WILL ALSO NEED TO RENT VEHICLE FOR CROSS COUNTRY ROAD TRIP NEXT WEEK; WILL NOT RISK DRIVING THIS CAR; (INCIDENT DATE: FIRST INCIDENT-DAY ESTIMATED)
NHTSA ODI #10120916
40,000 miles · Apr 6, 2005
Power Train
IN A 2000 CHEVROLET BLAZER, 40000 MILES. 4 WHEEL DRIVE FRONT DIFFERENTIAL ACTUATOR FAILED TO ENGAGE AND WAS LOCKED IN 4 LOW GEARING. UPON INSPECTION IT WAS DETERMINED THAT THE ACTUATOR HAD CORRODED TO THE POINT THAT IT NEED TO BE REPLACED. THE QUOTE FROM THE DEALER WAS OVER $500 FOR REPLACEMENT PART. DEALER AND MANUFACTURER RE…
Read full complaint
IN A 2000 CHEVROLET BLAZER, 40000 MILES. 4 WHEEL DRIVE FRONT DIFFERENTIAL ACTUATOR FAILED TO ENGAGE AND WAS LOCKED IN 4 LOW GEARING. UPON INSPECTION IT WAS DETERMINED THAT THE ACTUATOR HAD CORRODED TO THE POINT THAT IT NEED TO BE REPLACED. THE QUOTE FROM THE DEALER WAS OVER $500 FOR REPLACEMENT PART. DEALER AND MANUFACTURER REPRESENTATIVES MADE COMMENTS REGARDING THE FREQUENCY OF SAID PROBLEM WHEN QUESTIONED.*AK
NHTSA ODI #10116464
58,000 miles · Mar 15, 2005
Power Train
THE 4 WHEEL DRIVE SERVICE LIGHT WOULD ILLUMINATE WHILE DRIVING. WHEN THIS OCCURRED IT PREVENT THE 4 WHEEL DRIVE FROM BEING ENGAGE. THE DEALER WAS NOTIFIED. THE DEALER INFORMED THE CONSUMER THAT PART WAS NOT COVERED UNDER A RECALL. *NM *NM
NHTSA ODI #10107358
72,000 miles · Feb 14, 2005
Power Train
I WAS DRIVING DOWN THE ROAD WHEN MY CAR MADE A POP SOUND AND WOULD NOT ACCELERATE. I PULLED INTO A GAS STATION AND WENT TO LEAVE AND HAD NO REVERSE. HARD TO SHIFT FROM 1ST TO 2ND. THE CAR ONLY HAS 72000 MILES ON IT.*AK
NHTSA ODI #10110514
50,000 miles · Dec 29, 2004
Power Train
I WAS DRIVING TO WORK WHEN ALL OF A SUDDEN A HEARD A LOUD POP. THEN MY VEHICLE WOULD NOT ACCELERATE. I GOT TO WORK AND MY VEHICLE WOULD NOT GO IN REVERSE. I CALL MY MECHANIC AND HAD MY VEHICLE TOWED. IT WAS MY TRANSMISSION THAT WENT AND IT ONLY HAS 50K MILES ON IT. IT COST ME 1,400 FOR THE TRANSMISSION,84.00 FOR THE TOW AND 102.…
Read full complaint
I WAS DRIVING TO WORK WHEN ALL OF A SUDDEN A HEARD A LOUD POP. THEN MY VEHICLE WOULD NOT ACCELERATE. I GOT TO WORK AND MY VEHICLE WOULD NOT GO IN REVERSE. I CALL MY MECHANIC AND HAD MY VEHICLE TOWED. IT WAS MY TRANSMISSION THAT WENT AND IT ONLY HAS 50K MILES ON IT. IT COST ME 1,400 FOR THE TRANSMISSION,84.00 FOR THE TOW AND 102.00 FOR THE RENTAL. *NM
NHTSA ODI #10104701
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration