Engine And Engine CoolingEquipmentService Brakes, HydraulicCrashInjury
I HAVE HAD PROBLEMS WITH MY 1995 ASTRO VAN 4.03L FROM THE DAY I BOUGHT IT HARD STARTING ASB LOCKING UP DEALER REPLACED EGR VALUE TWICE TOOK BACK WITH SAME PROBLEM 3 MONTHS LATER WAS TOLD NOTHING WRONG COMPUTER DIGITAL CHECK SAID SO NOW I HAVE GOTTEN 2 MECHANICS TO LOOK AT IT AND SAID THE EGR VALVE FUEL LIND STAYS OPEN POURING…
Read full complaint
I HAVE HAD PROBLEMS WITH MY 1995 ASTRO VAN 4.03L FROM THE DAY I BOUGHT IT HARD STARTING ASB LOCKING UP DEALER REPLACED EGR VALUE TWICE TOOK BACK WITH SAME PROBLEM 3 MONTHS LATER WAS TOLD NOTHING WRONG COMPUTER DIGITAL CHECK SAID SO NOW I HAVE GOTTEN 2 MECHANICS TO LOOK AT IT AND SAID THE EGR VALVE FUEL LIND STAYS OPEN POURING OUT GAS THEY WANT TO CHARGE MY 600.00 TO CLEAN OUT THE SLUGE THIS PROBLEM HAS BEEN GOING ON FOR 3 YEARS MY VAN NOW HAS 82000 MILES AND IT SOUNDS AND SMELLS LIKE A MAC TRUCK I ALSO HAS TO REPLACE TO WIPER MOTOR ABOUT 2 YEARS AGO AND I PAID FOR IT I JUST A NOTICE TO REPLACE IT IT NO CHARGE I CANT FIND THE ORGINAL RECEIPT SO I'M OUT ANOTHER120.00 FOR THAT REPAIR ALONG WITH THE 65.00 SO A LOCAL MECHANIC. CAN TELL ME THIS IS A DEFECT FROM CHEVROLET FOR MY ASTRO VAN I HAVE HAD THE BREAKS CHECKED BY THE DEALER ABOUT 6 TIMES THEY INFORMED ME I DIDN'T KNOW HOW TO USE ABS SYSTEM AND THEY WERE FINE IN ALL MY BRAKES LOCKED UP ON I4 IN FLORIDA LAST AUGUST TRYING TO AVOID AN ACCIDENT 4700.00 LATER I WAS IN THE DITCH BECAUSE THE BRAKES LOCKED UP AND MY VAN WENT SLIDING *LA
NHTSA ODI #10041654
Mileage unknown · Aug 6, 2001
EquipmentSuspensionVisibility
I SEE THE SAME THREE PROBLEMS REPORTED ON THE ASTRO...WINDSHIELD WIPERS NOT WORKING, TORSION BAR BREAKING, AND AIR CONDITIONING NOT WORKING. WHEN IS CHEVROLET GOING TO ADDRESS THESE PROBLEMS?
