NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Other complaints
35 reportsClear category filter50,000 miles · Jan 25, 2006
Electrical SystemEngine And Engine CoolingFuel System, Other
OWNS A 2000 CHEVROLET BLAZER ZR2 WITH 68000 MILES. THE HEATER BLOWS COLD AIR ONLY. THE ALTERNATOR HAS BEEN REPLACED AT LEAST TWICE. I REPLACED IT ONCE, AND PREVIOUS OWNER REPLACED IT ONCE . BATTERY HAS BEEN REPLACED AT LEAST TWICE. ALL BALL JOINTS REPLACED AT LEAST ONCE TO MY KNOWLEDGE. FUEL GAUGE BROKE BEFORE 50000 …
Read full complaint
OWNS A 2000 CHEVROLET BLAZER ZR2 WITH 68000 MILES. THE HEATER BLOWS COLD AIR ONLY. THE ALTERNATOR HAS BEEN REPLACED AT LEAST TWICE. I REPLACED IT ONCE, AND PREVIOUS OWNER REPLACED IT ONCE . BATTERY HAS BEEN REPLACED AT LEAST TWICE. ALL BALL JOINTS REPLACED AT LEAST ONCE TO MY KNOWLEDGE. FUEL GAUGE BROKE BEFORE 50000 MILES. SEAT HANDLE ON PASSENGER'S SIDE BROKEN BEFORE 50000 MILES. TAILGATE WON'T OPEN. PASSENGER SIDE WINDSHIELD WIPER ONLY MOVES HALF THE TIME. THAT IS ALL THAT I CAN RECALL RIGHT NOW.*AK
NHTSA ODI #10148536
Mileage unknown · Dec 3, 2005
Fuel System, OtherPower Train
I HAVE A 2000 BLAZER WITH 58,000 MILES AND THE FUEL GAUGE DOES NOT WORK PROPERLY. I HAVE HEARD DEALERS AND MECHANICS SAY THAT IT IS COMMON PROBLEM WITH CHEVROLET. I WOULD LIKE TO KNOW IF THEY PLAN TO ADDRESS THE ISSUE. ALSO, MY LOCKING REAR DIFFERENTIAL DOES NOT WORK. MY BROTHER HAD IT REPLACED TWICE UNDER WARRANTY ON HIS 20…
Read full complaint
I HAVE A 2000 BLAZER WITH 58,000 MILES AND THE FUEL GAUGE DOES NOT WORK PROPERLY. I HAVE HEARD DEALERS AND MECHANICS SAY THAT IT IS COMMON PROBLEM WITH CHEVROLET. I WOULD LIKE TO KNOW IF THEY PLAN TO ADDRESS THE ISSUE. ALSO, MY LOCKING REAR DIFFERENTIAL DOES NOT WORK. MY BROTHER HAD IT REPLACED TWICE UNDER WARRANTY ON HIS 2004 Z71.*JB
NHTSA ODI #10144359
140,000 miles · Nov 29, 2005
Fuel System, GasolineFuel System, OtherSuspension
BALL JOINTS UPPER AND LOWER REPLACED AT 40K AND 100K MILES. WILL BE NEEDING TO BE REPLACED AGAIN VERY SOON AT 140K MILES. THE REPLACEMENT AT 40K WAS A TOTAL FAILURE OF PASSENGER SIDE BALL JOINTS TO WIT: VEHICLE WAS INCAPACITATED AS WHEEL WAS LEFT 'BENT'. FUEL GAUGE FLUCTUATED WILDLY IF LESS THAN 1/3 TANK OF GAS. FUEL PU…
Read full complaint
BALL JOINTS UPPER AND LOWER REPLACED AT 40K AND 100K MILES. WILL BE NEEDING TO BE REPLACED AGAIN VERY SOON AT 140K MILES. THE REPLACEMENT AT 40K WAS A TOTAL FAILURE OF PASSENGER SIDE BALL JOINTS TO WIT: VEHICLE WAS INCAPACITATED AS WHEEL WAS LEFT 'BENT'. FUEL GAUGE FLUCTUATED WILDLY IF LESS THAN 1/3 TANK OF GAS. FUEL PUMP FAILED. *JB
