NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
63 reportsClear category filter113,000 miles · Sep 30, 2011
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ALWAYS SMELL FUEL WHILE DRIVING REPLACED ALL FUEL SYSTEMS THEN ALL SENSORS NEEDED REPLACING SO I DID THAT AND NOW THERE TELLING ME I HAVE A ELECTRIC PROBLEMS SINCE BUYING THIS VEHICLE NEW I PUT OVER 6000.00 DOLLARS INTO AND I STILL HAVE ALL THE SAME PROBLEMS MOSTLY WITH THE FUEL SYSTEM I STILL SMELL ALOT OF FUEL WHEN DRIVING AND…
Read full complaint
ALWAYS SMELL FUEL WHILE DRIVING REPLACED ALL FUEL SYSTEMS THEN ALL SENSORS NEEDED REPLACING SO I DID THAT AND NOW THERE TELLING ME I HAVE A ELECTRIC PROBLEMS SINCE BUYING THIS VEHICLE NEW I PUT OVER 6000.00 DOLLARS INTO AND I STILL HAVE ALL THE SAME PROBLEMS MOSTLY WITH THE FUEL SYSTEM I STILL SMELL ALOT OF FUEL WHEN DRIVING AND BACK FIRING AND SHUTTING OFF IN THE MIDDLE OF DRIVING I HAVE ALL MY RECEIPTS FROM WORK DONE ON THE WHOLE FUEL SYSTEM AND I'VE LOOKED UP THIS KIND OF BLAZER AND EVERYONE WHO OWNED ONE HAS THE SAME PROBLEMS. *TR
NHTSA ODI #10428095
2,000 miles · Aug 24, 2010
Engine And Engine CoolingExterior LightingFuel System, Gasoline
FRONT END IS JUNK,THE SMELL OF RAW GAS WHEN FUELING UP AND REPLACED OIL LINE, STEERING PARTS, DOOR PIN, BACK LIGHT, RIGHT HUB, BEFORE SERVICE WARRANTY WAS UP. THEN OF COARSE THE, ROTORS WENT ALONG WITH THE LEFT HUB AND HEATER CORE WENT,.. THE BLAZER HAS BEEN A LEMON SINCE I BOUGHT IT NEW. CRIED ALOT.. I JUST TURNED THE 100,000 …
Read full complaint
FRONT END IS JUNK,THE SMELL OF RAW GAS WHEN FUELING UP AND REPLACED OIL LINE, STEERING PARTS, DOOR PIN, BACK LIGHT, RIGHT HUB, BEFORE SERVICE WARRANTY WAS UP. THEN OF COARSE THE, ROTORS WENT ALONG WITH THE LEFT HUB AND HEATER CORE WENT,.. THE BLAZER HAS BEEN A LEMON SINCE I BOUGHT IT NEW. CRIED ALOT.. I JUST TURNED THE 100,000 ON 7/15/10 COULDN'T GO ANYWHERE CAUSE IT WAS IN THE SHOP BEING FIXED... LEMON SO MUCH FOR BUYING NEW. *TR
NHTSA ODI #10351618
108,000 miles · Jul 31, 2010
Engine And Engine Cooling
THE HEATER CORE HAS GONE OUT FOUR TIMES SINCE I HAVE OWNED THE VEHICLE WHEN THIS HAPPENS I CAN NOT SEE OUT MY WINDSHIELD AND I AM BREATHING IN POISONOUS FUMES FROM THE ANTI FREEZE THAT IS NOW LEAKING INTO THE DRIVERS CAB. *TR
NHTSA ODI #10346509
108,000 miles · Jul 20, 2010
Engine And Engine Cooling
HAD THE HEATER CORE FIXED THREE TIMES UNDER WARRANTY AND IT IS OUT AGAIN. *TR
NHTSA ODI #10344295
100,000 miles · Sep 15, 2009
Engine And Engine Cooling
I HAVE A 2000 BLAZER LT WITH 128,000 MILES THAT HAS HAD HEATING/COOLING SYSTEM PROBLEMS FOR SEVERAL YEARS. HAD DEX-COOL IN SYSTEM WHICH I MONITORED REGULARLY TO MAKE SURE HAS TOPPED UP. GM STATES DEX-COOL IS MAINT FREE TO 155,000 MILES. WHEN VEHICLE REACHED 100,000 MILES, I BEGAN TO LOOSE HEAT. I NOTICED A CRYSTAL-LIKE RESIDUE F…
