NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
49 reportsClear category filterMileage unknown · Oct 23, 2006
Electrical SystemEngine And Engine CoolingExterior Lighting
I PURCHASED MY 2000 BLAZER IN 6/20/02 FROM A CHEVY DEALER IN PA . I PURCHASED THE EXTENDED WARRANTY . I HAVE UNTIL 6/07 OR100000 MILES I HAVE REPLACED THE COIL AND DISTRIBUTOR CAP AND ROTOR 5 TIMES A NEW FUEL PUMP A CATALYTIC CONVERTER WINDSHIELD WASHER MOTOR AND TURN SIGNAL SWITCH IT HAS GOTTEN TO THE POINT THAT I CAN'T EVE…
Read full complaint
I PURCHASED MY 2000 BLAZER IN 6/20/02 FROM A CHEVY DEALER IN PA . I PURCHASED THE EXTENDED WARRANTY . I HAVE UNTIL 6/07 OR100000 MILES I HAVE REPLACED THE COIL AND DISTRIBUTOR CAP AND ROTOR 5 TIMES A NEW FUEL PUMP A CATALYTIC CONVERTER WINDSHIELD WASHER MOTOR AND TURN SIGNAL SWITCH IT HAS GOTTEN TO THE POINT THAT I CAN'T EVEN SELL IT TO ANYONE PRIVATE AND I CAN'T AFFORD TO KEEP IT . THERE HAS BEEN ELECTRICAL AND COMPUTER ISSUES SHORTS THAT MELTED THE FUSE BOX UNDER THE HOOD THAT MELTED THE RELAY FOR THE FUEL PUMP. ALSO THERE WAS A SHORT THAT WIPED THE COMPUTER CODES OUT AND I HAD A ROUGH TIME PASSING EMISSION TESTING I AM AT THE POINT THE EXTENDED WARRANTY DOES NOT WANT TO SPEND ANY MORE ON THE VEHICLE. I HAVE HAD THE MOTOR MOUNTS REPLACED TWICE IN 4 YEARS. I HAVE NEVER BEEN NOTIFIED OF ANY RECALLS ORSERVICE NOTICES . I HAVE HAD THE VEHICLE SERVICED BY LICENSED MECHANICS AND HAD IT SERVICED AT THE APPROPRIATE MILEAGE REQUIRED FOR THE WARRANTY. *NM
NHTSA ODI #10171668
50,000 miles · Jan 25, 2006
Electrical SystemEngine And Engine CoolingFuel System, Other
OWNS A 2000 CHEVROLET BLAZER ZR2 WITH 68000 MILES. THE HEATER BLOWS COLD AIR ONLY. THE ALTERNATOR HAS BEEN REPLACED AT LEAST TWICE. I REPLACED IT ONCE, AND PREVIOUS OWNER REPLACED IT ONCE . BATTERY HAS BEEN REPLACED AT LEAST TWICE. ALL BALL JOINTS REPLACED AT LEAST ONCE TO MY KNOWLEDGE. FUEL GAUGE BROKE BEFORE 50000 …
Read full complaint
OWNS A 2000 CHEVROLET BLAZER ZR2 WITH 68000 MILES. THE HEATER BLOWS COLD AIR ONLY. THE ALTERNATOR HAS BEEN REPLACED AT LEAST TWICE. I REPLACED IT ONCE, AND PREVIOUS OWNER REPLACED IT ONCE . BATTERY HAS BEEN REPLACED AT LEAST TWICE. ALL BALL JOINTS REPLACED AT LEAST ONCE TO MY KNOWLEDGE. FUEL GAUGE BROKE BEFORE 50000 MILES. SEAT HANDLE ON PASSENGER'S SIDE BROKEN BEFORE 50000 MILES. TAILGATE WON'T OPEN. PASSENGER SIDE WINDSHIELD WIPER ONLY MOVES HALF THE TIME. THAT IS ALL THAT I CAN RECALL RIGHT NOW.*AK
NHTSA ODI #10148536
58,000 miles · Jun 21, 2005
Electrical SystemPower Train
I PURCHASED MY 2000 BLAZER LS 2DR 4X4 WITH 58000 MILES. AT SPEEDS AROUND 65-70, IT VIBRATES PRETTY HARSHLY. I HAVE BRAND NEW TIRES, BREAKS, AND MY U-JOINTS AND BEARINGS HAVE BEEN INSPECTED AND FOUND TO BE FINE. STILL HAVE VIBRATION. I HAVE NOTICED VIA THE INTERNET THAT THIS IS A KNOWN PROBLEM WITH BLAZER'S AND IT IS JUST A D…
Read full complaint
I PURCHASED MY 2000 BLAZER LS 2DR 4X4 WITH 58000 MILES. AT SPEEDS AROUND 65-70, IT VIBRATES PRETTY HARSHLY. I HAVE BRAND NEW TIRES, BREAKS, AND MY U-JOINTS AND BEARINGS HAVE BEEN INSPECTED AND FOUND TO BE FINE. STILL HAVE VIBRATION. I HAVE NOTICED VIA THE INTERNET THAT THIS IS A KNOWN PROBLEM WITH BLAZER'S AND IT IS JUST A DEFECT IN THE WAY THE DRIVETRAIN WAS BUILT. I FEEL THAT THIS PROBLEM SHOULD BE INVESTIGATED AND REPAIRED BY GM. ALSO AT 58000 MILES I HAD TO REPLACE THE ALTERNATER. I SPOKE WITH THE PERSON WHO I BOUGHT THE VEHICLE FROM AND THEY SAID THAT THEY HAD REPLACED IT ONCE ALSO, THEREFORE THIS WOULD BE THE 3RD ALTERNATER IN UNDER 60000 MILES.
NHTSA ODI #10126116
72,000 miles · May 14, 2005
Electrical SystemEngine And Engine CoolingFuel System, Other
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN …
Read full complaint
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN NOT BE FIXED; CALLED CHEVROLET AND WAS TOLD TO TAKE IT BACK TO DEALER AND PAY THEM TO REEVALUATE THE PROBLEM; ) SAFTY ISSUES: BALL JOINTS NEED TO BE REPLACED;GAS GAUGE SENDING UNIT DOESN'T WORK;;DIFFERENTIAL IS LEAKING AND PLUG CONNECTED TO THIS NEEDS TO BE DRILLED OUT AND RETHREADED TO FIND OUT HOW BAD THE LEAK IS; WINDSHIELD WIPER ON DRIVER'S SIDE LOOSE AND FLIPS OFF TO THE LEFT OF THE WINDSHIELD IN HEAVY RAIN AND SNOW; ELECTRICAL HARNASS NEEDS TO BE REPLACED; ENGINE INSOLATION PEALING OFF UNDER HOOD; ENGINE LIGHT ON CONTINUALLY; CAR STALLS INTERMITANTLY(FIRST TIME IT HAPPENED, WAS TOLD THE ENGINE HAD OVERHEATED); AT EVERY START UP, ENGINE STAYS IN NUETRAL (HAS NO EXCELLERATOR POWER)THEN CATCHES AFTER ABOUT THREE MINUTES); WORK DONE: THERMOSTAT HOSES REPLACED;DISTRIBUTOR REPLACED;SPARK PLUG WIRES AND SPARK PLUGS REPLACED; SEPENTINE BELT REPLACED; PART BETWEEN THE AXLE AND THE U JOINTS NEEDED TO BE REPLACED; OIL LEAK FIXED;FUEL INJECTOR REPLACED; I HAVE NO IDEA WHAT WILL GO WRONG WHEN; IT'S LIKE PLAYING RUSSIAN RULLETT WHILE DRIVING; HAVE RENTED VEHICLE TWICE; WILL ALSO NEED TO RENT VEHICLE FOR CROSS COUNTRY ROAD TRIP NEXT WEEK; WILL NOT RISK DRIVING THIS CAR; (INCIDENT DATE: FIRST INCIDENT-DAY ESTIMATED)
NHTSA ODI #10120916
Mileage unknown · Mar 30, 2005
Electrical System
WHILE DRIVING 2 MPH DRIVER NOTICED SMOKE COMING FROM THE STEERING COLUMN. DRIVER PULLED OVER, AND THEN TOOK THE VEHICLE TO A DEALER FOR INSPECTION. HOWEVER, THE CAUSE HAD NOT BEEN DETERMINED AT THIS TIME. *AK
NHTSA ODI #10117132
Mileage unknown · Mar 24, 2005
Electrical System
THE "BLINKING NOISE" OF MY BLINKER WON'T STOP. THE BLINKERS WORK OKAY BUT THE CLICKING WILL RANDOMLY CLICK. 2000 CHEVY BLAZER
