IllustrationCONSUMER STATES THAT GEAR SHIFT WILL LOCK IN GEAR PERIODICLY. NLM
1993 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1993 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 135 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports4 fire reports6 injury reports
Power Train complaints
20 reportsVEHICLE WAS PARKED. STARTED THE ENGINE, STEPPED ON BRAKE AND SHIFTER WOULD NOT COME OUT OF PARK. CONTACTED DEALER. DEALER WAS NOT ABLE TO HELP. THIS HAPPENED INTERMITTENTLY. DEALER SAID THAT IF TURN KEY HALFWAY THAT CAN SHIFT TO NEUTRAL, AND THEN TURN KEY ALL THE WAY ON. DOING THIS WITH POWER BRAKES AND ENGINE OFF THE VE…
Read full complaint
VEHICLE WAS PARKED. STARTED THE ENGINE, STEPPED ON BRAKE AND SHIFTER WOULD NOT COME OUT OF PARK. CONTACTED DEALER. DEALER WAS NOT ABLE TO HELP. THIS HAPPENED INTERMITTENTLY. DEALER SAID THAT IF TURN KEY HALFWAY THAT CAN SHIFT TO NEUTRAL, AND THEN TURN KEY ALL THE WAY ON. DOING THIS WITH POWER BRAKES AND ENGINE OFF THE VEHICLE WILL ROLL. *AK *ML
ENGINE VALVE GUIDE SEALS FAILED. YH
WHILE CORNING AT 15 MPH FRONT OF THE VEHICLE DROPPED DOWN, CAUSING THE AXLE TO BREAK. *AK
THE ABS SWITCH HAS GONE OUT CAUSING THE GEARS TO NOT SHIFT. THE VEHICLE IS STUCK IN PARK POSITION. DLR HAS REPLACED THE ABS SWITCH 3 TIMES BEFORE AND PROBLEM STILL EXIST. MJS
THE GEAR SHIFT RELEASE LOCKS UP. DEALER HAS REPAIRED THE VEHICLE TWO TIMES, AND THE PROBLEM STILL EXISTS. MANUFACTURER HAS BEEN NOTIFIED. *AK
VEHICLE FAIL TO SHIFT FROM PARK POSITION TO DRIVE WHEN BRAKES ARE APPLIED. HAD PROBLEM REPAIRED PREVIOUSLY UNDER TSB #93C56A. HAS HAPPENED AT LEAST 4 DIFFERENT TIMES. THE SHIFTING PROBLEM HAPPENS ONLY WHEN IT'S HOT. TAKING VEHICLE BACK TO DEALER. *AK
MOTOR MOUNTS AND TRANSMISSION MOUNTS BROKE AT THE SAME TIME. THIS WAS DISCOVERED BY DEALERSHIP WERE VAN WAS TAKEN FOR SERVICE FOR ENGINE TROUBLE. MOUNTS WERE REPLACED BY DEALER SHIP AT OWNER'S EXPENSE. THE ORIGINAL MOUNTS WERE REPLACED IN OCTOBER OF 96. FIRST WITH 73,412 MILES. *AK
THE VAN WILL NOT SHIFT INTO IN DRIVE OR REVERSE UNLESS IT IS STARTED IN NEUTAL FIRST. THE PROBLEM WAS CORRECTED ONCE IN 1994 FREE OF CHARGE. DEALER IS AWARE OF CURRENT PROBLEM. HOWEVER, PROBLEM HAS NOT BEEN CORRECTED. *AK
THE VAN WAS IN THE PARKING GEAR WITH THE IGNITION OFF, AND THE GEAR SHIFT WENT FROM PARK TO DRIVE, CAUSING THE VAN TO ROLL FORWARD. BEFORE THIS HAPPENED, THE GEAR SHIFT WAS STUCK IN THE PARKING GEAR FOR ABOUT 5 OR 10 MINUTES, AND RIGHT AFTER TURNING OFF THE ENGINE THIS INCIDENT HAPPENED. THE PARK SOLENOID AND THE CRUISE CONTROL …
Read full complaint
THE VAN WAS IN THE PARKING GEAR WITH THE IGNITION OFF, AND THE GEAR SHIFT WENT FROM PARK TO DRIVE, CAUSING THE VAN TO ROLL FORWARD. BEFORE THIS HAPPENED, THE GEAR SHIFT WAS STUCK IN THE PARKING GEAR FOR ABOUT 5 OR 10 MINUTES, AND RIGHT AFTER TURNING OFF THE ENGINE THIS INCIDENT HAPPENED. THE PARK SOLENOID AND THE CRUISE CONTROL VALVE WAS REPLACED BY A MECHANIC. *AK
Official recalls
194V177000 · Seats:front Assembly:head Restraint
Sep 14, 1994
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Remedy: SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.