NHTSA ODI #10143941
Mileage unknown · Nov 21, 2005
Exterior LightingFuel System, OtherSteering
RADLEY CHEVROLET DID NOT PROVIDE US WITH A RECALL NOTICE ON BRAKE LIGHTS NOT WORKING. WE HAVE HAD PROBLEMS WITH OUR 2000 CHEVROLET BLAZER FROM THE START. WE HAVE BEEN NOW TOLD THAT THE IDLER ARM ON THE CAR IS A SAFETY HAZARD. WE ALSO HAD THE FUEL GAUGE GO OUT. HOW OFTEN DO THESE COMPONENTS GO OUT. CAN YOU TELL ME ANYTHING A…
Read full complaint
RADLEY CHEVROLET DID NOT PROVIDE US WITH A RECALL NOTICE ON BRAKE LIGHTS NOT WORKING. WE HAVE HAD PROBLEMS WITH OUR 2000 CHEVROLET BLAZER FROM THE START. WE HAVE BEEN NOW TOLD THAT THE IDLER ARM ON THE CAR IS A SAFETY HAZARD. WE ALSO HAD THE FUEL GAUGE GO OUT. HOW OFTEN DO THESE COMPONENTS GO OUT. CAN YOU TELL ME ANYTHING ABOUT THE IDLER ARM AND IS THERE ANY RECALLS FOR THIS ITEM. *JB
NHTSA ODI #10143327
93,400 miles · Jul 8, 2005
Fuel System, Other
THE FUEL GUAGE IN MY 2000 CHEVY BLAZER STOPPED WORKING CAUSING ME TO RUN OUT OF FUEL WITH MY 4 YEAR OLD SON IN THE VEHICLE. I ALSO HAD A 1996 CHEVY BLAZER AND THE FUEL GUAGE STOPPED WORKING (MY FATHER NOW OWNS THIS VEHICLE). I CONTACTED CHEVROLET AND THEY CLAIMED THAT THEY HAVE NO REPORTS OF FUEL GUAGES THAT STOP WORKING. A V…
Read full complaint
THE FUEL GUAGE IN MY 2000 CHEVY BLAZER STOPPED WORKING CAUSING ME TO RUN OUT OF FUEL WITH MY 4 YEAR OLD SON IN THE VEHICLE. I ALSO HAD A 1996 CHEVY BLAZER AND THE FUEL GUAGE STOPPED WORKING (MY FATHER NOW OWNS THIS VEHICLE). I CONTACTED CHEVROLET AND THEY CLAIMED THAT THEY HAVE NO REPORTS OF FUEL GUAGES THAT STOP WORKING. A VERY CLOSE FRIEND OF MINE WHO WORKED FOR CHEVROLET FOR 20 YEARS TOLD ME THAT THIS IS NOT TRUE. APPARENTLY THE FINGERS ON THE SENDING UNIT WERE FALLING OFF CAUSING THE GUAGE TO NOT WORK.
NHTSA ODI #10127877
Mileage unknown · Jul 1, 2005
Fuel System, Other
DT: CONTACT STATES THE FUEL GAUGE IS NOT CONSISTENT IN THE READINGS. IT DOES NOT MEASURE THE GASOLINE CORRECTLY. A MECHANIC STATED THERE WAS A PROBLEM WITHIN THE ELECTRONIC WIRING THAT DEALS WITH THE COMPUTER TO THE FUEL GAUGE. THE VEHICLE HAS NOT BEEN SERVICED FOR THIS PROBLEM.*AK
NHTSA ODI #10127232
55,000 miles · May 15, 2005
Fuel System, Other
THE GAS GAUGE FLUCTUATES FROM E - F WHEN MY TANK IS ONLY HALF FULL. THE ONLY WAY I KNOW HOW FAR I CAN DRIVE IS TO ZERO OUT THE TRIP ODOMETER WHEN I FILL THE GAS TANK. THIS VEHICLE HAD HAS APPROXIMATELY 55K MILES ON IT - TOO FEW FOR THIS KIND OF PROBLEM.
