NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
28 reportsClear category filter137,000 miles · Aug 23, 2011
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
VEHICLE STALLS AT HIGH RATE OF SPEED, HIGHWAY DRIVING, TRUCK HESITATES AND JERKS, AND COMES TO THE NEAR POINT OF STALLING, AND LOW SPEEDS, VEHICLE DOES THE SAME, HESITATES, AND JERKS, STALLS, ALL SYSTEMS FAIL. STARTS BACK UP UPON SHIFTING TO NEUTRAL. MECHANIC SAYS IT IS THE CRANKSHAFT POSITION SENSOR ON THE 8.1 L 8100 SERIES M…
Read full complaint
VEHICLE STALLS AT HIGH RATE OF SPEED, HIGHWAY DRIVING, TRUCK HESITATES AND JERKS, AND COMES TO THE NEAR POINT OF STALLING, AND LOW SPEEDS, VEHICLE DOES THE SAME, HESITATES, AND JERKS, STALLS, ALL SYSTEMS FAIL. STARTS BACK UP UPON SHIFTING TO NEUTRAL. MECHANIC SAYS IT IS THE CRANKSHAFT POSITION SENSOR ON THE 8.1 L 8100 SERIES MOTOR, THE SAME MOTOR THAT IS IN THE 2001 MODEL SILVERADO, SIERRA, AND SUBURBANS THAT IS THE SUBJECT OF A RECALL. LOCATION IS IN THE BACK OF THE MOTOR MAKING IT NEAR IMPOSSIBLE TO CHANGE OUT WITHOUT MAJOR ENGINE REPAIR WORK, REMOVING INTAKE MANIFOLD AND OTHER COMPLEX THINGS, TO REPAIR AN APPARENT $60 PART. DANGEROUS DUE TO THE FACT THAT THERE IS ABSOLUTELY NO INDICATION THAT THIS IS HAPPENING AND HAPPENED ON A VEHICLE THAT HAS BEEN CARED FOR COMPLETELY. ALSO, DANGEROUS DUE TO THE SIZE OF THE VEHICLE AND THE NEAR IMPOSSIBLE TASK OF STEERING IT TO A SAFE PLACE WITH NO POWER BRAKES OR STEERING, ESPECIALLY AT HIGHWAY SPEEDS. MECHANIC SAYS PART IT ALMOST 100% PLASTIC AND CAN SUCCUMB TO HIGH AND LOW VARIATIONS IN TEMPERATURE AND BREAK DOWN IN COMPOSITION. WHICH, IT HAS DONE IN THIS TRUCK, AGAIN WITHOUT NO WARNING, AND NO APPARENT COST EFFECTIVE REPAIR. IT WOULD APPEAR THAT THE RECALL SHOULD BE EXTENDED TO THE 2002 MODEL YEAR AS WELL AS THE SAME 8.1 L MOTOR WAS INSTALLED IN THE CHEVROLET AVALANCHE 2500 TRUCK (BY THE WAY, THE VEHICLE WAS BUILT IN 2001), WHICH, OTHER THAT THE DIFFERENT BODY STYLE HAS THE SAME CHASSIS AND MOTOR AS THE SUBURBAN. VERY DANGEROUS FOR A WOMAN, WHO CANNOT OR DOES NOT HAVE THE STRENGTH TO STEER A 7,000 POUND TRUCK THAT COMPLETELY STALLED AT A HIGH RATE OF SPEED.
NHTSA ODI #10422115
133,000 miles · Dec 14, 2010
Engine And Engine Cooling
SOMETIMES MY 2002 CHEVY AVALANCHE 8.1 WILL NOT START. I LOCK CAR AGAIN WITH REMOTE FOB, UNLOCK AND USUALLY IT STARTS. SOMETIMES IT TAKES SEVERAL ATTEMPTS AT LOCKING, UNLOCKING BEFORE IT WILL START. NOW VEHICLE STALLS WITH NO WARNING, NO POWER BRAKES, STEERING ETC. DOES THIS AT RANDOM SPEEDS WITHOUT NOTICE OR ANY APPARENT CONSIST…
Read full complaint
SOMETIMES MY 2002 CHEVY AVALANCHE 8.1 WILL NOT START. I LOCK CAR AGAIN WITH REMOTE FOB, UNLOCK AND USUALLY IT STARTS. SOMETIMES IT TAKES SEVERAL ATTEMPTS AT LOCKING, UNLOCKING BEFORE IT WILL START. NOW VEHICLE STALLS WITH NO WARNING, NO POWER BRAKES, STEERING ETC. DOES THIS AT RANDOM SPEEDS WITHOUT NOTICE OR ANY APPARENT CONSISTENCY. THIS HAS HAPPENED ON THE FREEWAY AT HIGH SPEEDS AND IS VERY DANGEROUS. TO RESTART I MUST TRY AND GET PULLED OVER SAFELY, LOCK AND UNLOCK TRUCK WITH FOB AND HOPE IT STARTS. SOMETIMES WILL DO AFTER ONCE, SOMETIMES AFTER SEVERAL ATTEMPTS. NOT REALLY SURE THE FOB RESETTING OF SECURITY SYSTEM IS THE DIFFERENCE OR IT JUST HAPPENS TO START. WHEN ARE THEY GOING TO FIX THIS POTENTIALLY FATAL PROBLEM??? *TR
NHTSA ODI #10370672
81,000 miles · Nov 3, 2010
Engine And Engine Cooling
TRUCK STALLS WHILE DRIVING THIS IS HAPPENING MORE AND MORE. *TR
NHTSA ODI #10363906
70,000 miles · Oct 26, 2010
Engine And Engine Cooling
ENGINE DIED AT 55 MPH, RESTARTED RIGHT AWAY, DIED OUT AGAIN IN THE MIDDLE OF AN INTERSECTION ABOUT THREE MILES AWAY. NEARLY CAUSED AN ACCIDENT. THIS TIME IT TOOK ABOUT 10 MINUTES BEFORE IT WOULD START. I FOUND THERE IS A RECALL ON THE 2001 AVALANCHE, WHY NOT THE 2002? *TR
NHTSA ODI #10362377
85,000 miles · Sep 15, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 2500. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, THE ENGINE COMPLETELY STALLED WITHOUT WARNING. THE ENGINE WOULD NOT RESTART. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE CONTACT EXPERIENCED THE IDENTICAL FAILURE AS MENTIONED IN THE RECALL ASSOCIATED WITH THE NHTSA …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 2500. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, THE ENGINE COMPLETELY STALLED WITHOUT WARNING. THE ENGINE WOULD NOT RESTART. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE CONTACT EXPERIENCED THE IDENTICAL FAILURE AS MENTIONED IN THE RECALL ASSOCIATED WITH THE NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING); HOWEVER, HIS MODEL YEAR AND MODEL WAS NOT INCLUDED IN THE RECALL DEFECT. THE FAILURE MILEAGE WAS 85,000.
NHTSA ODI #10355668
59,000 miles · Aug 2, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 2500. THE CONTACT STATED THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 59,000.
NHTSA ODI #10346776
80,140 miles · Apr 30, 2010
Engine And Engine Cooling
DRIVING 2002 CHEVY AVALANCHE 2500 8.1 L AT VARIOUS TIMES AND SPEEDS AND ENGINE CUTS OUT. NO POWER STEERING OR BRAKES. PULLED OVER AND AFTER A MINUTE THE ENGINE WILL RESTART. RESEARCHED ONLINE AND FOUND THAT THE PROBLEM WITH MANY OTHER LIKE VEHICLES HAVE SAME PROBLEM (CRANKSHAFT POSITION SENSOR). REPORTED PREVIOUS YEAR SAME E…
Read full complaint
DRIVING 2002 CHEVY AVALANCHE 2500 8.1 L AT VARIOUS TIMES AND SPEEDS AND ENGINE CUTS OUT. NO POWER STEERING OR BRAKES. PULLED OVER AND AFTER A MINUTE THE ENGINE WILL RESTART. RESEARCHED ONLINE AND FOUND THAT THE PROBLEM WITH MANY OTHER LIKE VEHICLES HAVE SAME PROBLEM (CRANKSHAFT POSITION SENSOR). REPORTED PREVIOUS YEAR SAME ENGINE HAD RECALL FOR CRANKSHAFT POSITION SENSOR. *TR
NHTSA ODI #10328259
76,687 miles · Feb 27, 2010
Engine And Engine Cooling
WHILE DRIVING DOWN THE ROAD MY 2002 CHEVY AVALANCHE 2500 8.1L ENGINE WOULD SHUT OFF. THIS WAS HAPPENING 4 - 5 TIMES ON A DAILY BASIS DEPENDING ON HOW FAR I HAD TO DRIVE. THE LAST TIME THIS HAPPENED I WAS DRIVING ON THE HIGHWAY WITH MY SON IN THE TRUCK AND THE ENGINE SHUT DOWN LEAVING ME WITH LIMITED ABILITY TO SAFELY GET INTO TH…
Read full complaint
WHILE DRIVING DOWN THE ROAD MY 2002 CHEVY AVALANCHE 2500 8.1L ENGINE WOULD SHUT OFF. THIS WAS HAPPENING 4 - 5 TIMES ON A DAILY BASIS DEPENDING ON HOW FAR I HAD TO DRIVE. THE LAST TIME THIS HAPPENED I WAS DRIVING ON THE HIGHWAY WITH MY SON IN THE TRUCK AND THE ENGINE SHUT DOWN LEAVING ME WITH LIMITED ABILITY TO SAFELY GET INTO THE BREAK DOWN LANE. THUS IS WHY I ENDED UP GETTING STUCK IN THE MIDDLE OF THE HIGHWAY. I HAD IT TOWED TO A DEALERSHIP WHOM LATER REPLACED MY " CRANKSHAFT POSITIONING SENSOR ". THIS INCIDENT OCCURRED ON JUNE 13, 2009. I HAVE SPOKEN WITH SEVERAL OTHER OWNERS OF THE SAME VEHICLE ALL OF WHICH HAVE HAD THE SAME ISSUE. FROM WHAT I UNDERSTAND THERE WAS A RECALL FOR THE SAME PROBLEM ( NHTSA CAMPAIGN ID NUMBER: 07V521000 ), WITH THE SAME MOTOR THAT WAS IN THE 2001 CHEVY TRUCKS. WHAT IS BEING DONE ABOUT THIS ISSUE INVOLVING THE 2002 VEHICLES? *TR
NHTSA ODI #10314804
60,000 miles · Feb 22, 2010
Engine And Engine Cooling
DON'T UNDERSTAND WHY 2002 TRUCKS WERE NOT INCLUDED IN THIS RECALL, I HAD THE SAME PROBLEM WITH CRANK SENSOR AND ENGINE STALLING AT HIGHWAY SPEEDS. I HAD THE SENOR REPLACED 3 YEARS AGO. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) IS DIRECTING THE RECALL OF 11,974 2001-MODEL-YEAR HEAVY DUTY PICKUPS BUILT BY GENE…
Read full complaint
DON'T UNDERSTAND WHY 2002 TRUCKS WERE NOT INCLUDED IN THIS RECALL, I HAD THE SAME PROBLEM WITH CRANK SENSOR AND ENGINE STALLING AT HIGHWAY SPEEDS. I HAD THE SENOR REPLACED 3 YEARS AGO. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) IS DIRECTING THE RECALL OF 11,974 2001-MODEL-YEAR HEAVY DUTY PICKUPS BUILT BY GENERAL MOTORS TO FIX FAULTY CRANKSHAFT POSITION SENSORS, UNDER NHTSA CAMPAIGN ID NUMBER 07V521000. *TR