NHTSA ODI #749948
Mileage unknown · Sep 12, 2000
Electrical SystemEngine And Engine CoolingEquipmentFireInjury
CONSUMER HAS EXPERIENCED SEVERAL PROBLEMS WITH VEHICLE, RIGHT REAR BLINKER AND PARKING BRAKE BULB FAILED. BACK HATCH WOULD NOT OPEN, DOOR WAS LOCKED AND WOULD NOT OPEN, DEALER FOUND LATCH ROD RETAINERS WORN OUT. ALTERNATOR FAILED. SERPENTINE BELT FAILED. AIR CONDITIONER QUIT BLOWING. REAR END WAS ROARING, DEALER REPLACED RE…
Read full complaint
CONSUMER HAS EXPERIENCED SEVERAL PROBLEMS WITH VEHICLE, RIGHT REAR BLINKER AND PARKING BRAKE BULB FAILED. BACK HATCH WOULD NOT OPEN, DOOR WAS LOCKED AND WOULD NOT OPEN, DEALER FOUND LATCH ROD RETAINERS WORN OUT. ALTERNATOR FAILED. SERPENTINE BELT FAILED. AIR CONDITIONER QUIT BLOWING. REAR END WAS ROARING, DEALER REPLACED REAR DIFFERENTIAL. OIL PRESSURE WOULD GO TO ZERO, DEALER REPLACED INDICATOR. VEHICLE EXPERIENCED MISSING, DEALER REPLACED SPARK PLUB AND DISTRIBUTOR CAP, WHEN THE ENGINE COVER WAS REMOVED, DEALER FOUND THE PLUG WIRES SHORTING TO THE CYLINDER HEAD, DEALER REPLACED ALL PLUG WIRES. VEHICLE WOULD TURN, BUT WOULD NOT START, DEALER FOUND FUEL PUMP SHORTED OUT, DEALER REPLACED FUEL PUMP SYSTEM. OIL LEAKING AT PINION AREA, DEALER REPLACED FRONT DIFFERENTIAL AND PINION SEAL. REAR AXLE WAS REPLACED DUE TO REAR AXLE SEAL LEAKING. WHILE DRIVING, LIGHTS ON DASH STARTED BLINKING, ALL INDICATOR NEEDLES AND GAUGES WERE JUMPING BACK AND FORTH, SMOKE CAME OUT OF THE VENTS, CONSUMER TRIED TO STOP VEHICLE, BUT BRAKES AND STEERING FAILED, VEHICLE FINALLY ROLLED TO A STOP, SLIDING DOOR WOULD NOT OPEN, FINALLY DRIVER AND DAUGHTER GOT OUT THROUGH FRONT DOORS, FIRE AND SMOKE CAME FROM UNDER THE HOOD, CONSUMER'S DAUGHTER HAS EXPERIENCED CHEST PAINS DUE TO THIS, CONSUMER HAS TO PAY FOR THE REST OF THE LOAN EVEN THOUGH VEHICLE WAS A TOTAL LOSS. CONSUMER FEELS THIS FIRE OCCURRED DUE TO THE MANY ELECTRICAL PROBLEMS THE VEHICLE EXPERIENCED, SHE IS REQUESTING REIMBURSEMENT, DEALER WOULD NOT HELP HER.
NHTSA ODI #870293
Mileage unknown · Jun 7, 2000
EquipmentPower TrainService Brakes, Hydraulic
CLUNK WHEN PUTTING VEHICLE IN GEAR, AND THE VEHICLE DOES NOT HOLD IN PARK AND REVERSE GEARS DUE TO POSSIBLE TRANSMISSION FAILURE. YH
NHTSA ODI #552524
Mileage unknown · Jul 21, 1999
Equipment
THERE IS A LOUD NOISE COMING FROM AIR CONDITIONER COMPRESSOR UNDER THE HOOD. DEALER SAYS IT NEEDS TO BE REPLACED. *AK
NHTSA ODI #842765
Mileage unknown · Jan 12, 1999
EquipmentFire
THIS UNIT WAS RECENTLY REPLACED TO HAVE IT FAIL AGAIN AND CAUSE THIS FIRE TO OCCUR. CONTACT JOHN AT THE THE ABOVE LISTED INFORMATION FOR MORE DETAILS
NHTSA ODI #702163
Mileage unknown · Mar 10, 1998
Equipment
THE AIR CONDITIONER BLOWS WARM AIR. DEALER HAS SEEN VEHICLE 3 TIMES AND STILL NO SOLUTION. *AK
NHTSA ODI #821511
Mileage unknown · Mar 3, 1998
EquipmentExterior LightingFuel System, Gasoline
AIR CONDITIONER BLOWS HOT AIR DUE TO COMPRESSOR HOSE SPLITTING, CAUSING FREON TO LEAK.
NHTSA ODI #531739
Mileage unknown · Nov 28, 1997
EquipmentService Brakes, HydraulicTires
ABS ELECTRONIC MODULE FAILED.
NHTSA ODI #525491
Mileage unknown · Jan 28, 1997
EquipmentSeat BeltsService Brakes, Hydraulic
SLIDING DOOR HAS BEEN ADJUSTED 4 TIMES, BUT STILL RATTLES AS IF THE LATCH IS NOT PULLING IT CLOSED TIGHT.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence & remedy
Consequence: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence & remedy
Consequence: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.
1995 Chevrolet Astro Problems, Complaints & Recalls | Skip That Year
Illustration