2003 CHEVROLET ASTRO CARGO VAN AIR BAG DID NOT DEPLOY AT TIME OF COLLISION. ASTRO VAN WAS HIT ON PASSENGER SIDE, FRONT WHEEL WELL & BUMPER. DRIVER WHO HIT VAN WAS EXCEEDING SPEED LIMIT, APPROXIMATELY DOING CLOSER TO 40 MPH IN A 25 MPH ZONE WHEN THEY HIT OUR VAN. WE WERE JUST STARTING TO PROCEED AFTER A STOP SIGN, BARELY DOING 10…
Read full complaint
2003 CHEVROLET ASTRO CARGO VAN AIR BAG DID NOT DEPLOY AT TIME OF COLLISION. ASTRO VAN WAS HIT ON PASSENGER SIDE, FRONT WHEEL WELL & BUMPER. DRIVER WHO HIT VAN WAS EXCEEDING SPEED LIMIT, APPROXIMATELY DOING CLOSER TO 40 MPH IN A 25 MPH ZONE WHEN THEY HIT OUR VAN. WE WERE JUST STARTING TO PROCEED AFTER A STOP SIGN, BARELY DOING 10 - 15 MPH. THE ASTRO VAN WAS DRAGGED APPROXIMATELY 6-7 FEET INTO THE INTERSECTION. THE AIR BAG NEVER DEPLOYED, DRIVER WAS INJURED RIGHT SIDE BACK & RIBS BRUISED AND POSSIBLE CONCUSSION HEAD INJURY TO LEFT SIDE OF HEAD DUE TO FORCE OF IMPACT.
CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO QUICKLY.
Consequence & remedy
Consequence: THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIONAL CONTROL OF THE VEHICLE. IN ADDITION, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE IF FORCES RESULTING FROM THE WHEEL'S DRAGGING ACTION WERE SUFFICIENT TO FRACTURE THE TIE ROD END AND UPPER BALL JOINT CONNECTIONS. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL'S HYDRAULIC BRAKE HOSE, RESULTING IN LOST BRAKING PERFORMANCE FROM THE FRONT BRAKE SYSTEM. VEHICLE STOPPING DISTANCE WOULD INCREASE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Chevrolet Astro Problems, Complaints & Recalls | Skip That Year
Illustration