IllustrationENGINE SHUTS DOWN WHILE DRIVING AS IF IGNITION TURNED OFF. CANNOT GET OUT OF PARK. AIR CONDITIONER STOPPED IN 2010, 2011, 2013 AIR BAG LIGHTS ON DASHBOARD ON SINCE 2010. *TR
2007 Chevrolet Aveo
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Chevrolet Aveo do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aveo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
560–25K
2625–50K
3250–75K
3575–100K
20100–150K
4150K+
173 reports with mileage · 43 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports13 fire reports15 injury reports
Engine complaints
13 reportsI WAS DRIVING THROUGH TOWN,ALL OF A SUDDEN I HAD NO RPM'S AND THE CAR CAME TO A COMPLETE STOP . CALLED A TOW SERVICE AND HAD IT TOWED, THE MECHANIC EXPLAINED TO ME THAT THE TIMING BELT HAD SNAPPED AND IT HAS CAUSED INTERNAL DAMAGE TO THE ENGINE. FROM THE RESEARCH I HAVE DONE ONLINE, THIS SEEMS TO BE AN ONGOING PROBLEM WITH CHEV…
Read full complaint
I WAS DRIVING THROUGH TOWN,ALL OF A SUDDEN I HAD NO RPM'S AND THE CAR CAME TO A COMPLETE STOP . CALLED A TOW SERVICE AND HAD IT TOWED, THE MECHANIC EXPLAINED TO ME THAT THE TIMING BELT HAD SNAPPED AND IT HAS CAUSED INTERNAL DAMAGE TO THE ENGINE. FROM THE RESEARCH I HAVE DONE ONLINE, THIS SEEMS TO BE AN ONGOING PROBLEM WITH CHEVROLET, I JUST HATE TO THINK WHAT WOULD HAVE HAPPENED HAD IT BEEN ON A BUSY HIGHWAY, BECAUSE I HAD NO WARNING. *JS
I WAS DRIVING 65 MPH ON THE HIGHWAY, WHEN ALL OF A SUDDEN MY RPMS DROPPED TO ZERO AND I COULD NO LONGER ACCELERATE. I HAD TO CUT ACROSS TWO LANES OF TRAFFIC TO SAFELY MAKE IT TO THE SHOULDER OF THE ROAD. I LATER FOUND OUT THAT MY TIMING BELT HAD SNAPPED, CAUSING INTERNAL DAMAGE TO MY ENGINE AND CAUSING MY CAR TO BREAK DOWN IN TH…
Read full complaint
I WAS DRIVING 65 MPH ON THE HIGHWAY, WHEN ALL OF A SUDDEN MY RPMS DROPPED TO ZERO AND I COULD NO LONGER ACCELERATE. I HAD TO CUT ACROSS TWO LANES OF TRAFFIC TO SAFELY MAKE IT TO THE SHOULDER OF THE ROAD. I LATER FOUND OUT THAT MY TIMING BELT HAD SNAPPED, CAUSING INTERNAL DAMAGE TO MY ENGINE AND CAUSING MY CAR TO BREAK DOWN IN THE MIDDLE OF CRUISING ON THE HIGHWAY. *JS
Official recalls
214V261000 · Exterior Lighting:headlights
May 19, 2014
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence & remedy
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
06V398000 · Fuel System, Gasoline
Oct 17, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.
Consequence & remedy
Consequence: IF THESE CONDITIONS OCCURRED IN AN ACTUAL CRASH, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.