NHTSA ODI #10120939
72,000 miles · May 14, 2005
Electrical SystemEngine And Engine CoolingFuel System, Other
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN …
Read full complaint
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN NOT BE FIXED; CALLED CHEVROLET AND WAS TOLD TO TAKE IT BACK TO DEALER AND PAY THEM TO REEVALUATE THE PROBLEM; ) SAFTY ISSUES: BALL JOINTS NEED TO BE REPLACED;GAS GAUGE SENDING UNIT DOESN'T WORK;;DIFFERENTIAL IS LEAKING AND PLUG CONNECTED TO THIS NEEDS TO BE DRILLED OUT AND RETHREADED TO FIND OUT HOW BAD THE LEAK IS; WINDSHIELD WIPER ON DRIVER'S SIDE LOOSE AND FLIPS OFF TO THE LEFT OF THE WINDSHIELD IN HEAVY RAIN AND SNOW; ELECTRICAL HARNASS NEEDS TO BE REPLACED; ENGINE INSOLATION PEALING OFF UNDER HOOD; ENGINE LIGHT ON CONTINUALLY; CAR STALLS INTERMITANTLY(FIRST TIME IT HAPPENED, WAS TOLD THE ENGINE HAD OVERHEATED); AT EVERY START UP, ENGINE STAYS IN NUETRAL (HAS NO EXCELLERATOR POWER)THEN CATCHES AFTER ABOUT THREE MINUTES); WORK DONE: THERMOSTAT HOSES REPLACED;DISTRIBUTOR REPLACED;SPARK PLUG WIRES AND SPARK PLUGS REPLACED; SEPENTINE BELT REPLACED; PART BETWEEN THE AXLE AND THE U JOINTS NEEDED TO BE REPLACED; OIL LEAK FIXED;FUEL INJECTOR REPLACED; I HAVE NO IDEA WHAT WILL GO WRONG WHEN; IT'S LIKE PLAYING RUSSIAN RULLETT WHILE DRIVING; HAVE RENTED VEHICLE TWICE; WILL ALSO NEED TO RENT VEHICLE FOR CROSS COUNTRY ROAD TRIP NEXT WEEK; WILL NOT RISK DRIVING THIS CAR; (INCIDENT DATE: FIRST INCIDENT-DAY ESTIMATED)
NHTSA ODI #10120916
Mileage unknown · Mar 15, 2005
Fuel System, Other
I JUST PURCHASED A 2000 BLAZER ZR2, WHEN THE GAS GAUGE HITS 3/4 TANK, THE GAUGE WILL BOUNCE BACK AND FORTH FROM EMPTY TO FULL. I NEVER KNOW HOW MUCH GAS I REALLY HAVE, WHICH COULD CAUSE A REAL SAFETY ISSUE TO MYSELF, LET ALONE THE HUNDREDS OF DOLLARS IT WOULD TAKE TO REPLACE THE FAULY SENSOR. I'VE FOUND THAT LOTS OF GM CONSUME…
Read full complaint
I JUST PURCHASED A 2000 BLAZER ZR2, WHEN THE GAS GAUGE HITS 3/4 TANK, THE GAUGE WILL BOUNCE BACK AND FORTH FROM EMPTY TO FULL. I NEVER KNOW HOW MUCH GAS I REALLY HAVE, WHICH COULD CAUSE A REAL SAFETY ISSUE TO MYSELF, LET ALONE THE HUNDREDS OF DOLLARS IT WOULD TAKE TO REPLACE THE FAULY SENSOR. I'VE FOUND THAT LOTS OF GM CONSUMERS ALSO HAVE THIS PROBLEM, WHICH I FEEL GM SHOULD BE RESPONSIBLE FOR REPLACEMENT. MY VEHICLE ONLY HAS 56000 MILES.*AK
NHTSA ODI #10114104
25,000 miles · Jan 6, 2005
Fuel System, Other
2000 CHEVY BLAZERFUEL GUAGE DOESN'T REGISTER PROPERLY BELOW 1/2 FULL. OFTEN FLUCTUATES BELOW 1/2 TANK FROM EMPTY TO FULL OR IN BETWEEN. ONLY 25000 MILES, JUST OUT OF WARRANTY (EXPIRED JUNE 2004). *AK
NHTSA ODI #10105841
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration