Electrical SystemEngine And Engine CoolingEquipmentFireInjury
CONSUMER HAS EXPERIENCED SEVERAL PROBLEMS WITH VEHICLE, RIGHT REAR BLINKER AND PARKING BRAKE BULB FAILED. BACK HATCH WOULD NOT OPEN, DOOR WAS LOCKED AND WOULD NOT OPEN, DEALER FOUND LATCH ROD RETAINERS WORN OUT. ALTERNATOR FAILED. SERPENTINE BELT FAILED. AIR CONDITIONER QUIT BLOWING. REAR END WAS ROARING, DEALER REPLACED RE…
Read full complaint
CONSUMER HAS EXPERIENCED SEVERAL PROBLEMS WITH VEHICLE, RIGHT REAR BLINKER AND PARKING BRAKE BULB FAILED. BACK HATCH WOULD NOT OPEN, DOOR WAS LOCKED AND WOULD NOT OPEN, DEALER FOUND LATCH ROD RETAINERS WORN OUT. ALTERNATOR FAILED. SERPENTINE BELT FAILED. AIR CONDITIONER QUIT BLOWING. REAR END WAS ROARING, DEALER REPLACED REAR DIFFERENTIAL. OIL PRESSURE WOULD GO TO ZERO, DEALER REPLACED INDICATOR. VEHICLE EXPERIENCED MISSING, DEALER REPLACED SPARK PLUB AND DISTRIBUTOR CAP, WHEN THE ENGINE COVER WAS REMOVED, DEALER FOUND THE PLUG WIRES SHORTING TO THE CYLINDER HEAD, DEALER REPLACED ALL PLUG WIRES. VEHICLE WOULD TURN, BUT WOULD NOT START, DEALER FOUND FUEL PUMP SHORTED OUT, DEALER REPLACED FUEL PUMP SYSTEM. OIL LEAKING AT PINION AREA, DEALER REPLACED FRONT DIFFERENTIAL AND PINION SEAL. REAR AXLE WAS REPLACED DUE TO REAR AXLE SEAL LEAKING. WHILE DRIVING, LIGHTS ON DASH STARTED BLINKING, ALL INDICATOR NEEDLES AND GAUGES WERE JUMPING BACK AND FORTH, SMOKE CAME OUT OF THE VENTS, CONSUMER TRIED TO STOP VEHICLE, BUT BRAKES AND STEERING FAILED, VEHICLE FINALLY ROLLED TO A STOP, SLIDING DOOR WOULD NOT OPEN, FINALLY DRIVER AND DAUGHTER GOT OUT THROUGH FRONT DOORS, FIRE AND SMOKE CAME FROM UNDER THE HOOD, CONSUMER'S DAUGHTER HAS EXPERIENCED CHEST PAINS DUE TO THIS, CONSUMER HAS TO PAY FOR THE REST OF THE LOAN EVEN THOUGH VEHICLE WAS A TOTAL LOSS. CONSUMER FEELS THIS FIRE OCCURRED DUE TO THE MANY ELECTRICAL PROBLEMS THE VEHICLE EXPERIENCED, SHE IS REQUESTING REIMBURSEMENT, DEALER WOULD NOT HELP HER.
NHTSA ODI #870293
Mileage unknown · Sep 10, 2000
Power Train
I HAVE HEARD IN THE PAST THAT CHEVROLET HAS HAD TROUBLES WITH THE TRANSMISIONS IN THE CHEVROLET ASTROS. I OWN A CHEVROLET ASTRO AND HAVE EXPERIENCED THE TRANS. SLIPPING I AM LOOKING FOR INFORMATION IN REGAURDS TO ANY FACTORY RECALLS OR HIDDEN WARENTIES FROM THE MANUFACTURE
NHTSA ODI #730918
Mileage unknown · Jun 7, 2000
EquipmentPower TrainService Brakes, Hydraulic
CLUNK WHEN PUTTING VEHICLE IN GEAR, AND THE VEHICLE DOES NOT HOLD IN PARK AND REVERSE GEARS DUE TO POSSIBLE TRANSMISSION FAILURE. YH
NHTSA ODI #552524
Mileage unknown · Jul 26, 1999
Power Train
NO SUMMARY
NHTSA ODI #709203
Mileage unknown · Jun 9, 1999
Power Train
KEY WAS IN IGNITION BUT THE ENGINE WAS NOT ACTIVATED. CHILD MOVED AUTOMATIC TRANSMISSION LEVER WITHOUT HOLDING DOWN THE BRAKES, WHICH RESULTED IN VEHICLE ROLLING AWAY. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #839116
Mileage unknown · Oct 19, 1998
Power TrainCrash
THE PARK PAWL DID NOT ENGAGE WHICH CAUSED THE VEHICLE TO ROLL DOWN HILL WITH 2 CHILDREN IN THE CAR. THEN CRASHED INTO TREES, NO INJURIES INVOLVED. DEALER SAID INTER- LOCK SAFETY SYSTEM MALFUNCTIONED.*AK
NHTSA ODI #829131
Mileage unknown · Oct 1, 1998
Engine And Engine CoolingInterior LightingPower Train
ENGINE STALLS OUT FOR NO REASON/ABS BRAKES DO NOT STOP VEHICLE WHEN BRAKES APPLIED/TRANSMISSION FAILS TO SHIFT INTO REVERSE AND INSTRUMENT PANELLIGHTS STAY ON DURING THE DAY. VEHICLE STILL RUNNING AFTER IGNITION IS TURNED OFF. TAKING TO DEALER AGAIN. *AK
NHTSA ODI #828419
Mileage unknown · Oct 10, 1997
Power TrainService Brakes, Hydraulic
BRAKE ROTORS NEEDED TO BE RESURFACED, CAUSING VIBRATION. MJS
NHTSA ODI #604229
Mileage unknown · Mar 17, 1997
Power TrainService Brakes, HydraulicSteering
REAR WHEEL BEARINGS EXPERIENCED EXCESSIVE WEAR. IN ADDITION, REPLACED IDLER ARM/RING AND PINION GEAR/FRONT BRAKE PADS/ROTORS. *AK
NHTSA ODI #808826
Mileage unknown · Dec 2, 1996
Power Train
POWER TRAIN HOUSING/BEARINGS/RINGS AND PINION GEARS WITH SEALS REPLACED.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.
1995 Chevrolet Astro Problems, Complaints & Recalls | Skip That Year
Illustration