Read full complaint
I HAVE A 2000 BLAZER LT WITH 128,000 MILES THAT HAS HAD HEATING/COOLING SYSTEM PROBLEMS FOR SEVERAL YEARS. HAD DEX-COOL IN SYSTEM WHICH I MONITORED REGULARLY TO MAKE SURE HAS TOPPED UP. GM STATES DEX-COOL IS MAINT FREE TO 155,000 MILES. WHEN VEHICLE REACHED 100,000 MILES, I BEGAN TO LOOSE HEAT. I NOTICED A CRYSTAL-LIKE RESIDUE FLOATING IN COOLANT. DRAINED, BACK FLUSHED HEATER CORE AND FLUSHED SYSTEM 3 TIMES THEN ADDED PRESTONE (GREEN) COOLANT. AFTER ABOUT 10,000 MILES BEGAN TO LOOSE HEAT AGAIN, REPEATED FLUSH AND FILL. EVERY YEAR SINCE, WHEN COLDER WEATHER SETS IN, THE SAME PROBLEM SHOWS UP AND I GO THROUGH THE SAME FLUSH AND FILL PROCEDURE. DEX-COOL HAS LEFT SO MUCH SLUDGE THROUGHOUT THE SYSTEM I CAN'T GET IT ALL OUT AND IT CONTINUES TO PLUG THE SYSTEM. I HAVE REPLACED TWO WATER PUMPS, THREE THERMOSTATS AND HAVE SPENT HUNDREDS OF DOLLARS JUST DOING FLUSH AND FILLS. ENGINE TEMP WILL BE GOOD FOR THE FIRST FEW WEEKS AFTER A F & F THEN BEGINS TO RUN HOT AGAIN WITH THE SMELL OF COOLANT IN AND AROUND THE VEHICLE. THERE ARE NO VISIBLE LEAKS ON THE GROUND OR ON THE BLOCK. ALL ENGINE VACUUMS CHECK OK. ALL OTHER REGULAR MAINT DONE WHEN REQUIRED. LAST F & F DONE 08-30-2009 AND VEHICLE IS STARTING TO RUN HOT ALREADY/AGAIN. *TR
NHTSA ODI #10283990
100,000 miles · Dec 9, 2008
Engine And Engine Cooling
INTAKE MANIFOLD IS LEAKING WHICH CAUSES OVERHEATING. I'VE OWNED TWO 2000 CHEVY BLAZERS AND HAVE HAD THE SAME PROBLEM IN EACH. *TR
NHTSA ODI #10251164
117,000 miles · Oct 14, 2008
Engine And Engine Cooling
TOOK VEHICLE IN FOR OIL CHANGE, NEXT DAY CAR MADE NOISES AND LEAKED OIL. CONTACTED DEALER, TWO DAYS LATER CAR NEEDED TWO QTS OF OIL. CAR DEALER THEN TOWED CAR,HAD CAR FOR A WEEK AND SAID 'IT'S NOT THEIR FAULT'. EXTENDED WARRANTY EXPIRED. *TR
NHTSA ODI #10245374
134,000 miles · Aug 6, 2007
Engine And Engine CoolingExterior LightingSteering
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE TWO REAR BRAKE LIGHTS ABOVE THE HITCH FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. THE DEALER STATED THAT THE BRAKE LIGHTS WERE ALREADY REPAIRED ACCORDING TO THE MECHANIC'S RECORDS. SHE STATED THAT HER VEHICLE IS UNDER RECALL NUMBER 01V364000 (E…
Read full complaint
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE TWO REAR BRAKE LIGHTS ABOVE THE HITCH FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. THE DEALER STATED THAT THE BRAKE LIGHTS WERE ALREADY REPAIRED ACCORDING TO THE MECHANIC'S RECORDS. SHE STATED THAT HER VEHICLE IS UNDER RECALL NUMBER 01V364000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH), BUT THE DEALER WILL NOT REPAIR THE VEHICLE FOR FREE SINCE IT WAS ALREADY PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 134,000. UPDATED 02/01/08. *LJ THE DRIVE BELT AND POWER STEERING PUMP.
NHTSA ODI #10198589
60,000 miles · Jul 15, 2007
Engine And Engine CoolingFuel System, OtherPower Train
2000 BLAZER TRANSMISSION FAILED, COST $3000 TO REPAIR. LEFT BALL JOINT FAILED AND REPLACED ALL $500, PITMAN ARM, IDLER ARM, TIE RODS RIGHT AND LEFT NEEDED REPLACEMENT. LEFT FRONT WHEEL BEARING HUB FAILED AND WAS REPLACED, BOTH $800. OVERHEATING DUE TO DEXCOOL LEAK AT INTAKE NEEDED REPLACEMENT. I HAVE A $20,000 PIECE OF J…
Read full complaint
2000 BLAZER TRANSMISSION FAILED, COST $3000 TO REPAIR. LEFT BALL JOINT FAILED AND REPLACED ALL $500, PITMAN ARM, IDLER ARM, TIE RODS RIGHT AND LEFT NEEDED REPLACEMENT. LEFT FRONT WHEEL BEARING HUB FAILED AND WAS REPLACED, BOTH $800. OVERHEATING DUE TO DEXCOOL LEAK AT INTAKE NEEDED REPLACEMENT. I HAVE A $20,000 PIECE OF JUNK SITTING IN MY DRIVEWAY.THIS WAS ONGOING FROM EARLIER YEAR MODELS BUT NO RECALLS FOR THIS YEAR ,WHY NO BODY DIED ? FUEL GAUGE BOUNCED. *AK
NHTSA ODI #10196403
120,000 miles · May 14, 2007
Electrical SystemEngine And Engine CoolingEquipmentCrash
THE HANDLE THAT ALLOWS YOU TO RECLINE THE SEAT BROKE OFF FLUSHED WITH THE SEAT, THIS HAPPENED TO BOTH THE DRIVER AND PASSENGER SEATS IN JUNE 2005. THE HOOD WILL NOT POP UP WHEN THE LEVER WAS PULLED UNTIL ONE BANGED ON THE GRILL OR THE HOOD IN CERTAIN SPOTS, WHICH JUST STARTED IN MARCH OF 2007. THE GAS MILEAGE DROPPED FRO…
Read full complaint
THE HANDLE THAT ALLOWS YOU TO RECLINE THE SEAT BROKE OFF FLUSHED WITH THE SEAT, THIS HAPPENED TO BOTH THE DRIVER AND PASSENGER SEATS IN JUNE 2005. THE HOOD WILL NOT POP UP WHEN THE LEVER WAS PULLED UNTIL ONE BANGED ON THE GRILL OR THE HOOD IN CERTAIN SPOTS, WHICH JUST STARTED IN MARCH OF 2007. THE GAS MILEAGE DROPPED FROM 20 MPG TO 16 MPG WITHIN 6 MONTHS. THE BACK GLASS STUCK AND WAS HARD TO OPEN, STARTED IN 2006. WHEN TURNING ON THE AIR CONDITIONER (A/C ) THE CAR HAD NO POWER, I HAVE TO TURN IT OFF WHEN ACCELERATING ON THE INTERSTATE OR ON HILLS. IF THE CRUISE CONTROL WAS SET IT KICKED OFF WHEN THE A/C WAS ON. WHEN I NEEDED TO STOP QUICKLY THE BRAKES FAILED, AND FELT A GRINDING SENSATION THROUGH THE PEDAL, BUT THE MECHANIC CHANGED THE BRAKES AND CHECKED THE ROTORS, BUT HASN'T FOUND ANY PROBLEM. SUSPECTED A DEFECT SOMEWHERE IN THE BRAKE SYSTEM\ AS OF 2005. THE FAN KICKED ON ALL THE TIME, EVEN WHEN THE ENGINE WAS COLD, AND IN WINTER WHEN FIRST STARTING. ONE MECHANIC TOLD ME THAT IN MANY BLAZERS THE CATALYTIC CONVERTER BROKE OFF IN THE MUFFLER, WHICH HAD TO BE REPLACED. HAD BEEN TOLD THIS HAPPENED SO MUCH THAT MOST PEOPLE LEFT THEM OFF. TOO MANY OTHER PROBLEMS TO MENTIONED. ALSO, THE HORN WORKED ONLY WHEN IT WANTED TO, PROBLEM IN THE STEERING WHEEL. *AK
NHTSA ODI #10190669
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration