IllustrationVEHICLE PULLED TO LEFT AT ALL TIMES WHEN APPLYING BRAKES. VEHICLE HAS BEEN TAKEN TO DEALERSHIP 11 TIMES. DEALER REPLACED FRONT SHOCKS/ IDLER ARM/ RESURFACED ROTORS/DID WHEEL ALIGNMENTS, AND REPLACED TIRES. CURRENTLY, DEALER SAID REMEDY WOULD BE A COMPLETE BRAKE JOB. NONE OF THE MENTIONED REPAIRS REMEDIED PROBLEM. *AK
1995 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1995 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 446 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports6 fire reports26 injury reports
Service Brakes, Hydraulic complaints
105 reportsBRAKES DO NOT STOP IN TIME WHEN TRYING TO SLOW DOWN WHILE IT'S RAINING OR SNOWING. *AK
CONSUMER COMPLAINT REGARDING ABS BRAKE SYSTEM. VEHICLE HAS ALWAYS BEEN DIFFICULT TO BRING TO A STOP USING ABS BRAKES, EXCESSIVE EFFORT NEEDED BEFORE VEHICLE WOULD CATCH AND BEGIN TO SLOW DOWN. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
ONGOING PROBLEM WITH LOSS OF STEERING AND BRAKING DUE TO A LEAKAGE. VEHICLE BEEN REPAIRED BY DEALER ON TWO OCCASIONS, AND PROBELM REOCCURRED. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
MANUFACTURE ROUTED BATTERY GROUND LINE ADJACENT TO METALIC BRAKE LINE CAUSING LINES TO CHAFF THUS CAUSING HOLE IN BRAKE LINE FROM MASTER CYLENDER RENDERING REAR BRAKES USELESS
WHILE BRAKING VEIHCLE WILL GO TO RIGHT OR LEFT WHICH MAY CAUSE A CRASH. DEALER CANNOT DETERMINE CAUSE. *AK
WHILE DRIVING AT APPROXIMATELY 40 MPH TORSION BAR BROKE, CAUSING DRIVER'S SIDE FRONT END TO DROP ON TOP OF TIRE, CONSUMER WAS UNABLE TO TURN STEERING WHEEL. DEALER CLAIMED IT WAS NORMAL FOR TORSION BAR TO BREAK. *AK DRIVER HAD TWO PREVIOUS FAILURE OF IDLER ARMS. ALSO HAD WHEEL ROTOR FAILURE. *YH
ABS BRAKE WARNING LIGHT REMAINS ILLUMINATED, INDICATING A MALFUNCTION WITHIN THE SYSTEM, CAUSING THE SYSTEM TO BECOME INOPERABLE. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
ANTI-LOCK BRAKE WARNING LIGHT LIT FOR A LONG TIME. SERVICE SHOP SAID IT IS A FAILED MODULE AND THERE IS A RECALL ON IT. THERE WAS A LOT OF PUBLICITY ON TV NEWS ABOUT THAT TIME ABOUT ABS RECALL ON ASTRO VANS, BUT CHEVROLET DEALER SAYS THEY DON'T KNOW ABOUT IT AND I DON'T SEE IT LISTED AT THIS WEB SITE. HAS THERE BEEN SUCH A RE…
Read full complaint
ANTI-LOCK BRAKE WARNING LIGHT LIT FOR A LONG TIME. SERVICE SHOP SAID IT IS A FAILED MODULE AND THERE IS A RECALL ON IT. THERE WAS A LOT OF PUBLICITY ON TV NEWS ABOUT THAT TIME ABOUT ABS RECALL ON ASTRO VANS, BUT CHEVROLET DEALER SAYS THEY DON'T KNOW ABOUT IT AND I DON'T SEE IT LISTED AT THIS WEB SITE. HAS THERE BEEN SUCH A RECALL?*AK
ONGOING PROBLEM WITH DELAY IN STOPPING DISTANCE AND NOISE COMING FROM THE ENGINE COMPARTMENT WHEN BRAKES ARE APPLIED. FEEL FREE TO PROVIDE FURTHER DETAILS. *AK
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
95V175000 · Suspension:front:control Arm:lower Arm
Sep 13, 1995
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
94V188000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Oct 4, 1994
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.