NHTSA ODI #10114590
Mileage unknown · Dec 22, 2004
Electrical SystemExterior LightingFuel System, Gasoline
I HAVE MULTIPLE COMPLAINTS, THE GAS GAUGE ON MY VEHICLE STOP WORKING AND I RAN OUT OF GAS IN THE MIDDLE OF THE STREET WHEN I REALIZED PROBLEM 2 THE REAR BRAKE LIGHTS AND HAZARD LIGHTS DO NOT WORK. THE OTHER PROBLEM IS THE VEHICLE STALLS, AND WHEN IT FINALLY TAKE OFF, THE CAR JERKS AND THE DRIVER SEAT MOVES/SLIDES BACK FROM THE H…
Read full complaint
I HAVE MULTIPLE COMPLAINTS, THE GAS GAUGE ON MY VEHICLE STOP WORKING AND I RAN OUT OF GAS IN THE MIDDLE OF THE STREET WHEN I REALIZED PROBLEM 2 THE REAR BRAKE LIGHTS AND HAZARD LIGHTS DO NOT WORK. THE OTHER PROBLEM IS THE VEHICLE STALLS, AND WHEN IT FINALLY TAKE OFF, THE CAR JERKS AND THE DRIVER SEAT MOVES/SLIDES BACK FROM THE HINGES WHICH CAUSED ME TO NOT BE ABLE TO REACH MY BREAKS AND RUN INTO A CURB. ALSO THE DRIVER SIDE DOOR STICKS AND IS DIFFICULT TO OPEN. LASTLY THE WHEEL BARING AND BALL JOINTS HAVE GONE BAD TWICE AND THE CAR HAS LESS THEN 75000 MILES ON IT. I CALLED GM CUSTOMER SERVICE DEPARTMENT AND EXPLAINED ALL OF MY CONCERNS AND WAS TOLD THEY WE NOT AWARE OF ANY NATIONWIDE PROBLEM AND THERE WAS NOTHING THEY COULD DO EXCEPT FIX THE HAZARD LIGHT MALFUNCTION. I RESEARCHED ON THE NET AND FOUND MANY MANY PEOPLE COMPLAINING OF THE SAME CONCERNS I HAVE. *JB
NHTSA ODI #10104364
Mileage unknown · Jul 27, 2004
Electrical System
BLINKER SOUND CONTIUNES WHEN BLINKERS ARE NOT REALLY ON, IT'S ANNOYING AND AN ELECTRICAL PROBLEM, BUT COULD POTENTIALLY CAUSE AN ACCIDENT. MANY CAR REPAIR SHOPS HAVE HEARD OF THIS SAME PROBLEM ON THE SAME VEHICLE. *AK
NHTSA ODI #10082759
85,000 miles · Jul 7, 2004
Electrical SystemPower TrainVehicle Speed Control
TRANSMISSION FALURE, REVERSE SECOND AND THIRD GEAR, TRANSFER CASE FAILURE, CRUISE CONTROL DOESNT WORK, DASHBOARD CLUSTER FAILURE. *AK
NHTSA ODI #10080560
Mileage unknown · May 11, 2004
Electrical System
ON FIVE SEPARATE OCCASIONS THE VEHICLE STALLED WHILE DRIVING AT ANY SPEED. THE DRIVER WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *JB THE ENGINE SHUT DOWN WITHOUT ANY WARNING AT ANY SPEED AND WHILE IDLING IN PARK, THE ENGINE RESTARTED. THE PROBLEM COUL…
Read full complaint
ON FIVE SEPARATE OCCASIONS THE VEHICLE STALLED WHILE DRIVING AT ANY SPEED. THE DRIVER WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *JB THE ENGINE SHUT DOWN WITHOUT ANY WARNING AT ANY SPEED AND WHILE IDLING IN PARK, THE ENGINE RESTARTED. THE PROBLEM COULD NOT BE DUPLICATED. THE GAS FILTER, IGNITION WIRING, AND THE FUEL PUMP WAS REPLACED BUT THE VEHICLE WAS STILL EXPERIENCING THE SAME PROBLEM. *SC *JB
NHTSA ODI #10064941
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration