IllustrationTHE PARK PAWL DID NOT ENGAGE WHICH CAUSED THE VEHICLE TO ROLL DOWN HILL WITH 2 CHILDREN IN THE CAR. THEN CRASHED INTO TREES, NO INJURIES INVOLVED. DEALER SAID INTER- LOCK SAFETY SYSTEM MALFUNCTIONED.*AK
1995 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1995 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 446 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports6 fire reports26 injury reports
What owners actually said
446 reportsSOMETIMES THE WINDSHIELD WIPER BLADES DO NOT COME ON. ALSO, WINDSHIELD WIPER MOTOR CUTS OFF WHEN ALREADY IN OPERATION. OWNER HAS REPLACED THE PART. *AK
INTERMITTENTLY WHEN TURNING ON THE WINDSHIELD WIPERS THEY DO NOT COME ON. THE DEALER HAS REPLACED DELAY MODULE WHICH IS SAME PART NUMBER USED IN RECALL # 98V-043. CONSUMER FEELS THIS VAN SHOULD HAVE BEEN INCLUDED IN THE RECALL. *AK
WHILE DRIVING THE VEHICLE THE WINDSHIELD WIPERS SOMETIMES WORK AND SOMETIMES DO NOT WORK, BUT THEY MAY COME ON WHILE DRIVING. WHEN RAINING, THE WIPERS WILL OCCASIONALLY COME ON. DEALER IS NOT AWARE OF THE PROBLEM. *AK
ENGINE STALLS OUT FOR NO REASON/ABS BRAKES DO NOT STOP VEHICLE WHEN BRAKES APPLIED/TRANSMISSION FAILS TO SHIFT INTO REVERSE AND INSTRUMENT PANELLIGHTS STAY ON DURING THE DAY. VEHICLE STILL RUNNING AFTER IGNITION IS TURNED OFF. TAKING TO DEALER AGAIN. *AK
CONSUMER WAS PULLING OUT OF DRIVEWAY, WHEN NOTICED A DRAGGING SOUND UNDERNEATH VEHICLE, LEARNED LATER IT WAS THE FRONT TORSION BAR THAT WAS BROKEN, REPAIRMAN INFORMED CONSUMER THAT THE BAR WAS DEFECTIVE BECAUSE OF THE WAY IT WAS BROKEN. DEALER/MANUFACTURER NOTIFIED. ALSO PARTS ARE AVAILABLE FOR INSPECTION IF NEEDED. *AK
SLIDING PASSENGER DOOR FELL OFF AND HIT OWNER'S 10 YEAR OLD DAUGHTER IN THE HEAD.
DUE TO THE MALFUNCTIONING OF THE SPEED SIGNAL SENSOR, THE VEHICLE BRAKING SYSTEM MALFUNCTIONED, CAUSING EXTENDED STOPPING DIASTANCE, ALMOST RESULTING IN AN ACCIDENT. *AK
WHEN MAKING A SUDDEN STOP THE SEAT BUCKLE ON THE MIDDLE LAP SEAT ON THE REAR BENCH SEAT RELEASED, CAUSING THE OCCUPANT TO HIT THE WINDSHIELD . PLEASE GIVE ANY FURTHER DETAILS. *AK
BLOCK FAILURE.
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
95V175000 · Suspension:front:control Arm:lower Arm
Sep 13, 1995
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
94V188000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Oct 4, 1994
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.