IllustrationWHEN SLOWING DOWN OR WHEN ANY CHANGES OCCUR IN THE ROAD PAVEMENT OR IN WET WEATHER CONDITIONS, ABS SYSTEM ACTIVATES, CAUSING EXTENDED STOPPING DISTANCE. CAUSE UNKNOWN. DEALER CAN'T IDENTIFY THE PROBLEM. *AK *ML
1995 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1995 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 446 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports6 fire reports26 injury reports
Service Brakes, Hydraulic complaints
105 reportsWHEN APPLYING THE BRAKES THEY DIDN'T LOCK, AND THEY DIDN'T STOP VEHICLE. CONSUMER WENT STRAIGHT THROUGH AN INTERSECTION. *AK
EVERY 16,000 MILES ABS BRAKES WOULD WEAR OUT. ALSO, BRAKE LINING ON FRONT RIGHT WAS REPLACED AT LEAST 3 DIFFERENT TIMES. REST OF THE BRAKES WERE NOT WORKING PROPERLY. WAS INFORMED BY MECHANIC ALL BRAKES WORKED NORMALLY. ABS BRAKES STILL NOT WORKING & THE REGULAR SERVICE BRAKES HAVE TAKEN OVER. WILL BE TAKING VEHICLE BACK T…
Read full complaint
EVERY 16,000 MILES ABS BRAKES WOULD WEAR OUT. ALSO, BRAKE LINING ON FRONT RIGHT WAS REPLACED AT LEAST 3 DIFFERENT TIMES. REST OF THE BRAKES WERE NOT WORKING PROPERLY. WAS INFORMED BY MECHANIC ALL BRAKES WORKED NORMALLY. ABS BRAKES STILL NOT WORKING & THE REGULAR SERVICE BRAKES HAVE TAKEN OVER. WILL BE TAKING VEHICLE BACK TO DEALERSHIP. *AK
WHEN APPLYING THE BRAKES VEHICLE SLOWED DOWN, BUT DID NOT STOP. ALSO THE VEHICLE HAS A SQUEAKING NOISE WHEN APPLYING THE BRAKES. DEALER HAS NOT SEEN VEHICLE. *AK
WHILE COMING DOWN THE STREET THE LIGHT CHANGED TO RED ANNOTHER DRIVER IN FRONT STOPPED FOR THE LIGH. CONSUMER STARTED TO STOP, AND FOR 2 OR 3 SECONDS THE BRAKES STOPPED WORKING. HEARD A BUSY NOISE AND THEN BRAKES STARTED WORKING AGAIN. *AK
WHILE DRIVING AT A SPEED OF 20 MPH THE CONSUMER HAD A COLLISION . THIS HAPPENED IN FOGGY CONDITIONS, YET THE VISIBLE CONDITIONS WERE GOOD. T BRAKE PROBLEM IS ON RECALL #991006000. *AK
INTERMITTENTLY WHEN THE BRAKES ARE APPLIED THE PEDAL BECOMES HARD, RESULTING IN EXTENDED STOPPING DISTANCE. DEALER HAS INSPECTED THE VEHICLE SEVERAL TIMES . THE MANUFACTURER HAS BEEN NOTIFIED. *AK
WHILE DRIVING HAD TO STOP SUDDENLY. ABS BRAKES FELT LIKE THERE WERE ENGAGING, BUT FAILED TO ENGAGE. HAD EXTENDED STOPPING DISTANCE. NEARLY HIT PEDESTRIAN. BEEN TO MECHANIC OFF/ON FOR BRAKE PROBLEMS. CAUSE NOT FOUND. *AK IT TOOK APPROX. 3.5 BLOCKS AFTER THE EMERGENCY STOPPING INCIDENT, BEFORE THE BRAKES WERE ACTING NORMALLY. *JN
WHEN APPLYING THE BRAKES THE FRONT WHEELS LOCK UP AND VEHICLE SKIDS. DLR SAYS MAIN CONTROLLER NEEEDS REPLACED. MJS
ABS BRAKES FAIL TO STOP VEHICLE RIGHT AWAY WHEN APPLIED. WOULD KICK IN LATER. HAD TROUBLE SINCE 1994. THE LAST TIME ABS BRAKES WERE APPLIED, THEY LOCKED UP & ANOTHER VEHICLE WAS REARENDED. AIR BAG DID NOT DEPLOY. TAKING VEHICLE TO DEALER, AGAIN, TO CHECK BRAKES OUT. *AK
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
95V175000 · Suspension:front:control Arm:lower Arm
Sep 13, 1995
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
94V188000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Oct 4, 1994
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.