IllustrationMANUFACTURE ROUTED BATTERY GROUND LINE ADJACENT TO METALIC BRAKE LINE CAUSING LINES TO CHAFF THUS CAUSING HOLE IN BRAKE LINE FROM MASTER CYLENDER RENDERING REAR BRAKES USELESS
1995 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1995 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 446 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports6 fire reports26 injury reports
What owners actually said
446 reportsWHILE BRAKING VEIHCLE WILL GO TO RIGHT OR LEFT WHICH MAY CAUSE A CRASH. DEALER CANNOT DETERMINE CAUSE. *AK
VEHICLE HAD BEEN PARKED. NOTICED FRONT END WAS SLUMPED OVER. LEFT SIDE WAS ON THE WHEELWELL. TOOK VEHICLE TO AUTOMOBILE REPAIR SHOP & HAD IT PLACED ON THE RACK. INFORMED BY MECHANIC THAT FRONT SUSPENSION TORSION BAR WAS CRACKED. TOOK VEHICLE TO DEALER FOR REPAIRS.*AK
WHILE DRIVING AT APPROXIMATELY 40 MPH TORSION BAR BROKE, CAUSING DRIVER'S SIDE FRONT END TO DROP ON TOP OF TIRE, CONSUMER WAS UNABLE TO TURN STEERING WHEEL. DEALER CLAIMED IT WAS NORMAL FOR TORSION BAR TO BREAK. *AK DRIVER HAD TWO PREVIOUS FAILURE OF IDLER ARMS. ALSO HAD WHEEL ROTOR FAILURE. *YH
WHILE DRIVING AT 50 MPH ANOTHER VEHICLE PULLED IN FRONT , CONSUMER HIT OTHER VEHICLE WITH THE FRONT END. UPON IMPACT, DRIVER'S SIDE AIRBAG DID NOT DEPLOY, CAUSING INJUIRES IN CHEST. NO INDICATIONS OF DEFECT. VEHICLE WAS TOTAL LOSS.*AK
WAS DRIVING HOME & HEARD A LOUD BANG. STEERING WHEEL TILTED TO LEFT. DID NOT HAVE A LOT OF CONTROL OF VEHICLE. VEHICLE TAKEN TO SERVICE STATION WHERE MECHANIC INDICATED THAT TIE ROD END HAD SNAPPED. MANUFACTURER HAD REDESIGNED TIE ROD END AND REPLACED IT. *AK THE PROBLEM CONTINUED AND BOTH LEFT AND RIGHT TORSION BARS WERE…
Read full complaint
WAS DRIVING HOME & HEARD A LOUD BANG. STEERING WHEEL TILTED TO LEFT. DID NOT HAVE A LOT OF CONTROL OF VEHICLE. VEHICLE TAKEN TO SERVICE STATION WHERE MECHANIC INDICATED THAT TIE ROD END HAD SNAPPED. MANUFACTURER HAD REDESIGNED TIE ROD END AND REPLACED IT. *AK THE PROBLEM CONTINUED AND BOTH LEFT AND RIGHT TORSION BARS WERE FOUND TO BE THE CAUSE. *YH
CONSUMER HAS EXPERIENCED SEVERAL PROBLEMS WITH VEHICLE, RIGHT REAR BLINKER AND PARKING BRAKE BULB FAILED. BACK HATCH WOULD NOT OPEN, DOOR WAS LOCKED AND WOULD NOT OPEN, DEALER FOUND LATCH ROD RETAINERS WORN OUT. ALTERNATOR FAILED. SERPENTINE BELT FAILED. AIR CONDITIONER QUIT BLOWING. REAR END WAS ROARING, DEALER REPLACED RE…
Read full complaint
CONSUMER HAS EXPERIENCED SEVERAL PROBLEMS WITH VEHICLE, RIGHT REAR BLINKER AND PARKING BRAKE BULB FAILED. BACK HATCH WOULD NOT OPEN, DOOR WAS LOCKED AND WOULD NOT OPEN, DEALER FOUND LATCH ROD RETAINERS WORN OUT. ALTERNATOR FAILED. SERPENTINE BELT FAILED. AIR CONDITIONER QUIT BLOWING. REAR END WAS ROARING, DEALER REPLACED REAR DIFFERENTIAL. OIL PRESSURE WOULD GO TO ZERO, DEALER REPLACED INDICATOR. VEHICLE EXPERIENCED MISSING, DEALER REPLACED SPARK PLUB AND DISTRIBUTOR CAP, WHEN THE ENGINE COVER WAS REMOVED, DEALER FOUND THE PLUG WIRES SHORTING TO THE CYLINDER HEAD, DEALER REPLACED ALL PLUG WIRES. VEHICLE WOULD TURN, BUT WOULD NOT START, DEALER FOUND FUEL PUMP SHORTED OUT, DEALER REPLACED FUEL PUMP SYSTEM. OIL LEAKING AT PINION AREA, DEALER REPLACED FRONT DIFFERENTIAL AND PINION SEAL. REAR AXLE WAS REPLACED DUE TO REAR AXLE SEAL LEAKING. WHILE DRIVING, LIGHTS ON DASH STARTED BLINKING, ALL INDICATOR NEEDLES AND GAUGES WERE JUMPING BACK AND FORTH, SMOKE CAME OUT OF THE VENTS, CONSUMER TRIED TO STOP VEHICLE, BUT BRAKES AND STEERING FAILED, VEHICLE FINALLY ROLLED TO A STOP, SLIDING DOOR WOULD NOT OPEN, FINALLY DRIVER AND DAUGHTER GOT OUT THROUGH FRONT DOORS, FIRE AND SMOKE CAME FROM UNDER THE HOOD, CONSUMER'S DAUGHTER HAS EXPERIENCED CHEST PAINS DUE TO THIS, CONSUMER HAS TO PAY FOR THE REST OF THE LOAN EVEN THOUGH VEHICLE WAS A TOTAL LOSS. CONSUMER FEELS THIS FIRE OCCURRED DUE TO THE MANY ELECTRICAL PROBLEMS THE VEHICLE EXPERIENCED, SHE IS REQUESTING REIMBURSEMENT, DEALER WOULD NOT HELP HER.
I HAVE HEARD IN THE PAST THAT CHEVROLET HAS HAD TROUBLES WITH THE TRANSMISIONS IN THE CHEVROLET ASTROS. I OWN A CHEVROLET ASTRO AND HAVE EXPERIENCED THE TRANS. SLIPPING I AM LOOKING FOR INFORMATION IN REGAURDS TO ANY FACTORY RECALLS OR HIDDEN WARENTIES FROM THE MANUFACTURE
THE VAN RENTAL COMPANY PURCHASED FIRESTONE FIREHAWK AND BRIDGESTONE-FIRESTONE DUELER (225/75/16) TIRES, THE TIRE TREADS WOULD SEPARATE FROM THE CASING WITH 3000-8000 MILES. MLM
WIPERS FAIL DURNING RAIN OR PERIODS OF HIGH HUMIDITY
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
95V175000 · Suspension:front:control Arm:lower Arm
Sep 13, 1995
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
94V188000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Oct 4, 1994
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.