IllustrationCAMPAIGN# 01V364000. THE DEALER IS TELLING ME THE RECALL WAS ALREADY DONE ON MY VEHICLE IN 2003 BUT I HAVE THE SAME PROBLEM NOW AGAIN IN 2007. THEY SAY I HAVE NO RECOURSE. AREN'T THEY RESPONSIBLE TO FIX THIS SINCE IT'S A KNOWN PROBLEM? KOON CHEVROLET 410-931-8600 *JB
2000 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2000 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
6325–50K
8550–75K
4175–100K
51100–150K
15150K+
270 reports with mileage · 319 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports7 fire reports25 injury reports
Exterior Lighting complaints
79 reportsTL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE TWO REAR BRAKE LIGHTS ABOVE THE HITCH FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. THE DEALER STATED THAT THE BRAKE LIGHTS WERE ALREADY REPAIRED ACCORDING TO THE MECHANIC'S RECORDS. SHE STATED THAT HER VEHICLE IS UNDER RECALL NUMBER 01V364000 (E…
Read full complaint
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE TWO REAR BRAKE LIGHTS ABOVE THE HITCH FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. THE DEALER STATED THAT THE BRAKE LIGHTS WERE ALREADY REPAIRED ACCORDING TO THE MECHANIC'S RECORDS. SHE STATED THAT HER VEHICLE IS UNDER RECALL NUMBER 01V364000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH), BUT THE DEALER WILL NOT REPAIR THE VEHICLE FOR FREE SINCE IT WAS ALREADY PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 134,000. UPDATED 02/01/08. *LJ THE DRIVE BELT AND POWER STEERING PUMP.
TL* - THE CONTACT STATED THAT THE BRAKE LIGHT SWITCH ON 2000 CHEVROLET BLAZER, DID NOT TURN ON WHEN BRAKES WER APPLIED. THE CONTACT TOOK THE VEHICLE INTO THE DEALERSHIP TO BE SERVICED ,AND WAS INFORMED THAT THEY COULD NOT DIAGNOSE THE FAILURE. NEITHER THE ROAD CONDITIONS NOR THE WEATHER WERE FACTORS IN THE FAILURE. *AK
I PURCHASED MY 2000 BLAZER IN 6/20/02 FROM A CHEVY DEALER IN PA . I PURCHASED THE EXTENDED WARRANTY . I HAVE UNTIL 6/07 OR100000 MILES I HAVE REPLACED THE COIL AND DISTRIBUTOR CAP AND ROTOR 5 TIMES A NEW FUEL PUMP A CATALYTIC CONVERTER WINDSHIELD WASHER MOTOR AND TURN SIGNAL SWITCH IT HAS GOTTEN TO THE POINT THAT I CAN'T EVE…
Read full complaint
I PURCHASED MY 2000 BLAZER IN 6/20/02 FROM A CHEVY DEALER IN PA . I PURCHASED THE EXTENDED WARRANTY . I HAVE UNTIL 6/07 OR100000 MILES I HAVE REPLACED THE COIL AND DISTRIBUTOR CAP AND ROTOR 5 TIMES A NEW FUEL PUMP A CATALYTIC CONVERTER WINDSHIELD WASHER MOTOR AND TURN SIGNAL SWITCH IT HAS GOTTEN TO THE POINT THAT I CAN'T EVEN SELL IT TO ANYONE PRIVATE AND I CAN'T AFFORD TO KEEP IT . THERE HAS BEEN ELECTRICAL AND COMPUTER ISSUES SHORTS THAT MELTED THE FUSE BOX UNDER THE HOOD THAT MELTED THE RELAY FOR THE FUEL PUMP. ALSO THERE WAS A SHORT THAT WIPED THE COMPUTER CODES OUT AND I HAD A ROUGH TIME PASSING EMISSION TESTING I AM AT THE POINT THE EXTENDED WARRANTY DOES NOT WANT TO SPEND ANY MORE ON THE VEHICLE. I HAVE HAD THE MOTOR MOUNTS REPLACED TWICE IN 4 YEARS. I HAVE NEVER BEEN NOTIFIED OF ANY RECALLS ORSERVICE NOTICES . I HAVE HAD THE VEHICLE SERVICED BY LICENSED MECHANICS AND HAD IT SERVICED AT THE APPROPRIATE MILEAGE REQUIRED FOR THE WARRANTY. *NM
WE HAVE OWNED 2000 BLAZER SINCE 0/6/2001 2ND OWNER BOUGHT WITH LESS THAN 19000 MILES ON IT. MULTI-FUNCTION SWITCH REPLACED BECAUSE OF RECALL ACTS UP WHEN BULBS ARE WEAK. WE ARE ON THE THIRD SET OF UPPER BALL JOINTS NONE PAID FOR BY WARRANTY. LEFT HUB ASSEMBLY FAILURE WHICH RESULTED IN ABS MALFUNCTION FIXED BY EXTENDED WARRANTY. …
Read full complaint
