IllustrationCONSUMER HAS HAD MULTIPLE PROBLEMS WITH VEHICLE. BRAKES HAVE BEEN REPLACED 4 TIMES & THE DEALER COULDN'T REMEDY THE SITUATION OR GIVE AN EXPLANATION AS TO WHY. ALSO, WINDSHIELD WIPERS DIDN'T WORK WHEN IT WAS RAINING, AND VEHICLE WOULD SHAKE AT 50MPH. *AK
1995 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1995 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 446 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports6 fire reports26 injury reports
What owners actually said
446 reportsWINDSHIEL WIPERS INTERMITTENTLY QUIT WORKING, JUST LIKE MY 1996 BLAZER AND 1997 K3500. THIS IS A SERIOUS PROBLEM INVOLVING WHAT APPEARS TO BE ALL OF GM'S VEHICLES WHERE THE WIPERS QUIT WORKING AT CRITICAL TIMES OR MAY NOT BEGIN WORKING WHEN NEEDED. PLEASE HELP CONSUMERS TODAY.*AK
I MARKED THE FUEL INJECTION SYSTEM BUT, I AM NOT SURE. THE VAN WOULD NOT STAY RUNNING WHILE NOT GIVING IT THE GAS. THIS IS AN INTERMITTENT PROBLEM. *AK
WINDSHIELD WIPERS WORK INTERMITTENTLY. *AK
AFTER NOTICING HYDRAULIC FLUID ON THE GROUND, OWNER LOOKED UNDER THE TRUCK AND FOUND A HOLE IN THE BRAKE LINE. OWNER NOTIFIED DEALER AND THE MANUFACTURER ABOUT THE PROBLEM. OWNER REPLACED THE BRAKE LINE HIMSELF, THE DESIGN OF THE BRAKE LINE ROUTING RESULTED IN CHAFING AGAINST DRIVE ASSEMBLY, DURING REPAIR THE DEALERSHIP RELOC…
Read full complaint
AFTER NOTICING HYDRAULIC FLUID ON THE GROUND, OWNER LOOKED UNDER THE TRUCK AND FOUND A HOLE IN THE BRAKE LINE. OWNER NOTIFIED DEALER AND THE MANUFACTURER ABOUT THE PROBLEM. OWNER REPLACED THE BRAKE LINE HIMSELF, THE DESIGN OF THE BRAKE LINE ROUTING RESULTED IN CHAFING AGAINST DRIVE ASSEMBLY, DURING REPAIR THE DEALERSHIP RELOCATED THE ROUTING TO PREVENT FURTHER DAMAGE. *AK.ET.
WINDSHIELD WIPERS QUIT WORKING IN THE MIDDLE OF OPERATION, AND SOMETIMES WINDSHIELD WIPERS DO NOT COME ON AT ALL. PROBLEM WAS REPORTED TO DEALERSHIP, BUT PROBLEM HAS NOT BEEN CORRECTED. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
WHEN APPLYING BRAKES FRONT WHEELS LOCKED UP AND VEHICLE WENT INTO A SKID. DEALER STATED MAIN CONTROLLER NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER INFORMATION. *AK
WHILE DRIVING VEHICLE STALLS UNEXPECTEDLY WHICH MAY RESULT IN A CRASH. IN TWO INSTANCES, VEHICLE WOULD NOT RESTART. DEALER REPLACED THE FUEL PUMP TWICE. BUT PROBLEM IS STILL OCCURRING. PLEASE PROVIDE FURTHER INFORMATION. *AK
FRONT TORSION BAR BROKE ON ONE SIDE, CAUSING A LOSS OF SUSPENSION ON FRONT DRIVER'S SIDE. *AK
WHILE DRIVING IN RAINY WEATHER CONDITIONS WINDSHEILD WIPERS BECOME INOPERABLE, IF THE WIRING ON THE MOTOR IS MANEUVERED THE WIPERS BECOME OPERATIONAL. PLEASE GIVE ANY FURTHER DETAILS. *AK
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
95V175000 · Suspension:front:control Arm:lower Arm
Sep 13, 1995
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
94V188000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Oct 4, 1994
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.