NHTSA ODI #10312694
91,000 miles · Jul 27, 2009
Engine And Engine Cooling
2002 CHEVY AVALANCHE 2500- NONE PROBLEM WITH CRANK SHAFT SENSOR FAILING. MY VEHICLE STALLED IN THE MIDDLE OF TRAFFIC. I WAS ALMOST HIT FROM BEHIND. THIS HAS HAPPENED SEVERAL TIMES. UPON RESEARCH I LEARNED THAT THIS IS A COMMON PROBLEM WITH THIS VEHICLE AND THAT CHEVY IS AWARE BUT HAS DONE NOTHING. SOMEONE IS GOING TO BE KILLED …
Read full complaint
2002 CHEVY AVALANCHE 2500- NONE PROBLEM WITH CRANK SHAFT SENSOR FAILING. MY VEHICLE STALLED IN THE MIDDLE OF TRAFFIC. I WAS ALMOST HIT FROM BEHIND. THIS HAS HAPPENED SEVERAL TIMES. UPON RESEARCH I LEARNED THAT THIS IS A COMMON PROBLEM WITH THIS VEHICLE AND THAT CHEVY IS AWARE BUT HAS DONE NOTHING. SOMEONE IS GOING TO BE KILLED OR HURT IF THIS IS NOT COMMUNICATED. IT HAS BEEN REPORTED MANY TIMES- SEE WEB SITE WWW.CHEVYAVALANCHFANCLUB.COM/CAFCNA/INDEX.PHP?TOPIC IF YOU JUST SEARCH CHEVY AVALANCHE ENGINE STALLING YOU WILL FIND ALL OF THE POSTS. MANY PEOPLE START BY CHANGING THEIR BATTERY, REPLACING THEIR FUEL PUMP AND FILTER, REPLACING THE AIR FILTER BUT THE PROBLEM PERSISTS. PLEASE ADDRESS BEFORE SOMEONE IS KILLED. IT IS DANGEROUS FOR A VEHICLE TO STALL LIKE THIS......... *TR
NHTSA ODI #10278395
NHTSA investigations
3EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
EA07013 · Trailer Hitch Receiver Failure
Opened Sep 14, 2007 · Closed Sep 12, 2008
Status: closed (inferred from source dates) · Trailer Hitches
COMPLAINT REPORTS ALLEGE POOR WELD QUALITY AND/OR BENDING OF THE SUBJECT VEHICLE ORIGINAL EQUIPMENT TRAILER HITCH RECEIVER.THE AGENCY'S INVESTIGATION INCLUDED ANALYSIS OF MANUFACTURER AND AGENCY INCIDENT REPORTS, REVIEW OF POLICE REPORTS, ANALYSIS OF THE AGENCY'S FATAL ANALYSIS REPORTING SYSTEM, A VEHICLE OWNER SURVEY, INSPECTION OF TOW VEHICLES/HITCHES AND ANALYSIS OF FAILED PARTS.INCIDENTS OF WELD FAILURE WERE RARE AND ASSOCIATED WITH VERY LOW-SPEED DRIVING (TURNING, BACKING AND SUDDEN STOPPING).INCIDENTS OF BENDING WERE ASSOCIATED WITH IMPROPER TRAILER HITCH ADJUSTMENT OR OVERLOADING. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT SEARCH FILE FOR ADDITION INFORMATION.
PE07025 · Trailer Hitch Receiver Failure
Opened May 14, 2007 · Closed Sep 14, 2007
Status: closed (inferred from source dates) · Trailer Hitches
GM PROVIDED ADDITIONAL DATA REGARDING ALLEGATIONS OF FAILURE OF THE TRAILER HITCH.ODI REVIEWED THAT AS WELL AS OTHER DATA PROVIDED BY PEER MANUFACTURERS.BASED ON OUR REVIEW, ODI FINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.THIS PRELIMINARY EVALUATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA07-013) FOR FURTHER ASSESSMENT AND STUDY OF THIS ISSUE.
Illustration