WE HAVE OWNED 2000 BLAZER SINCE 0/6/2001 2ND OWNER BOUGHT WITH LESS THAN 19000 MILES ON IT. MULTI-FUNCTION SWITCH REPLACED BECAUSE OF RECALL ACTS UP WHEN BULBS ARE WEAK. WE ARE ON THE THIRD SET OF UPPER BALL JOINTS NONE PAID FOR BY WARRANTY. LEFT HUB ASSEMBLY FAILURE WHICH RESULTED IN ABS MALFUNCTION FIXED BY EXTENDED WARRANTY. DRIVER DOOR HINGE ASSEMBLY RUSTED WOULD NOT CLOSE WITHOUT FORCE FIXED BUT NOT COVERED BY ANY WARRANTY. SUSPECT DRIVER SIDE IS STARTING TO FAIL AGAIN BECAUSE OF THE LOUD SQUEAKING. MOST IMPORTANT! PASSENGER SIDE DOOR HAS DEVELOPED SAME PROBLEM AND WILL NOT SHUT CORRECTLY. ON MAY 01,2006 AFTER PICKING UP MY 12 YEAR OLD NEPHEW WE WERE TO STARTING TO DOWN THE STREET WHEN PASSENGER DOOR FLEW OPEN!!!! I AM AFRAID TO LET ANYONE SIT IN FRONT UNTIL THIS IS FIXED! THE HINGES AND PINS APPEAR TO BE GETTING WET AND RUSTING . ALSO ALL ROTORS HAVE HAD TO BE REPLACED ON THIS VEHICLE . THIS BLAZER HAS ONLY 88,000 MILES ON IT. I HAVE DECIDED TO INCLUDE ALL PROBLEMS BUT AM MOST CONCERNED ABOUT DOORS, IF WE HAD BEEN GOING FASTER I AM AFRAID MY NEPHEW WOULD HAVE FALLEN OUT OF VEHICLE!!! *JB
DT: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN ID 01V364000 CONCERNING THE BRAKE LIGHT SWITCH. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT HAS NOT HAD THE VEHICLE REPAIRED.*AK
RADLEY CHEVROLET DID NOT PROVIDE US WITH A RECALL NOTICE ON BRAKE LIGHTS NOT WORKING. WE HAVE HAD PROBLEMS WITH OUR 2000 CHEVROLET BLAZER FROM THE START. WE HAVE BEEN NOW TOLD THAT THE IDLER ARM ON THE CAR IS A SAFETY HAZARD. WE ALSO HAD THE FUEL GAUGE GO OUT. HOW OFTEN DO THESE COMPONENTS GO OUT. CAN YOU TELL ME ANYTHING A…
Read full complaint
RADLEY CHEVROLET DID NOT PROVIDE US WITH A RECALL NOTICE ON BRAKE LIGHTS NOT WORKING. WE HAVE HAD PROBLEMS WITH OUR 2000 CHEVROLET BLAZER FROM THE START. WE HAVE BEEN NOW TOLD THAT THE IDLER ARM ON THE CAR IS A SAFETY HAZARD. WE ALSO HAD THE FUEL GAUGE GO OUT. HOW OFTEN DO THESE COMPONENTS GO OUT. CAN YOU TELL ME ANYTHING ABOUT THE IDLER ARM AND IS THERE ANY RECALLS FOR THIS ITEM. *JB
MY VEHICLE WAS RECENTLY PURCHASED FROM A COWORKER WITH A KNOWN RECALL THAT WAS ALREADY FIXED ONCE AND NOW IS NOT FUNCTIONING AGAIN. I CALLED CHEVROLET AND THEY TOLD ME THERE IS NOT MUCH THEY COULD DO SINCE IT WAS BEYOND THE WARRANTY ,I HAD IT DIAGNOSED AT A DEALERSHIP WHICH COST ME $85.00 TO TELL ME WHAT I ALREADY KNEW BUT THEY…
Read full complaint
MY VEHICLE WAS RECENTLY PURCHASED FROM A COWORKER WITH A KNOWN RECALL THAT WAS ALREADY FIXED ONCE AND NOW IS NOT FUNCTIONING AGAIN. I CALLED CHEVROLET AND THEY TOLD ME THERE IS NOT MUCH THEY COULD DO SINCE IT WAS BEYOND THE WARRANTY ,I HAD IT DIAGNOSED AT A DEALERSHIP WHICH COST ME $85.00 TO TELL ME WHAT I ALREADY KNEW BUT THEY WOULD NOT FIX IT. THIS IS FAILURE THAT IS KNOWN AND I BELIEVE WAS NOT CORRECTED THE FIRST TIME SO I SHOULD NOT BE RESPONSIBLE FOR THE REPAIR COSTS SINCE IT IS A SAFETY ISSUE. THE ITEM IS A 4 WAY SWITCH. *NM
WHILE VEHICLE WAS PARKED A FIRE STARTED IN THE TURN SIGNAL SWITCH. *AK THE CONSUMER STATED EVER SINCE THE INCIDENT HAPPENED, THE ABS AND BRAKE LIGHT STAY ON. THE DEALER STATED THERE WAS NO PROBLEM WITH THE BRAKES. *JB
A RECALL ON THE MULTI-PURPOSE SWITCH WAS RECIEVED AND PART WAS REPLACED IN APRIL OF 2002. ON MONDAY AUGUST 22,2005 THE SAME SWITCH WAS REPLACED AGAIN AT MY EXPENCE.GM SHOULD CORRECT THR REAL PROBLEM AND NOT JUST THE PARTS.ALSO THE PASSANGE SEAT ADJUSTER HAS BROKEN OFF.AND IN ADDITION THE TRANSMISSION FAILED AND HAD TO BE REPLACE…
Read full complaint
A RECALL ON THE MULTI-PURPOSE SWITCH WAS RECIEVED AND PART WAS REPLACED IN APRIL OF 2002. ON MONDAY AUGUST 22,2005 THE SAME SWITCH WAS REPLACED AGAIN AT MY EXPENCE.GM SHOULD CORRECT THR REAL PROBLEM AND NOT JUST THE PARTS.ALSO THE PASSANGE SEAT ADJUSTER HAS BROKEN OFF.AND IN ADDITION THE TRANSMISSION FAILED AND HAD TO BE REPLACED UNDER WARRANTY.
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.