Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1225–50K
650–75K
775–100K
8100–150K
5150K+
45 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports3 fire reports3 injury reports
What owners actually said
70 reports
60,000 miles · Jul 24, 2003
Air BagsSeat BeltsService Brakes, HydraulicCrashInjury
THE BRAKES MADE A SQUEALING NOISE, AND WAS REPLACED. AFTER THEY WERE REPLACED, THE BRAKES LOCKED UP WHICH RESULTED IN AN ACCIDENT. *JB WHEN THE BRAKES LOCKED, THE VEHICLE RAN INTO A SNOWBANK. ON THE SECOND OCCASION, THE BRAKES LOCKED AND SLID INTO THE PERSON IN FRONT. THE VEHICLE WAS REAR ENDED AND THE AIR BAGS DID NOT D…
Read full complaint
THE BRAKES MADE A SQUEALING NOISE, AND WAS REPLACED. AFTER THEY WERE REPLACED, THE BRAKES LOCKED UP WHICH RESULTED IN AN ACCIDENT. *JB WHEN THE BRAKES LOCKED, THE VEHICLE RAN INTO A SNOWBANK. ON THE SECOND OCCASION, THE BRAKES LOCKED AND SLID INTO THE PERSON IN FRONT. THE VEHICLE WAS REAR ENDED AND THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELTS WERE INOPERATIVE. THE CONSUMER REQUESTED MONEY BACK. *SCC
NHTSA ODI #10019695
Mileage unknown · Jun 26, 2003
Service Brakes, Hydraulic
THE BRAKE PEDAL WAS TO SMALL. WHEN THE CONSUMER APPLIED THE BRAKE, HER FOOT SLIPPED OFF THE BRAKE PEDAL. *NLM *TS *JB
NHTSA ODI #10020151
37,000 miles · May 3, 2003
Electrical SystemFuel System, GasolineSteering
MY 2002 ASTRO VAN HAS BEEN IN THE SERVICE DEPT. AT RON CARTER IN ALVIN TEXAS 11 TIMES, 7 TIMES FOR THE SAME PROBLEM, THE STEERING. ELECTRICAL PROBLEMS 5 TIMES, THE LIGHT FLASHING AND THE LOCKS CLICKING CONSTANTLY. THE BACK DOOR BROKE TWICE FOR NO APPARENT REASON, THE FUEL PUMP FAILING AND NUMEROUS OTHER PROBLEMS, WELL THE ELEC…
Read full complaint
MY 2002 ASTRO VAN HAS BEEN IN THE SERVICE DEPT. AT RON CARTER IN ALVIN TEXAS 11 TIMES, 7 TIMES FOR THE SAME PROBLEM, THE STEERING. ELECTRICAL PROBLEMS 5 TIMES, THE LIGHT FLASHING AND THE LOCKS CLICKING CONSTANTLY. THE BACK DOOR BROKE TWICE FOR NO APPARENT REASON, THE FUEL PUMP FAILING AND NUMEROUS OTHER PROBLEMS, WELL THE ELECTRICAL PROBLEM WAS SUPPOSEDLY FIXED, BUT NOW IS ACTING UP AGAIN, I HAVE 4 CHILDREN AND NEED A SAFE VEHICLE TO DRIVE IN WITH MY KIDS.*JB
NHTSA ODI #10016966
7,200 miles · Apr 8, 2003
Service Brakes, Hydraulic
WHEN THE BRAKES WERE APPLIED, THE PEDAL TRAVELED TO THE FLOOR. *JB ALSO LOST STEERING CONTROL. BLOWN POWER STEERING SHAFT SEAL HAD TO BE REPLACED. *TT
NHTSA ODI #10015459
Mileage unknown · Apr 7, 2003
Service Brakes, Hydraulic
THE ABS SYSTEM FAILED AND CAUSED THE BRAKE PEDAL TO GO TO THE FLOOR. *NLM
NHTSA ODI #10015345
3,000 miles · Mar 31, 2003
Electrical System
THE ALTERNATOR WAS REPLACED SEVERAL TIMES. *JB
NHTSA ODI #10014726
Mileage unknown · Mar 19, 2003
Structure
THE DOOR FAILED TO CLOSE PROPERLY, AND SOMETIMES THE DOOR OPENED ON ITS OWN WHILE DRIVING. *JB
NHTSA ODI #10012126
Mileage unknown · Mar 6, 2003
Power Train
WHEN THE VEHICLE WAS PARKED ON AN INCLINE WITH THE ENGINE RUNNING, THE SHIFT LEVER DID NOT GO INTO ANY OTHER GEAR UNLESS EXCESSIVE FORCE WAS APPLIED.*JB
NHTSA ODI #10010023
Mileage unknown · Jan 13, 2003
Service Brakes, Hydraulic
CONSUMER STATED WHEN HE ATTEMPTED TO APPLY THE BRAKES, THE PEDAL WENT HALF WAY DOWN, IT WAS DISCOVERED THAT THERE WAS A FAULTY MAIN MODULE WHICH CONTROLLED THE BRAKE SYSTEM. DEALER HAS BEEN NOTIFIED. *JB THE VEHICLE LOST IT'S BRAKING POWER ON A STEEP ICY HILL AND SLID WITH THE PEDAL FULLY DEPRESSED. IMMEDIATELY AFTER THE VEH…
Read full complaint
CONSUMER STATED WHEN HE ATTEMPTED TO APPLY THE BRAKES, THE PEDAL WENT HALF WAY DOWN, IT WAS DISCOVERED THAT THERE WAS A FAULTY MAIN MODULE WHICH CONTROLLED THE BRAKE SYSTEM. DEALER HAS BEEN NOTIFIED. *JB THE VEHICLE LOST IT'S BRAKING POWER ON A STEEP ICY HILL AND SLID WITH THE PEDAL FULLY DEPRESSED. IMMEDIATELY AFTER THE VEHICLE WAS REPAIRED, THE BRAKE MODULAR HAD FAILED DURING A TEST DRIVE. *SCC
NHTSA ODI #10003665
Mileage unknown · Nov 20, 2002
Engine And Engine Cooling
WHILE DRIVING A LOUD COMES FROM UNDERNETH THE VEHICLE CAUSING A DISTRACTION. PLEASE ADD ANY ADDITIONAL INFORMATION. TS
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Additional source detail variants (2)
Exterior Lighting:brake Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Exterior Lighting:hazard Flashing Warning Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration